RoadVitals

2002 GMC C/K Pickup Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
5
Latest Feb 21, 2012
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
4
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2002 GMC C/K Pickup, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes240.0%
  • Airbags120.0%
  • Interior & seats120.0%
  • Other / unspecified120.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

2
reports

From owner reports, verbatim

WHILE ATTEMPTING TO STOP IN MY DRIVEWAY, I LOST BRAKING POWER... PEDAL WENT TO THE FLOOR AFTER A FEW PUMPS. BRAKE FLUID OUT ON THE GROUND. INSPECTION REVEALED REAR BRAKE LINE FAILURE BECAUSE OF CORROSION. THE TRUCK HAD 56,337 MILES AT THE TIME. IN SEPTEMBER 2011, THE FRONT LINES FAILED BECAUSE OF CORROSION WHILE OUT DRIVING ON THE ROADS. THE CORROSION WAS SEVERE OVERALL AND I HAD THE ENTIRE FRONT BRAKE LINE SYSTEM REPLACED FROM THE MASTER CYLINDER DOWN RATHER THAN THE PARTIAL BRANCH THAT HAD BURST. AT THE TIME OF THE FRONT LINE FAILURE, THE VEHICLE ONLY HAD 58,555 MILES ON IT. IT IS WORTH NOTING THAT THE CORROSION WAS ESPECIALLY SEVERE AT THE CONTACT POINTS: WHERE FASTENERS HELD THE LINES TO THE CHASSIS AND WHERE THEY MET JUNCTION BOXES/BLOCKS. THIS BRAKE LINE ISSUE APPEARS TO BE A COMMON ONE AND IS WORTHY OF THIS REPORT. WITH SO FEW MILES, I CAN'T IMAGINE WHY THIS PROBLEM IS OCCURRING. FURTHER, WITH THE COST OF THESE VEHICLES, WHY WOULDN'T GENERAL MOTORS USE CORROSION RESISTANT MATERIALS FOR BRAKE LINES? *TR

NHTSA ID 10448615 · filed Feb 21, 2012

FAULTY DISC BRAKE ROTORS ON GENERAL MOTOR CARS AND TRUCKS. EVEN THOUGH G.M. DEALERS ACKNOWLEDGE PROBLEM REFUSE TO CORRECT WITHOUT OWNER PAYING. COULD POSSIBLY CAUSE ACCIDENT ON BRAKE FAILURE.*AK

NHTSA ID 10116744 · filed Apr 11, 2005

Too few reports in this category for a page of its own — they appear in the full complaint list.

Airbags

Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.

1
report

From owner reports, verbatim

ONE OF OUR 2002 GMC PICKUPS WAS INVOLVED IN A FRONTAL COLLISION THAT WAS SEVERE ENOUGH TO BEND THE FRAME AND TOTAL THE TRUCK BUT THE AIR BAGS DID NOT DEPLOY. DUE TO THE AMOUNT AND TYPE OF DAMAGE I BELIEVE THERE IS A PROBLEM. I CONTACTED GM CUSTOMER SERVICE BUT THERE DID NOT SEEM TO BE ANY INTEREST. *JB

NHTSA ID 10010354 · filed Mar 12, 2003

Too few reports in this category for a page of its own — they appear in the full complaint list.

Interior & seats

Reports naming seats, latches, locks, linkages and interior fittings.

1
report

From owner reports, verbatim

INSTRUMENT PANEL FAILED COMPLETELY WITHOUT WARNING. *AK

NHTSA ID 10038365 · filed Sep 8, 2003

Too few reports in this category for a page of its own — they appear in the full complaint list.

Other / unspecified

Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.

1
report

From owner reports, verbatim

GENERAL MOTORS HEAVY DUTY HITCH ON 1999-PRESENT TRUCKS & SUVS. RATED FOR 1500 LBS TOUNGE WEIGHT & 15,000 LBS TOTAL W/WEIGHT DIST. FLEXES UNDER LIGHT LOAD COMNDITIONS WHEN USING WEIGHT DISTRUBITION. POTENTIAL METAL FATIGUE AND FAILURE(TRAILER BREAKING LOOSE) NOTHING WAS DONE BY MY DEALER, I REPLACED THE HITCH MYSELF WITH AN AFTERMARKET PRODUCT.*AK

NHTSA ID 10080608 · filed Jul 8, 2004

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .