2002 GMC S Series Other / unspecified Problems

LOW COOLANT LIGHT STAYS ON - REPLACED FIRST TIME LOW COOLANT LIGHT STAYS ON - REPLACED SECOND TIME. *JB

NHTSA ID

10153631

Incident

Aug 12, 2005

Mileage

50,508 mi

1999 CHEVY TAHOE ABS FRONT WHEEL SPEED SENSOR CORROSION CHEVROLET/GMC HAS INDICATED THAT THE 1999 CHEVY TAHOE THAT I OWN IS NOT COVERED UNDER THE PREVIOUSLY ANNOUNCED SAFETY RECALL 05068. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHO INDICATED THE FOLLOWING: "...FOUND THE WHEEL SPEED SENSORS WITH RUST CORROSION, CAUSING UNWANTED ABS ACTIVATION AND INCREASED STOPPING DISTANCES DURING LOW SPEED BRAKE APPLICATIONS. RECOMMEND REPLACING BOTH WHEEL SPEED SENSORS TO CORRECT THIS CONDITION." THE VEHICLE ALSO LIVED GEOGRAPHICALLY WITHIN FOR 137,000 MILES IN THE "RUST BELT STATES" COVERED UNDER RECALL 05068, HOWEVER GM HAS INDICATED THAT THE VEHICLE 1999 CHEVY TAHOE IS NOT CONSIDERED PART OF THE RECALL. *NM

NHTSA ID

10152880

Incident

Mar 15, 2006

Mileage

165,000 mi

I WAS ON 275W. WHEN MY RIGHT WINDOW WIPER ARM STARTED TO STOP THEN IT DIED, MY HUSBAND TOLD TO SEE WHAT I COULD FIND OUT ON REPAIRING IT AND COST ON THE COMPUTER, I RAN ACROSS THIS LITTLE THING ON THE COMPUTER ABOUT 1997 BUICK CENTURY'S AND THE RIGHT WINDSHIELD {COMPONENT: VISIBILITY: WINDSHIELD WIPER/WASHER LINKAGES} WELL WHEN I READ ALL OF IT THAT DESCRIBES WHAT HAPPEN TO MY WIPER. WHEN I CALLED EVERYBODY SAID NO NOT YOUR CAR, AND I SAID I DON'T UNDERSTAND BECAUSE THE SAME THING IS WRONG WITH MIND. *NM

NHTSA ID

10152401

Incident

Mar 9, 2006

Mileage

124,636 mi

FIRST OF ALL MY ODOMETER GAUGE STOPPED OPERATING. IT REMAINED ON ZERO MILES WHILE I WAS DRIVING THE VEHICLE SINCE NOVEMBER 2005. THE WHOLE DASHBOARD CLUSTER HAD TO BE REINSTALLED. SECONDLY; THE SERVICE ENGINE SOON LIGHT BEGAN POPPING ON AND THE ENVOY WAS DRIVING ROUGH. I FOUND OUT FROM A GM DEALER THAT THE CLUTCH FAN FROZE WHICH CAUSED THE WATER PUMP TO BREAK AND THE RADIATOR TO OVER HEAT BURST THE RADIATOR HOSE AND SPEW OUT AND LEAK ALL OF THE WATER AND RADIATOR FLUID FROM THE RADIATOR. THE ENVOY IS NOW NOT DRIVABLE. I HAVE ONLY HAD THIS 2004 ENVOY SINCE NOVEMBER OF 2003. *NM

NHTSA ID

10151678

Incident

Mar 2, 2006

Mileage

54,480 mi

I BOUGH 2001-GMC-TRUCK-SONOMA. AS A LEFT OVER. ON JANUARY 11, 2002,IS THE DATE I RECEIVED IT ,THAT IS WHEN I BOUGH IT. ON APRIL 10, 2002 @\AT 1160 MILES,THEY REPLACED BOTH OF THE FRONT BRAKE ROTORS. ON AUGUST 14, 2003 AT 7745 MILES THEY REPLACED BOTH OF THE REAR BRAKE ROTORS, AND TURNED FRONT ROTORS. NOW AS OF JAN212006,THERE IS ONLY 17,868 MILES ON THE TRUCK, IT'S ALWAYS BE GARAGE KEEPED.AND WELL CARED FOR.IT'S STILL HAS THE NEW SMALL INSIDE, NOW ALL 4 OF THE ROTORS AND BRAKES HAVES TO BE REPLACD. I CANNOT UNDER STAND WHY ITS SHOULDBE UP TO ME TO REPLACE WITH ONLY THEN MILES-PER ABOVE.*AK

NHTSA ID

10148419

Incident

Apr 10, 2002

Mileage

1,160 mi

2002 YUKON. STEERING PART ISSUE. REPLACED TWICE IN TWO YEARS, LUBRICATED PRIOR TO THAT. BEEN IN SHOP FOR SAME THING 4 TIMES OR MORE FOR SAME ISSUE. WHEN MANUFACTURER CONTACTED ABOUT THIS AFTER THE FOURTH TIME IN THE SHOP FOR SAME ISSUE....STATED "IF STAYS FIXED FOR A YEAR, SERVICE DEPARTMENT DOING THEIR JOB AND NOT GM'S PROBLEM....NO PERMANENT RESOLUTION" MANUFACTURER REQ# 1-375628602. IF THIS PERSISTS, COULD CAUSE MAJOR ACCIDENT/INJURIES. *JB

NHTSA ID

10143923

Incident

Nov 25, 2005

Mileage

17,000 mi

2001 S-10 P/U. ABOUT 50,000 MILES. SUPPORT CABLES BROKE. 3 YEAR OLD SITTING ON GATE WHEN IT BROKE. NO ONE INJURED. *JB

NHTSA ID

10141804

Incident

Jul 13, 2004

I OWN A 2005 CHEVROLET COBALT. AS I WAS DRIVING THE CAR I WENT TO MAKE A TURN ONTO A STREET AND ALL OF A SUDDEN THE CAR SHUTS OFF AND JUST COMES TO A COMPLETE STOP. I WASN'T GOING MORE THAN 5 MPH WHEN MAKING THE TURN AND I ALMOST GOT RE-ENDED BECAUSE MY CAR CAME TO A ABRUPT AND I ALMOST GOT RE-ENDED. I HAD TO TAKE THE CAR PUT IT BACK INTO PARK AND RESTART. THIS IS RIDICULOUS THIS HAPPENED ON 10/24/05, AND THIS PROBLEM OCCURRED 2 MORE TIMES AFTER FOR A TOTAL OF 4 TIMES B/C IT HAPPENED PREVIOUSLY ON 10/2/05. *JB

NHTSA ID

10141795

Incident

Oct 24, 2005

[5] MAJOR PROBLEMS CHEVROLET SILVERADO Z71 EXTENDED CAB 4 DOOR LT 350CU.IN 5.7 LITER. THIS TRUCK CAME WITH THE TOW HAUL EQUIP. AND WAS SOLD WITH IMPROPER TIRES FOR THE USE DESCRIBED. TIRES WHERE FIRESTONE 245/75-16. STEELTEX A/T #108/104R M/S NEW VEHICLE STICKER ALSO. TO ME. THIS FRAUD #2) NEXT FAILURE: LOST ALL BRAKING GOING DOWN A SLIGHT GRADE. BRAKE PEDAL WENT FLAT TO THE FLOOR. I RELEASED PRESSURE. PUSHED AGAIN. DOWN TO THE FLOOR BUT WITH PULSING FELT THROUGH PEDAL. RELEASED AGAIN SAME ...USED BOTH LEGS ON ONE BRAKE PEDAL OTHER ON PARKING BRAKE. ENGINE SHAKING DURING THIS. APPROX. STOPPING DISTANCE 600-700-YARDS.! INFORMED DEALER WHEN NEXT SERVICE DUE AT 15.000MI. NO COMMENT NO ISSUE #3) NEXT FAILURE: GM CRAP EXHAUST SYSTEM MANIFOLD CRACKED IN TWO@17,156MI. AND CONVERTER BLOCKAGE DUE TO BREAKAGE OF MANIFOLD FRAGMENTS. #4) NEXT FAILURE: SAME AS #2 ABOVE. BREAKING LOSS FOR BRIEF 90-200 SECONDS. ENOUGH TIME TO BE SERIOUSLY INJURED OR CAUSE ONE. 17,982.47 MI #5) 20 MI ROUND TRIP ON WAY HOME ON FREEWAY SUDDEN DECREASE IN SPEED AND THE RPM GAUGE IS AT 6,000 RPM IT DOES NOT GO ANY HIGHER. THEN IT GRABBED AND SPED WAY UP. LET OFF GAS AND SLING SHOT TYPE ERRATIC SPEEDS WITH SAME PRESSURE ON GAS NEXT PEDAL. SAME [XXX] TIME. I WILL NEVER REACH THAT SPACE IN TIME OR MILES BEFORE THIS UNRELIABLE DEFECT LAIDEN POORLY DESIGNED PIECE OF SHODY MERCHANDISE KILLS ME OR SOMEONE ELSE. THE SERVICE DEPT WANTS ME TO AUTHORIZE TAKE DOWN OF TRANSMISSION AND DISSEMBLE THE UNIT AND SAID NEEDED TO NOTIFY GM. ALSO THEY MENTIONED 66,790. IS THIS A FORM OR A CHARGE?. I CALLED THEM BACK ONLY TO GET A RECORDING . I SAID (MY EXACT WORDS) I AUTHORIZE GM/ DEALER TO REPAIR THIS VEHICLE NOW AT THEIR COST AND DELIVER IT ASAP. COME MONDAY THIS WILL BE 4 DAYS NO TRUCK. THIS WILL FORCE ME TO USE VERY HARSH CIVIL COMPLAINTS FOR THESE INTERRUPTIONS. *NM INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10136813

Incident

Sep 15, 2005

Mileage

18,600 mi

1. RUNS HOT WAS TOLD BY DEALER ITS "NORMAL" TO RUN IT AT 230 20,000 MILES. 2. REPLACE BRAKES AT 40,000 MILES. 500.00 REPAIR 3. RECALLED FOR WIPER/SIGNAL SWITCH 45,000, 4. CUTS OUT OR RPMS MOVE THE CAR DOESN'T, DEALER CANT FIND A PROBLEM 46,000 MILES. 5. "DRINKS OIL NO SIGNS OF LEAKS! 60,000 MILES DEALER HAS NO CLUE! 6. TOTAL OVER HEATING AT 70,000. REPLACE THERMOSTAT. 300.00 REPAIR 7. BATTERY WENT DEAD 71,000 MILES 90.00 REPAIR 8. TURN SIGNALS "STICK" WILL NOT TURN OFF BY THEMSELVES NOT BLINK 72,000 MILES 9. REPLACE ALTERNATOR AT 73,000 MILES, 400.00 REPAIR. IM THE SECOND OWNER...THIS CAR IS A TOTAL PIECE OF '!@#$%! NEVER BUY ANOTHER ONE FOR SURE!!! *NM

NHTSA ID

10130911

Incident

Jan 1, 2005

Mileage

20,000 mi

IN THE SUMMER OF 2002 MY GMC SIERRAS PU TRUCK VIN [XXX] BEGAN TO EXPERIENCE BRAKE CHATTER AT VERY LOW SPEED. IT THEN BEGAN TO CONTINUE TO ROLL WHEN THE BRAKES WERE APPLIED. THIS PROBLEM BECAME MORE PRONOUNCED AND MORE PRONOUNCED AS TIME WENT ON. I HAD NUMEROUS VERY CLOSE CALLS WITH THIS TRUCK INVOLVING BUILDINGS, TREES AND OTHER VEHICLES. I TOOK IT TO A LOCAL REPAIR SHOP AND THEY COULD NOT FIND THE PROBLEM OVER A TWO WEEK PERIOD. I FINALLY TOOK IT TO BOWSER GMC IN PLEASANT HILLS PA. THEY REPAIRED THE TRUCK BY REPLACING THE FRONT HUBS AND SENSORS. WITH THIS REPAIR AND THE PREVIOUS COMPLETE BRAKE JOB INCLUDING BRAKES AND ROTORS THIS EPISODE COST MORE THAN $1400. AT THE TIME THE TRUCK HAD 36,000 MILES ON IT. ON 7/20/05 I BEGAN TO NOTICE THE BRAKE CHATTER RETURNING. JUST A SLIGHT CHATTER COMING TO A STOP AT RED LIGHTS ON INCLINES, THEN ON THE LEVEL AND FINALLY ON 7/23/05 I ALMOST CRASHED INTO MY HOUSE AS I PULLED INTO THE DRIVEWAY. THE SAME PROBLEM HAD RETURNED, THE TRUCK NOW HAS 47,000 MILES. IT APPEARS THAT MY $800 HUB REPLACEMENT WAS DONE WITH THE SAME FAULTY HUB ASSEMBLY. THE SAME PROBLEM HAS RETURNED ONLY IN LESS TIME. THIS IS NOT THE ONLY PROBLEM I HAVE HAD WITH THE BRAKES ON THIS TRUCK, I JUST RECENTLY AT 46,000 MILES HAD TO HAVE THE REAR ROTORS AND PADS REPLACED DUE TO RUSTED BRAKE PARTS. SO OVER THE COURSE OF 5 YEARS I HAVE REPLACED 6 BRAKE ROTORS, 6 SETS OF PADS, TWO HUBS AND TWO SENSOR ASSEMBLIES. I HAVE HAD NUMEROUS CLOSE CALLS WITH THIS TRUCK COMING WITHIN INCHES OF CRASHING INTO BUILDINGS AND OTHER CARS. AT TIMES I HAVE HAD TO THROW THE VEHICLE INTO PARK TO STOP FROM HITTING SOMETHING. I HAVE NO OTHER MEANS OF TRANSPORTATION AND I AM DISGUSTED THAT NOTHING HAS BEEN DONE TO RECTIFY THIS PROBLEM SINCE I FIRST REPORTED IT IN 2002. THE NHTSA ACTION NUMBER FOR THIS TRUCK IS PE05020. *NM UPDATED 07/19/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

10130445

Incident

Jul 23, 2005

Mileage

47,000 mi

SEAT BACK RECLINE HANDLE BREAKS OFF CAUSING SEAT BACK NOT TO STAY IN PLACE, OR NOT ABLE TO ADJUST

NHTSA ID

10129501

Incident

Jul 20, 2005

NO WARNING. HEARD A LOUD SOUND LIKE A FIRECRACKER. VEHICLE WAS AT A STOP SIGN. TRAVELLED 1/2 MILE TO HOME AT LESS THAN 30 MPH. VEHICLE HAD A SEVERE VIBRATION IN THE STEERING WHEEL AND THE FLOORBOARDS. RIGHT ENGINE MOUNT STUDS SHEARED BETWEEN THE ENGINE MOUNT FLANGE AND THEIR ATTACHMENT POINT ON THE ENGINE. PARTS REPLACED AND YES, I HAVE THE BAD PARTS.

NHTSA ID

10128804

Incident

Jul 5, 2005

I JUST GOT MY CAR IN DECEMBER OF 2004.I WENT TO GET MY STATE INSPECTION AND THE MECHANIC TOLD ME THAT I NEEDED TO REPLACE MY BRAKE LIGHTS BECAUSE THEY WERE NOT WORKING PROPERLY BECAUSE WATER HAD GOTTEN INTO THE LIGHT.I GO BACK A COUPLE OF DAYS LATER AFTER DUMPING THE WATER OUT OF MY LIGHTS AND MY CAR PASSES THE STATE INSPECTION BUT MY RIGHT BRAKE LIGHT DOES NOT WORK BECAUSE OF A WIRE SHORTAGE.

NHTSA ID

10128517

Incident

May 1, 2005

Mileage

93,000 mi

HAD MY LOCAL MECHANIC REPLACE REAR BRAKES. STILL GETTING NOISE FROM REAR WHEELS, TOOK IT TO BUICK DEALERSHIP TO INVESTIGATE. THEY ADJUSTED BRAKES AND THEY FAILED WITHIN A WEEK. I WAS THEN CHARGED $1000 PLUS A $400 RENTAL CAR BILL WHILE THEY "FIXED THE BRAKES." AFTER GETTING MY CAR BACK IT WAS STILL "WHIRRING", TURNS OUT THE PROBLEM WAS A HUB BEARING FAILURE ON ALL FOUR TIRES.

NHTSA ID

10123997

Incident

May 27, 2005

Mileage

98,750 mi

ANTI-LOCK BRAKES ACTIVATE DURING NORMAL STOP AND GO DRIVING. THIS HAS RESULTED IN NUMEROUS NEAR COLLISIONS. DEFECT REPORTED TO GM CUSTOMER SERVICE REPRESENTATIVE ON 5-24-05.

NHTSA ID

10122083

Incident

Sep 2, 2004

Mileage

50,979 mi

HAD FRONT PASSENGER SIDE WHEEL HUB (WHEEL BEARING) ASSEMBLY REPLACED IN OCTOBER 2004. IN MARCH 2005 SAME WHEEL BEARING FAILED WHICH NEEDED REPLACED AGAIN. NOW ON THE DRIVER SIDE THE WHEEL BEARING IS MAKING NOISE. I LOOKED INTO THIS AND ALOT OF PEOPLE HAVE HAD THE SAME PROBLEM WITH THESE VEHICLES AND WHEEL BEARINGS. THIS IS VERY UNSAFE AS THE WHEEL BEARING HOLDS ON THE FRONT WHEEL THUS COULD CAUSE WHEEL TO FALL OFF WHILE DRIVING.

NHTSA ID

10119416

Incident

Mar 25, 2005

Mileage

55,000 mi

I HAVE A 1997 PONTAIC GRAND PRIX. THE HEADLIGHT LENS (GLASS) COMES OFF WHILE TRAVELING DOWN THE ROAD. THIS CREATES AN UNSAFE CONDITION BEING THAT THERE IS A PROJECTILE THAT COULD HIT ANOTHER VEHICLE OR A PEDESTRIAN AND CAUSE SERIOUS INJURY. IN CALLING AROUND TO FIND A REPLACEMENT LENS, I FOUND THAT THIS HAPPENS A LOT AND THE SALAVAGE YARDS SELL THEM AS FAST AS THEY GET THEM IN. THAT IS A LOT OF LENS COVERS FLYING AROUND ON THE HIGHWAYS. IT IS EVEN TAKING A DEALERSHIP A WHILE TO ORDER ONE, SINCE THEY ALSO CAN NOT KEEP THEM IN STOCK. I HAVE NO WAY OF KNOWING IT MINE HIT ANOTHER VEHICLE, AS IT WAS THERE WHEN I LEFT AND GONE WHEN I GOT TO MY DESTINATION. I HEARD A NOISE LIKE A STONE OR SOMETHING HITTING THE CAR, BUT WAS NOT AWARE OF WHAT IT REALLY WAS. IF PONTAIC KNOWS THERE IS A PROBLEM THEY SHOULD BE RECALLED AND THEY SHOULD FIX THE PROBLEM.*AK

NHTSA ID

10116865

Incident

Mar 2, 2005

Mileage

68,000 mi

WITHIN 12 MONTHS GM GENUINE BALLJOINTS (LOWER) ON OUR 2001 CHEVROLET S10 PICKUP TRUCK FAILED WITHIN 12 MONTHS, POSSIBLY SOONER IF IT WERE'NT FOR THE STATE REQUIRED MOTOR VEHICLE INSPECTIONS POINTING IT OUT AGAIN. IMAGINE THAT THEY PROBABLY FAILED WAY BEFORE THE INSPECTION. IT LOOKS LIKE WE'RE NOT THE ONLY ONE WHO HAS EXPIERENCED THIS PART FAILURE WITH THE CHEVROLET, S10.*AK

NHTSA ID

10114087

Incident

Mar 4, 2005

Mileage

62,344 mi

I HAVE HAD THE POWER STEERING RACK IN MY 99 GRAND AM REPLACED TWICE. THE LAST TIME WAS IN APRIL 2004. IT IS LEAKING AND NEEDS TO BE REPLACED AGAIN.*AK

NHTSA ID

10104845

Incident

Dec 16, 2004

Mileage

12,000 mi

SINCE PURCHASING MY 2002 VEHICLE I HAVE HAD TO ALREADY PUT A NEW BATTERY, NEW ALTERNATOR, NEW TIRES (ACCEPTABLE) TWO SETS OF BRAKES AND THE CHECK ENGINE LIGHT STILL IS ON AND NO ONE CAN FIND OUT WHY SO THEREFORE I CAN'T GET AN INSPECTION OF THE VEHICLE UNTIL LIGHT IS OFF. HELP. *NM

NHTSA ID

10104712

Incident

Dec 12, 2004

I HAVE EXPERIENCED THE PROBLEM DESCRIBED IN TSB NO. 020730048 - PRESSURE CONTROL SOLENOID REPLACEMENT FOR 4T65-E, 4T40-E, AND 4T45-E TRANSAXLE/TRANSMISSION (NHTSA ITEM NUMBER: 10006166) A LITTLE OVER 2 YEARS AGO. I PAID TO HAVE THE SOLENOID REPLACED. THE REPLACEMENT IS NOW BEGINNING TO FAIL AGAIN. SINCE THIS IS A CONTINUING PROBLEM FOR GENERAL MOTORS I FEEL THAT A RE-DESIGN SOLENOID SHOULD BE MANUFACTURED AND INSTALLED ON THESE VEHICLES AT NO ADDITIONAL COST TO THE OWNERS.*AK

NHTSA ID

10100684

Incident

Sep 8, 2004

BRAKES ON MY 1995 GMC JIMMY FAIL PERIODICALLY. THE LAST TIME I REAR ENDED A WOMEN AND DESTROYED THE FRONT OF MY CAR. EVERYTHING HAS BEEN CHECKED OVER TWICE BY MECHANICS WHO HAVE COME TO THE CONCLUSION IT IS THE MODULE IN THE ABS. GM HAS SAID IT IS NOT THEIR PROBLEM. IF I AM DRIVING ALONG AT 25 MILES AN HOUR, I SHOULDN'T HAVE TO WONDER IF AND WHEN MY BRAKES WILL FAIL AGAIN. THE BRAKES WERE PUT TO THE FLOOR AND NOTHING HAPPENED, I CONTINUED AT THE SAME RATE OF SPEED. THE FIRST TIME I ALMOST GOT BROAD SIDED AT A STOP SIGN. I AM SCARED TO DRIVE MY CAR AND GM WON'T TAKE RESPONSIBILITY FOR THE FAILING COMPONENT. *NM

NHTSA ID

10095603

Incident

Oct 10, 2004

Mileage

137,800 mi

RETURNED TRUCK TO DEALER TWICE BECAUSE OF BRAKES WHEN TRUCK WAS UNDER WARRANTY NO REPAIRS WERE DONE. THE BRAKES WOULD NOT STOP THE TRUCK WITHIN A REASONABLE DISTANCE. *AK

NHTSA ID

10093162

Incident

Jun 16, 2000

POP IN STEERING AND CLUNK WHEN TURNING AT LOW SPEED. DEALERSHIP HAS REPLACED STEERING COLUMN, STEERING BOX, FRONT END AND ROTORS. HAVE SOLD THE VEHICLE TO INSURE THE SAFETY OF OUR FAMILY. *AK

NHTSA ID

10093129

Incident

Aug 20, 2004

Mileage

1,000 mi