RoadVitals

2011 Freightliner Business Class M2 106V Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest May 18, 2011
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

11V289000

TRAILER HITCHES:FIFTH WHEEL ASSEMBLY

May 18, 2011
2,342 units potentially affected
The defect: DTNA IS RECALLING CERTAIN MODEL YEAR 2011 BUSINESS CLASS M2, AND CORONADO, MODEL YEAR 2011-2012 CASCADIA VEHICLES EQUIPPED WITH FONTAINE ULTRA LT FIFTH WHEELS AND MANUFACTURED FROM APRIL 7, 2010, THROUGH MARCH 7, 2011. DURING THE COUPLING PROCESS ON VEHICLES EQUIPPED WITH PRE-MODIFICATION FONTAINE ULTRA LT FIFTH WHEELS, IT IS POSSIBLE FOR THE DRIVER TO PARTIALLY CLOSE THE FIFTH WHEEL LOCK, AND IF RELYING ON A TUG TEST (PULL TEST), AND NOT PERFORMING THE REQUIRED VISUAL INSPECTION, THINK THAT THE FIFTH WHEEL LOCK IS PROPERLY COUPLED TO THE TRAILER KING PIN, WHEN IN FACT, IT IS NOT.
The risk: IF THE TRACTOR IS NOT FULLY CONNECTED TO THE TRAILER, THE TRAILER MAY DISENGAGE WHILE IN USE, INCREASING THE RISK OF A CRASH.
The remedy: FONTAINE NOTIFIED OWNERS IN FEBRUARY 2011, AND IS HANDLING THE REMEDY FOR THIS CAMPAIGN. FONTAINE IS IN THE PROCESS OF RETROFITTING ALL AFFECTED VEHICLES, FREE OF CHARGE. OWNERS MAY CONTACT FONTAINE AT 1-800-874-9780 OR DTNA AT 1-800-547-0712.
DAIMLER TRUCKS NORTH AMERICAManufacturer number FL-608View on NHTSA.gov
11V160000

EXTERIOR LIGHTING:HEADLIGHTS

Mar 10, 2011
301 units potentially affected
The defect: DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2011 BUSINESS CLASS M2 106V INCOMPLETE CHASSIS CAB VEHICLES, MANUFACTURED FROM JULY 19, 2010, THROUGH JANUARY 14, 2011. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE HEADLIGHTS ON SOME VEHICLES MAY HAVE BEEN INSTALLED MORE THAN 54" FROM THE ROAD SURFACE.
The risk: HEADLIGHTS INSTALLED AT HEIGHTS OUTSIDE OF THE PARAMETERS SET BY THE SAFETY STANDARD MAY NOT FULLY ILLUMINATE ROAD SURFACES OR MAY INHIBIT THE ABILITY OF MOTORISTS TO SEE VEHICLES INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL INSPECT THE HEADLAMP HEIGHT AND REPLACE ANY NONCONFORMING HEADLIGHTS WITH NEW HEADLIGHTS THAT LOWER THE BULB CENTER SUCH THAT THE HEADLIGHTS MEET THE SAFETY STANDARD FREE OF CHARGE. AN INTERIM LETTER WAS SENT TO OWNERS ON JUNE 1, 2011. THE NOTIFICATION LETTER TO NOTIFY OWNERS THAT THE REMEDY IS NOW AVAILABLE WAS MAILED ON OCTOBER 10, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
DAIMLER TRUCKS NORTH AMERICAManufacturer number FL-592View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources