RoadVitals

1996 Freightliner Fs-65

Recalls, owner-reported complaints, investigations and safety data

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
0
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Latest Jul 12, 2004
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains no NHTSA owner-reported complaints for the 1996 Freightliner Fs-65. 2 safety recalls have been issued covering this model year.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Safety recalls

2 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
04V343000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Jul 12, 2004
3,200 units potentially affected
The defect: ON CERTAIN SCHOOL BUSES CHASSIS EQUIPPED WITH CATERPILLAR ENGINES AND HYDRAULIC BRAKES. A BRAIDED GROUND STRAP FOR THE STARTER MAY RUB ON A STEEL CHASSIS BRAKE LINE POTENTIALLY CAUSING A FLUID LEAK.
The risk: A BRAKE FLUID LEAK CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE THE STOPPING DISTANCE, WHICH COULD RESULT IN A CRASH.
The remedy: DEALERS WILL INSPECT THE BRAKE LINE AND REPLACE IT, IF NECESSARY. THE BRAIDED GROUND STRAP WILL BE REPLACED WITH AN INSULATED CABLE. THE RECALL BEGAN ON AUGUST 10, 2004. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
FREIGHTLINER LLCManufacturer number FL-421View on NHTSA.gov
02V248000

VEHICLE SPEED CONTROL

Sep 16, 2002
818 units potentially affected
The defect: ON CERTAIN SCHOOL BUS CHASSIS WITH CUMMINS ISB ENGINES WITH MECHANICAL THROTTLE, THE THROTTLE CABLE CAN VIBRATE EXCESSIVELY AND BREAK NEAR THE END FITTING THAT ATTACHES TO THE ENGINE LINKAGE.
The risk: THIS CAN RESULT IN A LOSS OF THROTTLE CONTROL, INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL REMOVE AND REPLACE THE THROTTLE CABLE WITH A NEW DESIGN. OWNER NOTIFICATION BEGAN ON FEBRUARY 17, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
FREIGHTLINER CORPORATIONManufacturer number FL-398View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

No owner complaints recorded for this model year

Either none have been filed with NHTSA, or this vehicle is too new for reports to have accumulated.

Compare model years

Complaint and recall counts across every year of this model

Freightliner Fs-65 by model year
YearComplaintsRecallsInvestigationsIssue Index
2006010—
2005110—
2002531—
2001124146.1
2000126144.9
1999271—
1998140—
1997031—
1996Viewing020—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.