2002 Freightliner Fs-65 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2002 Freightliner Fs-65, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure480.0%
- Fuel system120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
FRAME IS CRACKED AND NEARLY SEPARATED ABOVE REAR AXLE. *TR
TL* THE CONTACT OWNS A 2002 FREIGHTLINER FS65 SCHOOL BUS. THE CONTACT STATED THAT THE CROSS MEMBER FRAME WAS CRACK. THE CONTACT MENTIONED THAT THE FAILURE WAS FOUND AFTER A ROUTINE MAINTENANCE WAS COMPLETED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO OFFERED TO PAY FOR THE PARTS NEEDED FOR THE REPAIRS. THE VEHICLE WAS NOT REPAIR. THE FAILURE MILEAGE WAS 172,982.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
ROSEAU SCHOOL DISTRICT OPERATES A FLEET OF 26 BUSES COVERING APPROX. 1000 SQUARE MILES IN AREA. IN 1999 ROSEAU SCHOOLS BEGAN PURCHASING BUSES WITH THE CUMMINS ISB ENGINES (AN ALL ELECTRONIC ENGINE REPLACING THE OLDER "B" ENGINES). THE DISTRICT NOW HAS 8 UNITS WITH THIS PARTICULAR ENGINE. THE DISTRICT HAS BEEN EXPERIENCING TOO MANY PROBLEMS WITH SENSORS, CHECK ENGINE LIGHTS COMING ON AND POWER DERATING WHEN OPERATING THESE ENGINES. A COMMON PROBLEM IS LIFT PUMP FAILURE CAUSING RETOACTIVE FAILURE TO THE INJECTION PUMP (CUMMINS NAME FOR THE INJECTION PUMP IS THE VP44 PUMP). WHEN PUMP FAILURE OCCURS A NUMBER OF THINGS MAY HAPPEN - EITHER THE ENGINE MAY GO INTO THE LIMP MODE WHICH WILL LET THE ENGINE STILL RUN BUT UNDER RESTRICTED POWER, THE ENGINE MAY LOSE POWER AND WITHIN SECONDS RETURN TO FULL POWER OR THE ENGINE MAY JUST STOP AND NOT RESTART. IN THE SCHOOL BUSING INDUSTRY ANY OF THESE TYPE OF FAILURES COULD PRESENT ITSELF AS A SERIOUS SAFETY HAZARD FROM THE BUS SLOWING DOWN AND BEING REARENDED BY ANOTHER VEHICLE, THE LOSS OF POWER WHEN BRAKING OR TURNING CAUSING LOSS OF BRAKES OR POWER STEERING, THE LOSS OF POWER CAUSING STALLING OF THE UNIT IN AN INTERSECTION OR WORSE YET WHEN GOING ACROSS A RAILROAD INTERSECTION. IN OUR SITUATION IN NORTHERN MINNESOTA WE ARE SOMETIMES RUNNING IN SUB-ZERO TEMPERATURES (THIS PAST WEEK AS COLD AS -40 DEGREES BELOW 0). A STRANDED SCHOOL BUS OF KIDS IN THOSE TEMPERATURES COULD CREATE REAL PROBLEMS. THE LIST GOES ON AND ON OF WHAT MAY HAPPEN OR IN SOME CASES HAS ALREADY HAPPENED. OTHERS ARE HAVING SIMILAR PROBLEMS.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .