2023 Genesis GV80 Fuel system Problems

The vehicle experienced a failure of the High Pressure Fuel Crossover Pipe, a safety defect subject to NHTSA Recall 26V-229 (Manufacturer Campaign 033G). While operating the vehicle over 200 miles from home, a strong odor of raw fuel was detected inside and outside the vehicle. The vehicle was immediately parked at an authorized Genesis dealership due to the risk of pressurized fuel leaking onto hot engine components and igniting an engine compartment fire. The dealership confirmed the defect and performed the recall service, completing and invoicing the repair order on August 5, 2026. However, the manufacturer failed to fulfill its statutory duty to provide a remedy without charge and within a reasonable time under 49 U.S.C. § 30120: Unreasonable Logistics Delay: Following the completed repair on August 5, 2026, the manufacturer failed to arrange flatbed transport back to the home state dealership until August 21, 2026—leaving the vehicle stranded on the out-of-state lot for 16 calendar days solely due to internal corporate logistics delays. Failure to Remedy Without Charge: The manufacturer provided no loaner vehicle. After directing the owner to secure rental transportation, the manufacturer retroactively imposed an undisclosed $60/day reimbursement cap—a limitation that does not appear anywhere in the official federal recall notice. This action shifted over $1,100 of out-of-pocket rental and carrying expenses directly onto the consumer. The replaced/inspected fuel pipe assembly was serviced and recorded by the authorized dealership under Warranty Claim Campaign 257.

NHTSA ID

11765830

Incident

Jul 26, 2026

I am submitting this complaint regarding the handling of a safety recall on my 2023 Genesis GV80. During an approximately seven-week service visit at an authorized Genesis dealership, I was verbally informed that the applicable safety recall had been completed. Based on my subsequent interactions, Genesis Corporate also appeared to believe the recall had been performed. However, the recall was not documented on my repair order and was ultimately completed later by a different authorized Genesis dealership (Genesis of Weatherford). I am concerned that a safety recall had been verbally represented as completed when it had not actually been performed, resulting in my vehicle being returned to me with an outstanding safety recall still open. I request that NHTSA review the handling and documentation of this recall. The attached repair orders are all from the same visit, and incorrectly showing as two visits. The vehicle was dropped off at Norm Reeves Genesis of Irving on Jun 23, and remained in their possession until the vehicle was ultimately returned to me on August 11th. The recall was not completed, nor was the principle failure (P213800) remedied. This concern is particularly troubling because my vehicle has also experienced a separate recurring safety-related propulsion defect (P2138/P213800). After yet another authorized Genesis dealer recently returned the vehicle stating it could not reproduce that fault, it recurred within approximately 24 hours and caused the vehicle to enter reduced-power/limp mode while my wife and two young daughters were merging onto a highway. While this complaint concerns the handling of the recall itself, I believe the pattern of unresolved safety-related issues and inaccurate repair completion records warrants NHTSA's review. I have a case with Genesis Motor America, Case #43043015, thoroughly documenting all of this. Genesis has offered me no goodwill or viable remedy, aside from "try taking it to another dealer."

NHTSA ID

11758086

Incident

Jul 29, 2026

The contact owns a 2023 Genesis GV80. The contact stated that while pulling into traffic, the vehicle stalled. The accelerator was depressed, but the vehicle failed to move. There were no warning lights illuminated. The contact stated that the failure was due to NHTSA Campaign Number: 24V282000 (Fuel System, Gasoline). The contact contacted AAA, who rest drove the vehicle but eventually towed the vehicle. The vehicle was towed to the local dealer, where it was diagnosed that the fuel pump needed to be replaced. The manufacturer was contacted and provided a case. The failure mileage was approximately 6,700.

NHTSA ID

11738023

Incident

Apr 1, 2026

Mileage

6,700 mi

Stalls or Stops while driving. Increased RPM when gearing down and lunging with zero fuel pedal applied. Lunging/delayed forward motion from stop with acceleration. Electrical system random issues including unable to hold a charge, parasitic battery drain.

NHTSA ID

11604707

Incident

Feb 23, 2023

The contact owns a 2023 Genesis GV80. The contact stated that while driving at an undisclosed speed, the vehicle independently turned off with several unknown warning lights illuminated. The contact restarted the vehicle. The contact received notification of NHTSA Campaign Number: 24V282000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was taken to the dealer however, the failure could not be duplicated. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 15,000. VIN tool confirms parts not available.

NHTSA ID

11585502

Incident

Apr 7, 2024

Mileage

15,000 mi

When I was driving my 2023 GV 80, I was applying pressure onto the gas pedal and the car suddenly started jerking. The car was not accelerating then the check engine sign came on and then the car completely turned off. Then I restarted the car and it was moving really slow. Similar incident happened few other times and luckily I was able to pull over to the parking lot after turning on the hazard light. I drove my car over to the dealership and dropped it off. I am afraid that someone is going to get killed in an accident while they're driving on the highway or crossing the streets

NHTSA ID

11544854

Incident

Aug 15, 2023

I was driving and the car just stopped in the middle of the road. I had to turn the car off and restart. Once I did the car wouldn’t get any speed but the RPM would go up to 4 or 5. I finally got the car home and had it towed the next morning. After 9 days in the shop, I was advised it needed a new fuel pump but no ETA on when the car will be repaired.

NHTSA ID

11537771

Incident

Aug 1, 2023

Car engine stalled multiple times after a stop. Once car did that right after light turned green and I tried to accelerate. Almost causing accident by getting hit by behind. Also did it in parking lot, what happens the gages stop showing information and only the miles driven on the bottom left. Twice had to turn car on and off, once it was able to start back up on its own after pressing accelerator. Dropped off vehicle in dealer today for repair, they mentioned prior year models issue was related to fuel pump. No warning lamps or system failure notification, just some information on dash going away for a bit.

NHTSA ID

11534417

Incident

Jul 23, 2023