2005 GMC Canyon Problems

INSTALLED NEW BRAKE LIGHTS DID YOU BRAKE SWITCH UNDER THE BRAKE PEDAL STILL SHOWING SIGNS OF NO BRAKE LIGHTS ON MY VEHICLE I'LL BRAKE BALLS HAVE BEEN REPLACE. *TR

THE BRAKE LINES AND THE ENTIRE FRAME IS RUSTED OUT. THERE ARE BIG WHOLES IN THE FRAME. THE GARAGE WOULDN'T EVEN PUT IT ON THE LIFT, BECAUSE IT WAS SO BAD. HAVE REPLACED BREAKS AND STILL THE TRUCK HAS BREAK ISSUES

MY 2005 GMC CANYON CONTINUES TO HAVE ISSUES WITH THE PASSLOCK II SYSTEM. NO MODIFICATIONS HAVE BEEN MADE TO THE IGNITION SWITCH, KEYS, OR ANY OTHER ELECTRICAL SYSTEM. THE PASSLOCK PREVENTS ME FROM STARTING MY TRUCK BECAUSE FOR SOME REASON THE COMPUTER THINKS IT IS TRYING TO BE STOLEN. THE LAST TIME THIS ISSUE OCCURED, MY TRUCK WAS PARKED IN MY GARAGE. WHEN ATTEMPTED TO START, THE TRUCK CRANKED BUT DID NOT START AND THE PASSLOCK LIGHT CAME ON. I HAD TO SIT AND WAIT FOR 10 MINUTES UNTIL THE LIGHT WENT OFF. THE PROBLEM WAS I WAS TRYING TO DRIVE MYSELF TO THE EMERGENCY ROOM BECAUSE I HAD JUST BEEN BITTEN BY A DOG.

I GOT A SAFETY BULLETIN FROM GMC #14609 STATING THAT THERE IS A PROBLEM WITH MY AIR BAG LIGHT,. IT CAN GO ON DUE TO WIRES IN THE REAR DOOR BREAKING, THE AIR BAG CAN GO OFF ALSO. THIS IS A SAFETY ISSUE WITH THE AIR BAGS, I HAVE THE PROBLEM WITH THE AIR BAG LIGHT ON. THEY SAID THEY WOULD FIX IT OR REIMBURSE ME IF I PAID IN THE PAST TO HAVE IT FIXED. WELL THEY SAID I WAS OFF OF WARRANTY 1-15 . THIS IS A SAFETY ISSUE, THE DEALER WILL NOT FIX IT FOR FREE. WHY DID THEY SEND ME THIS BULLETIN WITH MY VIN NUMBER ATTACHED? I HAVE HAD NOTHING BUT PROBLEMS WITH THIS GMC TRUCK, YOU NAME IT IT HAS HAD A PROBLEM. MOSTLY ELECTRICAL SYSTEM FAILURE. THE AIR BAG ISSUE SHOULD BE FIXED BY GMC FREE OF CHARGE WHICH THEY STATE IN THE LETTER, THERE TELLING ME I AM A FEW MONTHS PAST THE 10 YEAR DEAD LINE. THAT IS A DISGRACE THIS IS A SAFETY ISSUE AND SHOULD BE COVERED BY GMC IF IT IS A DESIGN PROBLEM LIKE ALL THE OTHER PROBLEMS I AM HAVING. THEY ARE GETTING AWAY WITH THIS AND THE AIR BAG CAN GO OFF WHILE DRIVING AND CAUSE AN ACCIDENT. I AM HOLDING THEM LIABLE FOR THIS PROBLEM. WHAT CAN I DO ABOUT THIS THEY ARE NOT HELPING ME WITH THIS SAFETY ISSUE. THANKS, TOM

MY TRUCK IS EXHIBITING AN ISSUE IN WHICH THE GM PASSLOCK SYSTEM DISABLES THE FUEL AND ENGINE BECAUSE OF SOME MALFUNCTION. THIS SYSTEM IS INTENDED TO DISABLE THE FUEL SYSTEM ON A VEHICLE IF IT DETECTS THAT THE IGNITION HAS BEEN TAMPERED WITH OR IN IMPROPER KEY HAS BEEN USED TO TRY AND START THE VEHICLE. MY ISSUE IS THAT INTERMITTENTLY WHEN I TRY TO START MY TRUCK WITH THE FACTORY KEY, THE PASSLOCK SYSTEM ENGAGES AND DOES NOT ALLOW ME TO START MY TRUCK. I HAVE TO WAIT 10 MINUTES IN ORDER FOR THE PASSLOCK SYSTEM LIGHT TO TURN OFF ON THE DASHBOARD. SOMETIMES MY TRUCK WILL START AFTER THIS 10 MINUTE LOCKOUT PERIOD. IT HAS HAPPENED BEFORE WHERE MY TRUCK WILL FAIL TO START AFTER THE FIRST LOCKOUT PERIOD AND I HAVE TO WAIT ANOTHER 10 MINUTES. ONCE THE PASSLOCK SYSTEM ALLOWS ME TO START THE ENGINE, MY TRUCK RUNS FINE WITH NO ISSUES. IN MY OPINION, THIS IS A SERIOUS SAFETY CONCERN. IN ANY EMERGENCY SITUATION, I WOULD HOPE TO DEPEND ON MY TRUCK STARTING. THIS MALFUNCTIONING PASSLOCK SYSTEM PREVENTS ME FROM STARTING MY TRUCK. MY GREATEST ISSUE WITH THIS SITUATION IS THAT MY TRUCK IS NOT THE ONLY ONE THAT IS AFFECTED BY THIS. A QUICK GOOGLE SEARCH OF "GMC CANYON PASSLOCK" WILL SHOW PAGES UPON PAGES OF FORUMS OF OTHER TRUCK OWNERS WITH THE SAME PROBLEM. I LIVE IN AN AREA OF THE COUNTRY WITH A HIGH RISK OF FOREST FIRES. I KNOW FRIENDS WHO HAVE BEEN EVACUATED FROM THEIR HOMES IN THE PAST. I HONESTLY BELIEVE THAT THIS MALFUNCTION OF MY TRUCK COULD GREATLY IMPACT MY ABILITY TO EVACUATE IN CASE OF AN EMERGENCY.

I GOT A SAFETY BULLETIN FROM GMC #14609 STATING THAT THERE IS A PROBLEM WITH MY AIR BAG LIGHT,. IT CAN GO ON DUE TO WIRES IN THE REAR DOOR BREAKING, THE AIR BAG CAN GO OFF ALSO. THIS IS A SAFETY ISSUE WITH THE AIR BAGS, I HAVE THE PROBLEM WITH THE AIR BAG LIGHT ON. THEY SAID THEY WOULD FIX IT OR REIMBURSE ME IF I PAID IN THE PAST TO HAVE IT FIXED. WELL THEY SAID I WAS OFF OF WARRANTY 1-15 . THIS IS A SAFETY ISSUE, THE DEALER WILL NOT FIX IT FOR FREE. WHY DID THEY SEND ME THIS BULLETIN WITH MY VIN NUMBER ATTACHED? I HAVE HAD NOTHING BUT PROBLEMS WITH THIS GMC TRUCK, YOU NAME IT IT HAS HAD A PROBLEM. MOSTLY ELECTRICAL SYSTEM FAILURE. THE AIR BAG ISSUE SHOULD BE FIXED BY GMC FREE OF CHARGE WHICH THEY STATE IN THE LETTER, THERE TELLING ME I AM A FEW MONTHS PAST THE 10 YEAR DEAD LINE. THAT IS A DISGRACE THIS IS A SAFETY ISSUE AND SHOULD BE COVERED BY GMC IF IT IS A DESIGN PROBLEM LIKE ALL THE OTHER PROBLEMS I AM HAVING. THEY ARE GETTING AWAY WITH THIS AND THE AIR BAG CAN GO OFF WHILE DRIVING AND CAUSE AN ACCIDENT. I AM HOLDING THEM LIABLE FOR THIS PROBLEM. WHAT CAN I DO ABOUT THIS THEY ARE NOT HELPING ME WITH THIS SAFETY ISSUE. THANKS, TOM

Frame rail rust holes, brackets wielded to frame supports for leaf springs wields rusted completely through frame making vehicle unsafe due to the potential leaf springs supports to frame of vehicle breaking away from frame dropping rear of vehicle onto rear axles and tires. Frame of vehicle has a lot of rusting and holes due to the excessive rusting.

The frames on many of these trucks are unsafe to be on the road due to rusted leaf spring mounts and frame rails that are rotting away and unable to lift on a hoist. Luckily I came across a video warning me to watch out for a rusted frame or else I could have lost control while driving. Yes, I work at a gm dealership and see this issue often, they are very similar to the Toyota trucks that had rusted frames replaced under recall. No it has not been inspected but they're is no way that it would pass an annual inspection, therefore the truck is rendered useless. There were no warnings that the frame was almost rotted in half. Very dangerous situation.

THIS VEHICLE USES A RESISTOR FOR VARIABLE SPEEDS (X4) ON THE VENTILATION BLOWER. DURING CONTINUOUS OR FREQUENT USE (I.E. DEFROST, AIR CONDITIONING) A BURNING SMELL DEVELOPS. THE BURNING SMELL INCREASES OVER TIME AFTER REPEATED USAGE AND THE INCREMENTAL BLOWER SPEED CIRCUITS ARE BURNED OUT AND DISABLED. THE WIRES ARE BLACKENED AND CONNECTORS MELTED AND THE PLASTIC CONNECTING BASE OF THE RESISTOR IS MELTED AND BLACKENED. AT TIMES THE VEHICLE WIRE HARNESS IS AFFECTED. GM HAS A "SERVICE BULLETIN" WHICH PRESCRIBES A "REPAIR" FOR THIS MALFUNCTION (I.E. NEW RESISTOR, PIGTAIL WIRES AND CONNECTORS, AND A BLOWER REPLACEMENT IF REQUIRED) ---- BUT IT DOES NOT FIX THE PROBLEM AND IT OCCURS REPEATEDLY THROUGHOUT OWNERSHIP OF THE VEHICLE. WE HAD TO REPLACE THE RESISTOR AND WIRES IN THIS CIRCUIT AT LEAST 6 TIMES IN THE LAST THREE YEARS. OUR CANYON BEGAN EXPERIENCING THIS PROBLEM AT ABOUT 85,000 MILES. EACH REPLACEMENT (INCLUDING LABOR AND PARTS) COSTS ABOUT $150. I CONTACTED GM LAST YEAR -- THEY GAVE ME A CASE NUMBER BUT WANTED ME TO PAY OUT OF POCKET BY THE HOUR FOR ELECTRICAL TROUBLESHOOTING. I ALSO CONTACTED CORPORATE CUSTOMER SERVICE LAST MONTH WHEN THEY WERE ADVERTISING NEW RECALLS BASED ON SERVICE BULLETINS --- BUT THEY WERE NOT INTERESTED UNLESS AN OPEN FLAME WAS PRESENT IN THE SITUATION. WE EVENTUALLY BYPASSED THIS CIRCUIT BY INSTALLING CORE WIRE, A ONE-WAY SWITCH, AND A FUSE. AT THE VERY LEAST, THIS IS A DISTRACTION. AT THE WORST -- DEFROST, HEAT, A/C, ALL FUNCTIONS INVOLVING THE BLOWER BECOME DISABLED AND THE VEHICLE HARNESS CORE WIRE CAN BECOME DAMAGED. *TR

THE BRAKE LIGHTS HAVE STOPPED WORKING,TURN SIGNALS HAVE STOPPED WORKING,ENGINE WILL NOT START,TURNOVER, ABS BRAKE SYSTEM MALFUNCTIONS. *TR

HIT 3 DEER IN HIGH SPEED COLLISION. MY AIR BAGS DIDN'T FUNCTION. THEN RESEARCH ONLINE SHOWED I HAVE TIKATA AIRBAGS. THEN I NOTICED MY BRAKES IF WET OR HAVE ICE ON ROTORS, WHEN BRAKING, I GET TERRIBLE SQUEAKING NOISE AND FRONT END WILL SHIMMY OR VIBRATE. REAR BRAKES TOO. AND MY POWER STEERING STARTED MAKING NOISE, LIKE A RUBBING SOUND A FEW MONTHS AFTER I BOUGHT TRUCK, THOUGH NO FLUID LOSS OR STIFFNESS IN STEERING. I KNOW THESE AIR BAGS ARE DANGEROUS, METAL PARTS HAVE KILLED A FEW PEOPLE. WHY WASN'T I NOTIFIED BY AUTOMAKER ABOUT WHAT AIRBAGS WERE INSTALLED IN MY TRUCK!? I NEED FIXED. I DO A LOT OF MOUNTAIN DRIVING. I WOULD LIKE THEM TO WORK PROPERLY. AND THESE STRANGE NOISES REALLY BUG ME. I CAN'T BE BREAKING DOWN DEEP INTO MOUNTAIN ROADS WHEN I WORK OR TRAVEL. MUCH HIGHWAY TRAVELING TOO. THE CRUISE CONTROL HAS NEVER WORKED, SINCE TWO WEEKS AFTER BUYING TRUCK. IF COMING UP TO HILLS WHEN SET, THEN AS YOU DRIVE UP & DOWN MORE HILLS, IT WILL SELF EXCELLERATE! NOT SLOW DOWN ON DECLINES. VERY SCARY A COUPLE OF TIMES. VERY DANGEROUS! ENGINE WOULD JUMP INTO PASSING GEAR. I HAVE THE 5 CYLINDER 3.5 MOTOR. AUTOMATIC, SLE EXTENDED CAB 4X4. SHOULD I GO BACK TO DEALER TO GET FIXED?

AIR BAG COMES ON DISPLAY AND STAYS ON AFTER STARTING VEHICLE

Frame rail rust holes, brackets wielded to frame supports for leaf springs wields rusted completely through frame making vehicle unsafe due to the potential leaf springs supports to frame of vehicle breaking away from frame dropping rear of vehicle onto rear axles and tires. Frame of vehicle has a lot of rusting and holes due to the excessive rusting.

2005 CREW CAB GMC CANYON Z85 SLE - LOCALIZED FRAME DETERIORATION DUE TO EXCESSIVE RUST COMPLETELY THROUGH THE BOX FRAME. NO OTHER AREAS ON FRAME DISPLAY MORE THAN SURFACE RUST. PRESENT FROM DRIVERS SIDE REAR DOOR TO ABOVE THE FRAME ELEVATION CHANGE, INCLUDING THE MOUNTING BRACKET FOR THE REAR LEAF SPRING. HOLES AND SEAMS COMPLETELY OPEN IN AFFECTED AREAS. STRUCTURAL INTEGRITY COMPROMISED AT JOINT OF CAB TO THE BED OF TRUCK. VEHICLE IS STILL FUNCTIONAL BUT DAMAGE TO THIS AREA DOES NOT ALLOW FOR TRUCK TO BE USED AS INTENDED. ANY SIGNIFICANT WEIGHT IN BED MAY CAUSE FRAME TO COLLAPSE. NOT RELATED TO ANY SPECIFIC INCIDENT. NO FAILURE TO OPERATE AT THIS TIME.

INSTALLED NEW BRAKE LIGHTS DID YOU BRAKE SWITCH UNDER THE BRAKE PEDAL STILL SHOWING SIGNS OF NO BRAKE LIGHTS ON MY VEHICLE I'LL BRAKE BALLS HAVE BEEN REPLACE. *TR

CHECK ENGINE LIGHT COMES ON INTERMITTENTLY INDICATING MISFIRE WHEN IDLING; CAR IS SHAKING AND RATTLING THERE'S A SPECIAL COVERAGE LETTER #07123A BUT GMC DOES NOT COVER INTAKE LEAKAGE ISSUE ONCE VEHICLE IS PASSED 7 YRS OR 100K MILES, EVEN THOUGH THEY ARE AWARE OF THE PROBLEM SINCE 2007. IF YOU ARE NOT THE ORIGINAL OWNER, THERE IS NO WAY TO BE NOTIFIED OR CONTACTED. MY DEALER NEVER MADE ME AWARE OF THE ISSUE AFTER PURCHASING THE TRUCK. NOW I'M PASSED THE EXTENDED WARRANTY AND AM SUPPOSED TO COVER THE FULL COSTS. THIS IS CUSTOMER FRAUD SINCE ITS A MANUFACTURING PROBLEM RELATED TO THE ENGINE - ALL 2004-06 GMC CANYONS ARE AFFECTED BY THIS. THIS NEEDS A RECALL - NOT EXTENDED WARRANTY! *TR

ON 6/17/20 AS I WAS TRAVELING UNDER THE ALABASTER, ALABAMA OVER PASS ON HIGHWAY 65 NORTH AN ORANGE CONSTRUCTION BARREL WAS BLOWN INTO THE ROAD BY A TRUCK A HEAD OF ME. I SWERVED IN THE ATTEMPT TO MISS IT. THE BARREL CLIPPED THE PASSENGER SIDE BUMPER AND TORE OUT MY FOG LAMP. THANKFULLY NO ACCIDENT OCCURRED. WOULD LIKE MY FOG LAMP REPLACED AND BARRELS NOT IN USE PICKED UP OFF OF THE HIGHWAYS. THANK YOU IN ADVANCE. *TR

TL* THE CONTACT OWNS A 2005 GMC CANYON. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 55 MPH, THE CRUISE CONTROL FAILED TO OPERATE UPON ACTIVATION. IN ADDITION, THE BRAKE LIGHT LAMP WAS INOPERABLE. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 06V139000 (EXTERIOR LIGHTING) HOWEVER, THE CONTAC'S VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 82,000.

I PURCHASED 4 COOPER TIRES 8/18/10. I STARTED NOTICING A PROBLEM IN 1/11. THE SIDE WALLS WOULD BECOME VERY DARK BLACK ABOUT 2" DOWN FROM TREAD .THEN I NOTICED THE TRUCK NOT DRIVING RIGHT. SENSATION OF BEING STUCK IN 4 WHEEL DRIVE. ALTOUGH IT WAS NOT STUCK IN 4 WHEEL. I ASKED MANY PEOPLE TODAY I HAD A MECHANIC LOOK AT THEM. HIS RESPONSE WAS FEEL THESE LUMPS ON THE TREAD. THIS IS WHERE BELTS HAVE SNAPPED INSIDE THE TIRES ALL 4 OF THEM!!THE SIDE WALLS ARE SLIGHTLY BULGED AND WAS TOLD IT WOULD ONLY BE A MATTER OF TIME BEFORE I WILL HAVE A BLOW OUT. I SAVED FOR THESE TIRES FOR 1 YR. COOPER ATR OWL 31X10.50 R15 LT. PLEASE HELP BECAUSE I CAN'T AFFORD NEW TIRES & I'D NOT WANT TO KILL SOME ONE ON THE ROAD.. *TR

TL*THE CONTACT OWNS A 2005 GMC CANYON. WHILE DRIVING 30 MPH ON A WET ROAD, THE WHEELS SPUN AND CAUSED THE VEHICLE TO TAILSPIN. THE CONTACT CRASHED INTO A TREE AND DAMAGED THE REAR END OF THE VEHICLE. HE TOOK THE VEHICLE TO A BODY SHOP AND THEY REPAIRED THE REAR END OF THE VEHICLE. THERE WERE NO OTHER REPAIRS DONE TO THE VEHICLE. AT THE TIME OF PURCHASE, THE CONTACT ASKED IF THE VEHICLE HAD POST-TRACTION. THE DEALER STATED THAT IT DID; HOWEVER, THE CONTACT LATER DISCOVERED THAT THE VEHICLE DID NOT HAVE POST-TRACTION. WHENEVER HE DRIVES THE VEHICLE IN THE RAIN, HE HAS TO DRIVE APPROXIMATELY 20 MPH TO AVOID TAIL SPINNING. THE CURRENT MILEAGE WAS 38,000 AND FAILURE MILEAGE WAS 30,000. UPDATED 10/16/08 *BF UPDATED 10/21/08. *JB

MY TRUCK IS EXHIBITING AN ISSUE IN WHICH THE GM PASSLOCK SYSTEM DISABLES THE FUEL AND ENGINE BECAUSE OF SOME MALFUNCTION. THIS SYSTEM IS INTENDED TO DISABLE THE FUEL SYSTEM ON A VEHICLE IF IT DETECTS THAT THE IGNITION HAS BEEN TAMPERED WITH OR IN IMPROPER KEY HAS BEEN USED TO TRY AND START THE VEHICLE. MY ISSUE IS THAT INTERMITTENTLY WHEN I TRY TO START MY TRUCK WITH THE FACTORY KEY, THE PASSLOCK SYSTEM ENGAGES AND DOES NOT ALLOW ME TO START MY TRUCK. I HAVE TO WAIT 10 MINUTES IN ORDER FOR THE PASSLOCK SYSTEM LIGHT TO TURN OFF ON THE DASHBOARD. SOMETIMES MY TRUCK WILL START AFTER THIS 10 MINUTE LOCKOUT PERIOD. IT HAS HAPPENED BEFORE WHERE MY TRUCK WILL FAIL TO START AFTER THE FIRST LOCKOUT PERIOD AND I HAVE TO WAIT ANOTHER 10 MINUTES. ONCE THE PASSLOCK SYSTEM ALLOWS ME TO START THE ENGINE, MY TRUCK RUNS FINE WITH NO ISSUES. IN MY OPINION, THIS IS A SERIOUS SAFETY CONCERN. IN ANY EMERGENCY SITUATION, I WOULD HOPE TO DEPEND ON MY TRUCK STARTING. THIS MALFUNCTIONING PASSLOCK SYSTEM PREVENTS ME FROM STARTING MY TRUCK. MY GREATEST ISSUE WITH THIS SITUATION IS THAT MY TRUCK IS NOT THE ONLY ONE THAT IS AFFECTED BY THIS. A QUICK GOOGLE SEARCH OF "GMC CANYON PASSLOCK" WILL SHOW PAGES UPON PAGES OF FORUMS OF OTHER TRUCK OWNERS WITH THE SAME PROBLEM. I LIVE IN AN AREA OF THE COUNTRY WITH A HIGH RISK OF FOREST FIRES. I KNOW FRIENDS WHO HAVE BEEN EVACUATED FROM THEIR HOMES IN THE PAST. I HONESTLY BELIEVE THAT THIS MALFUNCTION OF MY TRUCK COULD GREATLY IMPACT MY ABILITY TO EVACUATE IN CASE OF AN EMERGENCY.

TL* THE CONTACT OWNS A 2005 GMC CANYON. THE CONTACT STATED THAT WHEN THE VEHICLE WAS STARTED, THERE WAS A FUEL ODOR COMING FROM THE VEHICLES BLOWER VENTS. THE CONTACT STATED THAT AFTER DRIVING THE VEHICLE 30 TO 35 MINUTES, THE ODOR WOULD DISSIPATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

ABS SENSOR FAULT APPEARS AND CONTINUES TO STAY ON. WHEN LIGHT TURNS OFF TERRIBLE NOISE AND VIBRATION OCCURS WHEN BRAKING. I AM CONCERNED FOR THE SAFETY OF MY 3 YEAR OLD AND MYSELF AS THE BRAKES DO NO REACT AS THEY SHOULD. I HAVE TAKEN IT AND HAD THE BRAKES REPLACED, THE SENSORS REPLACED AND THE PROBLEM CONTINUES. AFTER 3 DIFFERENT TIMES IN THE SHOP, I AM SO WORRIED THAT I AM GOING TO CAUSE AN ACCIDENT WITH MY TRUCK. I HAVE SEARCHED AND THERE ARE HUNDREDS OF COMPLAINTS WITH THE SAME PROBLEM ON HTTP://TOWNHALL-TALK.EDMUNDS.COM/[email protected]@.F1FB9BA/33#MSG33 PLEASE COPY THIS LINK AND CHECK OUT ALL OF THE COMPLAINTS ABOUT THE SAME PROBLEM. SOMEONE IS GOING TO GET REALLY HURT IF THIS IS NOT TAKEN CARE OF. *TR

AIR CONDITIONING FAN ABRUPTLY STOPPED WORKING ON ALL FAN SPEEDS EXCEPT "4", THE HIGHEST POSITION. CHECKED INTERNET FOR POSSIBLE SOLUTIONS AND FOUND THAT THERE HAVE BEEN NUMEROUS FAILURES EXACTLY LIKE MINE. ALL INVOLVED THE "BLOWER MOTOR RESISTOR ASSEMBLY, CONNECTOR AND/OR WIRING HARNESS" SHORTING OUT. SCORTCHING THE CONNECTORS, RESISTOR ASSEMBLY AND CAUSING THE PLASTIC TO MELT/BURN. GM PARTS AT LOCAL DEALERSHIP HAD REPLACEMENT PARTS AND I WAS ABLE TO RESOLVE THE PROBLEM. SPEAKING A GM SERVICE ADVISOR, HE CONFIRMED THAT THERE ARE NUMEROUS REPAIR PROBLEMS WITH THESE PARTS ON THE GMC CANYON/ CHEVROLET COLORADO 2004-2007. BUT NO EXPLANATION FOR WHY THEY ARE FAILING. NUMEROUS INTERNET REPORTS WITH PHOTO'S SHOWING DAMAGE AND EXPLAINING PROBLEM MOST REQUIRING MULTIPLE OR REPEATED REPAIRS. OLD PARTS ARE AVAILABLE. *TR

DT*: THE CONTACT STATED WHILE THE OUTSIDE CONDITIONS WERE FREEZING THE LINKAGE FOR THE TRANSMISSION FROZE AS WELL. THIS RESULTED IN THE INABILITY TO CHANGE GEARS UNTIL THE ICE MELTS. THE CONTACT STATED BY THE TIME THE VEHICLE WOULD ARRIVE AT THE DEALERSHIP, THE ICE WOULD MELT. THEREFORE, THE VEHICLE HAS NOT BEEN SEEN BY THE DEALERSHIP.

9/21/05 WENT TO START VEHICLE AND THE IGNITION STAYED ENGAGED. HAD TO TURN VEHICLE OFF AND RESTART. HAVE NOT TAKEN TO THE DEALERSHIP YET. *NM

I HAD JUST BOUGHT A USED / REPOSESSED 2005 GMC CANYON JANUARY 18, 2006 WITH 9100 APPROX MILES ON IT. MAY THE 3RD 2006 WHILE GOING ON INTERSTATE 20/59 IN BIRMINGHAM ALABAMA APPROX 10:45 AM, THE DRIVER SIDE REAR TIRE SHREDDED ON THE INTERSTATE WHILE I WAS DRIVING 75 MPH IN A 70 ZONE. THERE WAS NOTHING IN THE HIGHWAY STRUCK ON A SUNNY DAY. HOWEVER I MANAGED TO GET THE VEHICLE OFF THE INTERSTATE AND TO A TIRE REPAIR PLACE WHERE UPON INSPECTING THE BLACK RUBBER TORE UP THE REAR BED PANEL AND DAMAGE THE UNDERNEATH TIRE WELD AREA AND THE SUPER STRUCTURE. GMC WAS NOTIFIED AND THE REPRESENTATIVE SAID SOMEONE WITH KNOWLEDGE OF TIRES WOULD HAVE TO SAY THE TIRE WAS DEFECTIVE. AT THE AUTO DEALER BODY SHOP THE ADJUSTER PERSON COULDN'T MAKE A DETERMINATION WITH THE TIRE IN FRONT OF HIM, HE DID TAKE PICTURES, I ALSO WENT TO A TIRE SPECIALIST FOR THE AS 60 GENERAL TIRE P225 HE SAID THE SAME THING DUE TO THE DAMAGE. SO I AM AT A STAND STILL NEVERTHELESS THIS HAS COST ME $500.00 DOLLARS ON THE DEDUCTIBLE FOR MY INSURANCE CO. NATIONWIDE TO PICK UP THE BILL. I EVEN TOLD THE GMC REP I HAD A DREAM AFTER THAT INCIDENT FRIDAY NIGHT INTO SATURDAY MORNING THAT THE FRONT TIRE SHREDDED AND I FLIPPED THE CAR AND LOST CONTROL AND CRASH ON THE SAME STRETCH OF INTERSTATE. I TOLD HIM TOO THAT IF THAT WAS TO HAPPEN AND I SURVIVE THE MEDIA WOULD BE NOTIFIED. UNLESS THIS HAS HAPPEN TO YOU, YOU DON'T KNOW THE ANXIETY OF DRIVING WONDERING WHEN THIS WILL HAPPEN AGAIN. AFTER ALL THE VEHICLE ONLY HAD BEEN DRIVEN APPROX 3000 MILES WHEN THE INCIDENT HAPPEN AND HAS LEFT ME WITH THE FEELING OF WANTING TO GET A FOREIGN TRUCK. THIS WAS TOLD TO THE REP FROM GMC, THE SAD PART ABOUT THE WHOLE SITUATION IS THAT AS A LT. FIREFIGHTER PARAMEDIC FIRST RESPONDER, I HAVE STATED WHAT HAS HAPPEN AND NOTHING MOVED GM IT APPEARS, SAYS A LOT ABOUT US HAVING TO TESTIFY WHEN IT APPARENTLY MEANS MORE EVIDENCE IS NEEDED FOR ME TO BELIEVE AND HELP YOU. *JB

MY 2005 CANYON HAS ONLY 258 MILES ON IT AND THE TRUCK WOBBLES/SHAKES AT ANY SPEED ABOVE 45MPH. I THOUGHT MAYBE IT WAS JUST ME BUT THERE ARE MULTIPLE ON THE CANYONFANS.COM WEBS THAT ARE HAVING THE SAME PROBLEM.*AK

DRIVERS SIDE SEAT HEAT SWITCH STAYS LATCHED ON THE "ON" POSITION EVERY TIME I GET OUT OF THE TRUCK. *TR

THE "2005 GMC CANYON" PICK-UP AND SIMILAR VEHICLES MADE BY THIS MANUFACTURER LACK KEYED ACCESS LOCKS ON THE PASSENGER-SIDE DOORS. IN THE EVENT OF AN EMERGENCY, BECAUSE THERE IS NO PRACTICAL WAY TO READILY ACCESS THE VEHICLE FROM THE PASSENGER-SIDE, THERE IS THE POTENTIAL THAT THE VEHICLE OWNER OR PASSENGERS WOULD BE EXPOSED TO UNDUE HARM. IT IS TAKEN FOR GRANTED BY MOST CONSUMERS THAT VEHICLES COME WITH KEYED ACCESS ON THE PASSENGER-SIDE, BUT NOWHERE IN THE MANUFACTURERS LITERATURE DOES IT MENTION THAT THERE ARE NO OUTSIDE LOCKS ON THE PASSENGER-SIDE OF THESE VEHICLES. IF A CONSUMER WERE TO PURCHASE THE VEHICLE WITH POWER LOCKS, THIS WOULDN'T BE AN ISSUE, UNLESS THERE WAS A POWER FAILURE TO THE VEHICLE, BUT VEHICLES SOLD THAT DO NOT COME WITH THE POWER DOOR LOCK FEATURE, DO NOT COME WITH OUTSIDE DOOR LOCKS ON THE PASSENGER-SIDE OF THE VEHICLE. I FEEL THAT THE MANUFACTURER SHOULD RETROFIT THESE VEHICLES WITH OUTSIDE DOOR LOCKS. *JB

2005 GMC CANYON DRIVER SIDE SEAT BELT BUCKLE DOES NOT STAY LATCHED. JERKING ON THE SEAT BELT WILL UNLATCH THE SEAT BELT. *TR

HIT 3 DEER IN HIGH SPEED COLLISION. MY AIR BAGS DIDN'T FUNCTION. THEN RESEARCH ONLINE SHOWED I HAVE TIKATA AIRBAGS. THEN I NOTICED MY BRAKES IF WET OR HAVE ICE ON ROTORS, WHEN BRAKING, I GET TERRIBLE SQUEAKING NOISE AND FRONT END WILL SHIMMY OR VIBRATE. REAR BRAKES TOO. AND MY POWER STEERING STARTED MAKING NOISE, LIKE A RUBBING SOUND A FEW MONTHS AFTER I BOUGHT TRUCK, THOUGH NO FLUID LOSS OR STIFFNESS IN STEERING. I KNOW THESE AIR BAGS ARE DANGEROUS, METAL PARTS HAVE KILLED A FEW PEOPLE. WHY WASN'T I NOTIFIED BY AUTOMAKER ABOUT WHAT AIRBAGS WERE INSTALLED IN MY TRUCK!? I NEED FIXED. I DO A LOT OF MOUNTAIN DRIVING. I WOULD LIKE THEM TO WORK PROPERLY. AND THESE STRANGE NOISES REALLY BUG ME. I CAN'T BE BREAKING DOWN DEEP INTO MOUNTAIN ROADS WHEN I WORK OR TRAVEL. MUCH HIGHWAY TRAVELING TOO. THE CRUISE CONTROL HAS NEVER WORKED, SINCE TWO WEEKS AFTER BUYING TRUCK. IF COMING UP TO HILLS WHEN SET, THEN AS YOU DRIVE UP & DOWN MORE HILLS, IT WILL SELF EXCELLERATE! NOT SLOW DOWN ON DECLINES. VERY SCARY A COUPLE OF TIMES. VERY DANGEROUS! ENGINE WOULD JUMP INTO PASSING GEAR. I HAVE THE 5 CYLINDER 3.5 MOTOR. AUTOMATIC, SLE EXTENDED CAB 4X4. SHOULD I GO BACK TO DEALER TO GET FIXED?