2002 GMC Sierra 1500 Hd Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2002 GMC Sierra 1500 Hd, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes666.7%
- Fuel system333.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
I WAS MOVING MY 1500HD GMC SIERRA WHICH HAS 29K MILE & THE FRONT BRAKE LINE UNDER THE RADIATOR, BLEW OUT DUE TO RUST THIS IS A NIGHTMARE FOR ANY GMC OWNER , UPON AN INSPECTION OF ALL BRAKE LINES I FIND THEY ARE JUST STEEL WITH NO ANTI CORROSION ON ANY OF THEM. I ALSO OWN A 2002 YUKON & NOW IT HAS THE SAME PROBLEM, ALL LINES ARE BADLY RUSTED & JUST RECENTLY THE LINES ON THE REAR AXLE BURST. THIS IS LIFE THREATENING SITUATION THE VERY THIS YOU RELY ON THE MOST IS BRAKES.
THIS IS THE SECOND TIME A BRAKE LINE HAS BURST ON THIS TRUCK. THIS IS DANGEROUS. I HAD THE TRUCK TAKEN TO LOCAL SHOP AND WAS TOLD ALL BRAKE LINES ARE IN DANGER OF RUPTURE. HOW CAN GMC PUT THIS JUNK STEEL IN THEIR BRAKE LINES? WHEN PEOPLE START GETTING KILLED IF THEY HAVENT ALREADY MAYBE SOMETHING WILL BE DONE. I SMELL SOME LAWYER GETTING RICH HERE. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
I HAVE 2 OF THESE VEHICLES AND KNOW A FEW FRIENDS WITH THE SAME. THE FUEL PUMP AND FUEL GAUGE IN THESE VEHICLES ARE FACTORY DEFECTIVE. THEY ARE VERY, VERY INACCURATE IN TELLING YOU HOW MUCH FUEL YOU HAVE. I HAVE RUN OUT OF FUEL MANY, MANY TIMES WITH 1/2 TANK, 3/4 TANK FULL OF FUEL. THIS IS VERY VERY DANGEROUS SINCE YOU HAVE NO WARNING AND LOSE ALL STEERING AND BRAKES WITH NO ENGINE POWER. A LOT OF MY FRIENDS HAVE HAD THE SAME PROBLEM WITH VERY SIMILAR MAKES AND MODELS. *TR
THE GAS GAUGE IS NOT DEPENDABLE. SOMETIMES ACCURATE, BUT MORE OFTEN, NOT ACCURATE. IT IS A CONTINUOUS PROBLEM. YOU MAY RUN OUT OF GAS AT ANY MOMENT, IN TRAFFIC, ON THE INTERSTATE AT HIGH SPEEDS, THEN YOU HAVE NO STEERING OR BRAKES, ENGINE IS DEAD. IT HAS HAPPENED MANY TIMES, ONCE WHEN IT SHOWED 3/4 TANK FULL. I HAVE A 2001 CHEVY REGULAR CAB PICKUP TRUCK THAT DOES THE SAME THING. I HAVE TALKED TO MANY OTHER OWNERS THAT HAVE THE SAME PROBLEM. IT IS DEFINITELY A FACTORY DEFECT. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .