2000 GMC Sierra 1500 Brakes Problems

No wreck

NHTSA ID

11686984

Incident

Sep 12, 2025

TL* THE CONTACT OWNS A 2000 GMC SIERRA 1500. WHILE DRIVING AT A LOW RATE OF SPEED, THE BRAKE PEDAL WOULD NOT ENGAGE UNLESS EXCESSIVE FORCE WAS APPLIED. WHEN THE CONTACT APPLIED PRESSURE TO THE BRAKE PEDAL, THE ABS ENGAGED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 190,000.

NHTSA ID

11245279

Incident

Aug 13, 2019

Mileage

190,000 mi

TL* THE CONTACT OWNS A 2000 GMC SIERRA 1500. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC) BY WEHR FORD (11311 US-60 BUS, MOUNTAIN GROVE, MO 65711, (417) 926-3192). THE CONTACT STATED THAT THE DEALER ONLY CLEANED THE ABS SENSOR FOR CORROSION. YEARS LATER, THE BRAKE PEDAL FAILED TO RESPOND DUE TO INTERNAL CORROSION REGARDING THE SENSOR. ALSO, THE ABS KEPT INTERMITTENTLY ACTIVATING AND CAUSED EXTREME DIFFICULTY WHEN BRAKING. THE BRAKE PEDAL FAILED TO STOP THE VEHICLE AND CAUSED THE DRIVER TO HAVE TO REVERSE MORE THAN TWICE TO PREVENT A CRASH. THE DEALER WAS NOTIFIED OF THE FAILURES AND INDICATED THAT THE ABS SENSOR MAY NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

11195833

Incident

Oct 26, 2009

WENT TO STOP AND THE BRAKE PEDAL PUSHED AGAINST MY FOOT INSTEAD OF GOING DOWN. WAS MOVING SLOWLY AND THE BRAKE PEDAL INSTEAD OF STOPPING THE CAR PUSHED MY FOOT UP FROM THE BRAKE PEDAL AND I WENT OVER A PARKING BRAKE. MECHANIC VERIFIED THAT WHEN WHEEL SENSOR GOES BAD THE VEHICLE THINKS THE BRAKES ARE LOCKING UP AND THE ABS SYSTEM GOES ON PUMPING BRAKE PEDAL. HAPPENED MULTIPLE TIMES AS APPROACHED STOP LIGHTS PUSHING ME INTO INTERSECTION INSTEAD OF STOPPING.. I BELIEVE WHEN THE WHEEL SENSOR IS BAD IT SHOULD NOT PUT ME OR OTHERS IN A DANGEROUS SITUATION.

NHTSA ID

11153550

Incident

Mar 7, 2018

Mileage

140,000 mi

DURING A NORMAL STOP AT A STOP SIGN ON A RURAL ROAD, A STEEL BRAKE LINE RUPTURED DUE TO EXCESS CORROSION. THIS ONE LINE BETWEEN THE MASTER CYLINDER AND ABS MODULE IS THE ONLY LINE THAT PROVIDES PRESSURE TO THE FRONT BRAKES, WHICH SUPPLY ROUGHLY 75% OF THE VEHICLE'S BRAKING POWER. THE RUPTURE RESULTED IN RAPID FLUID LOSS AND THEREFORE A LACK OF PRESSURE IN THE HYDRAULIC SYSTEM TO ALLOW FOR ADEQUATE BRAKING. NEEDED TO SWERVE INTO A DITCH TO AVOID A CRASH WITH CROSS TRAFFIC.VISUAL INSPECTION INDICATES MOST BRAKE LINES ARE EXTREMELY CORRODED, AND WERE OBVIOUSLY MADE WITH SUBSTANDARD MATERIALS AS COMPARED TO OTHER MANUFACTURERS. I DO RECOGNIZE THAT THIS IS AN OLD VEHICLE, HOWEVER OTHER VEHICLES OF SIMILAR AGE AND DRIVEN IN SIMILAR ENVIRONMENTS DO NOT HAVE THIS ISSUE. ONLINE RESEARCH, MOST NOTABLY THE COMPLAINTS FILED TO NHTSA, INDICATE THIS IS A COMMON PROBLEM WITH CHEVY/GMC TRUCKS OF THIS ERA. ALTHOUGH OTHER OEM'S (SUBARU) HAVE ISSUED RECALLS IN SIMILAR SITUATIONS, IT APPEARS THAT THE GM THAT THE PUBLIC BAILED OUT JUST A FEW YEARS AGO HAS DECIDED TO DENY THAT THIS IS A PROBLEM, GAMBLING THAT THE THE COST OF LAWSUITS ASSOCIATED WITH DEATHS DO NOT EXCEED THE COST OF A RECALL.

NHTSA ID

11082615

Incident

Apr 2, 2018

Mileage

240,000 mi

TAKATA RECALL

NHTSA ID

11052800

Incident

Nov 15, 2017

Mileage

352,410 mi

BRAKE FAILURE FOR THE SECOND TIME ON THE VEHICLE. ORIGINAL BRAKE LINES WERE REPLACED 7 OR 8 YEARS AGO DUE TO FAILURE AT MY OWN COST (RUSTED LINES, LEADING THEM TO FAIL AS THE BRAKES WERE APPLIED), ALL LINES WERE REPLACE WITH GM REPLACEMENT LINES BY A QUALIFIED TECHNICIAN. ORIGINAL FAILURE RENDERED THE BRAKES 0% OPERATIONAL, GRAVITY (UPHILL) WAS THE ONLY THING THAT STOPPED THE VEHICLE. THE MOST RECENT FAILURE (ON JULY 29, 2017) AFFECTED THE BRAKE LINE RUNNING TO THE FRONT-RIGHT CALIPER, LINE FAILED WHERE IT CROSSED OVER THE SKID PLATE NEAR THE CENTER-LINE OF THE VEHICLE UP FRONT BY THE LOWER RADIATOR SUPPORT. LINE FAILED DUE TO CORROSION. REAR BRAKES APPEAR TO BE WORKING BUT ARE NOT SUFFICIENT TO STOP THE VEHICLE IN A SAFE MANNER. NO ACCIDENT OCCURRED, LINE FAILED AS APPROACHING A LIGHT TURNING RED WHILE GOING UPHILL, ROLLED THROUGH THE INTERSECTION PRIOR TO THE LIGHT TURNING GREEN FOR CROSSING TRAFFIC AND WAS ABLE TO STOP THE VEHICLE AS IT DRIFTED TO A STOP UPHILL. THE QUALITY OF THE GM BRAKE LINES ARE VERY SUSPECT TO SAY THE LEAST. THE BRAKE LINES ARE DANGEROUS AND SEEM TO BE MORE SUSCEPTIBLE TO CORROSION THAN ANY OTHER BRAKE LINE ON ANY OTHER VEHICLE I'VE EVER OWNED, OR ANY OF MY FRIENDS OR FAMILY HAVE EVER OWNED. I CAN ONLY IMAGINE IF THE LINES FAILED UNDER DIFFERENT CIRCUMSTANCES (WHILE TOWING THOUGH MOUNTAINS WHILE GOING DOWNHILL FOR EXAMPLE, THIS WOULD BE A LIFE-THREATENING SITUATION). PLEASE DETERMINE IF THESE LINES ARE FAULTY FOR THE SAKE OF OTHERS WITH THESE VEHICLES, AND THE SAKE OF OTHER MOTORISTS THAT COULD BE IMPACTED WHEN THE BRAKES ON THIS LARGER VEHICLE FAIL. IF THEY ARE FOUND TO BE FAULTY OWNERS SHOULD BE NOTIFIED THAT THESE BRAKE LINES ARE SUBPAR, AND THAT THE MANUFACTURER'S REPLACEMENT LINES ARE ALSO SUBPAR.

NHTSA ID

11011811

Incident

Jul 29, 2017

Mileage

85,000 mi

BRAKE LINE RUNNING ON TOP OF FRAME FROM MASTER CYL TO ABS HAS CORRODED TO THE POINT OF FAILURE. IT HAS RUSTED THROUGH AND LEAKS BRAKE FLUID. BRAKES HAVE FAILED. THIS VEHICLE HAS NEVER LEFT FLORIDA AND IS STILL HELD BY ORIGINAL OWNER.

NHTSA ID

10924919

Incident

Oct 15, 2016

Mileage

190,600 mi

TL* THE CONTACT OWNS A 2000 GMC SIERRA 1500. WHILE DRIVING 10 MPH, THE BRAKE PEDAL FAILED TO STOP THE VEHICLE WHEN DEPRESSED. THE CONTACT HAD TO APPLY THE EMERGENCY BRAKE. THE CONTACT NOTICED BRAKE FLUID FLOWING FROM A FRACTURE IN THE FRONT BRAKE LINE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE LINES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 66,000.

NHTSA ID

10907177

Incident

Sep 16, 2016

Mileage

66,000 mi

WHILE DRIVING MY VEHICLE AND TOWING A 4000+ POUND BOAT, MY BRAKE PETAL WENT TO THE FLOOR. WHEN I GOT OUT OF THE VEHICLE, THERE WAS BRAKE FLUID LEAKING ON THE GROUND. I DETACHED THE BOAT AND ATTEMPTED TO SEE IF I COULD DRIVE THE VEHICLE TO THE REPAIR FACILITY. THERE WAS NO BRAKING POWER AVAILABLE SO THE VEHICLE WAS TOWED TO A REPAIR FACILITY. REPAIRS WERE AROUND $900 FOR A REPLACEMENT OF ALL THE RUSTED BRAKE LINES.

NHTSA ID

10851792

Incident

Jul 16, 2014

Mileage

175,000 mi

TL* THE CONTACT OWNS A 2000 GMC SIERRA 1500. WHILE DRIVING 50 MPH, THE VEHICLE HAD A SUDDEN LOSS OF POWER STEERING AND THE BRAKES FAILED TO ENGAGE WITHOUT WARNING. THE CONTACT MENTIONED THAT THE VEHICLE WOULD VEER TO THE RIGHT INDEPENDENTLY. AS A RESULT, THE VEHICLE CRASHED INTO A CONCRETE BARRIER AND SPUN AROUND FROM THE FRONT AND CRASHED IN THE REAR. THE DRIVERS SIDE AND FRONT PASSENGER SIDE AIR BAGS DEPLOYED. THE CONTACT SUSTAINED A DISLOCATED LEFT SHOULDER AND A FRACTURED RIGHT FOOT. THE CONTACT ALSO SUSTAINED WHIPLASH, NECK PAINS WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V005000 (POWER TRAIN) AND NHTSA ACTION NUMBER: EA04012 (SERVICE BRAKES, HYDRAULIC, STEERING). THE VEHICLE WAS TOWED TO THE CONTACTS RESIDENCE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 183,500.

NHTSA ID

10726833

Incident

Jun 20, 2015

Mileage

183,500 mi

WE WERE TRAVELING WEST ON 495 HEADING TO GEORGETOWN HOSPITAL IN DC TAKING A FRIEND FOR HER WEEKLY KIDNEY TRANSPLANT CHECKUP FROM BALTIMORE MD. THE TRAFFIC HAD SLOWED TO A STOP AS I HIT MY BRAKES AND THEY WENT TO THE FLOOR WITH MINUTE STOPPING POWER . HAD I BEEN IN THE NEXT LANE OVER IT WOULD HAVE BEEN A WIPE OUT AS I WOULD HAVE REAR ENDED THE STOPPED TRAFFIC. I WAS IN THE CURB LANE AND GOT INTO THE SHOULDER. BRAKE LINES ARE TOTALLY CORRODED, RUSTED AND JUST CRUMBLING.. I NOTICED GM KNOWS ABOUT THE PROBLEM BUT REFUSES TO DO ANYTHING. WILL THEY WAIT UNTIL A FATALITY HAPPENS BEFORE THEY WARN THE PUBLIC OF THIS PROBLEM.. MANY OF THESE VEHICLES STILL ON THE ROAD.. *TR

NHTSA ID

10712803

Incident

Apr 21, 2015

Mileage

60,000 mi

BRAKE LINES RUSTED OUT AND CAUSED TRUCK TO NOT BE ABLE TO STOP AND ALMOST CAUSED AN ACCIDENT. FIRST LINE WENT ABOUT 2 MONTHS AGO AND WAS REPAIRED. I ASSUMED THAT THIS WAS A SINGULAR INCIDENT AND THE REPAIR WAS FINE, AND I WOULD HAVE NO OTHER PROBLEMS. NOW, A DIFFERENT BRAKE LINE WENT. SAME EXACT PROBLEM...RUSTED OUT APPEARS THAT ALL OF THE LINES ARE AT ISSUE AND ALL OF THEM MUST BE REPLACED. I WAS LUCKY AS I HAD JUST COME OFF THE INTERSTATE HIGHWAY WHERE I WAS DOING SPEEDS OF 70MPH AND RELYING ON MY BRAKES AS WOULD BE NORMAL. JUST AS I GOT OFF THE HIGHWAY AND PULLED INTO WORK, THE LINE BLEW OUT COMPLETELY AND MY PEDAL WENT TO THE FLOOR. I HAD NO BRAKES AT ALL...NOTHING. LUCKILY, I WAS IN THE PARKING LOT, AND GOING SLOW ENOUGH AND I THOUGHT QUICKLY AND USED MY EMERGENCY BRAKES AND STOPPED. HAD THE BRAKE LINE GONE OUT JUST TWO MINUTES EARLIER, OR ABOUT TWO OR THREE BRAKE PEDAL PRESSES BEFORE, I WOULD HAVE BEEN IN A SERIOUS ACCIDENT. *TR

NHTSA ID

10700868

Incident

Mar 9, 2015

Mileage

60,000 mi

WHILE TRAVELING ON COUNTRY ROAD IN QUARRYVILLE PA. I CAME TO A HILL AND A STOP SIGN AND PRESSED ON THE BRAKE PEDDLE. IT WENT TO THE FLOOR. I HAD VERY LIMITED BRAKING POWER AND TRAVELED THROUGH THE STOP SIGN ACROSS THE INTERSECTION. IT WAS A 4 WAY STOP INTERSECTION. AND NO ACCIDENT OCCURRED . BUT OH BOY DID I GET A DIRTY LOOK! ALL THE BRAKE FLUID WAS GONE OUT ONE HALF OF THE CONTAINER. LOOKING AT THE BRAKE LINES THEY ARE RUSTED THROUGH AND LEAKING. *TR

NHTSA ID

10684250

Incident

Dec 26, 2014

Mileage

34,000 mi

MULTIPLE INCIDENCES OF STEEL BRAKE LINE CORROSION, RESULTING IN LOSS OF FLUID PRESSURE, AND THEREFORE LOSS OF BRAKING ABILITY. THIS HAS HAPPENED 3 DIFFERENT TIMES ALREADY. LUCKILY I DRIVE COUNTRY ROADS WITH LITTLE OTHER TRAFFIC.OBVIOUSLY THIS IS A REPETITIVE AND SERIOUS ISSUE FOR MANY OTHER OWNERS OF THESE VEHICLES, AS EVIDENCED BY THE SHEER NUMBER OF COMPLAINTS REGARDING THE SAME ISSUE FILED TO NHTSA FOR THIS VEHICLE. DOES NHTSA EVEN READ OR EVALUATE THE VOLUME AND SERIOUSNESS OF COMPLAINTS ON THE SAME ISSUE? HOW MANY LIVES MUST BE LOST BEFORE THIS BECOMES A RECALL? *TR

NHTSA ID

10670130

Incident

Oct 30, 2013

Mileage

240,000 mi

I WAS DRIVING DOWN THE HIGHWAY IN MY 2000 GMC SIERRA TRUCK WHEN I APPLIED THE BRAKES AND THE PEDAL WENT TO THE FLOOR. I COULDN'T STOP AT THE RED LIGHT, SO I HAD TO MAKE A QUICK LEFT TURN, ACROSS ON ONCOMING TRAFFIC INTO A PARKING LOT BEFORE I COULD GET THE CAR STOPPED. THIS IS THE SECOND TIME MY BRAKES FAILED AND IN BOTH CASES IT WAS BECAUSE THE STEEL BRAKE LINES ROTTED OUT. I'VE OWNED MANY GM VEHICLES AND NEVER HAD TO REPLACE THE STEEL BRAKE LINES, NOT EVEN ON MY 1969 OLDS CUTLASS THAT I STILL OWN. I READ ABOUT OTHERS HAVING THE SAME PROBLEM AND SUPPOSEDLY GM DID NOT RECALL. BUT WAS GOING TO REPLACE PARTS AND LABOR FOR $500. I CALLED GMC AND THEY SAID THEY DIDN'T KNOW OF THIS AND I CALLED 2 DEALERS AND THEY DIDN'T KNOW OF THIS KIT EITHER. SO, I GUESS I HAVE A BIG BILL ON MY HANDS. CHEAP BRAKE LINES WERE USED BUILDING THIS TRUCK, AND BRAKES ARE PRETTY IMPORTANT TO STOP. I'M LUCKY I WAS ABLE TO GET OUT OF THIS SITUATION WITHOUT WRECKING. *TR

NHTSA ID

10669692

Incident

Dec 21, 2014

Mileage

101,000 mi

HAD A RECALL ON THE BRAKES, RECALL # 05068. CLASSIC CHEVEROLET (NOW OUT OF BUSINESS DID THE WORK) THEY ONLY CLEANED THE PARTS, ABS LIGHT CAME BACK ON A FEW MONTHS LATER SO THEY JUST KEPT CLEANING THEM UNTIL MY WARRANTY EXPIRED. THEN WHEN I BROUGHT IT BACK IT ALL OF A SUDDEN NEED OVER $2000 DOLLARS OF REPAIRS. MY WIFE GOT THEM TO KICK IN A $1000. BUT I BELIEVE THE PARTS SHOULD OF BEEN RE MANUFACTURED OUT OF STAINLESS STEEL SO THEY DIDN'T RUST & I WOULDN'T STILL BE HAVING HIS PROBLEM. NOW I'M PROBABLY LOOKING AT ANOTHER $2000 TO CONTINUALLY FIX THE SAME ISSUE. THEY BASICALLY DID THE SAME THING WITH THE TAIL GATE RECALL, JUST REPLACED WITH NEW PARTS OF THE SAME MAT'L AS THE ONES THAT WERE RUSTING AND FAILING IN THE 1ST PLACE. SO I REPLACED THEM SINCE THEN AGAIN ALSO. WHICH IF THEY WOULD OF MADE THEM OUT OF GALVANIZED OR STAINLESS THEY WOULD OF HELD UP BETTER. *TR

NHTSA ID

10664338

Incident

Dec 8, 2011

Mileage

80,000 mi

WHILE DRIVING HOME FROM WORK AT APPROXIMATELY 35MPH ON A CONGESTED ROAD, I APPLIED THE BRAKES TO STOP AT AN UPCOMING LIGHT AND THE BRAKE PEDAL IMMEDIATELY WENT TO THE FLOOR. I SWERVED INTO THE ADJACENT LANE TO AVOID REAR ENDING THE CAR IN FRONT OF ME. LUCKILY THERE WAS AN OPENING IN THE ADJACENT LANE AND THE CAR BEHIND ME WAS OBSERVANT. I PULLED OFF THE ROAD AND OPENED THE HOOD TO CONFIRM THE BRAKE FLUID LEVEL. IT WAS VERY LOW. I CLIMBED UNDER THE TRUCK TO OBSERVE BRAKE FLUID EVERYWHERE AND ASSUMED A BRAKE LINE FAILED. I TOOK THE TRUCK TO A REPAIR SHOP AND WAS INFORMED THE BRAKE LINE WAS RUSTED THROUGH AND NEEDED TO BE REPLACED. A COST OF $275. UPON RESEARCHING THIS ON THE INTERNET, I HAVE SEEN THAT THIS IS A MAJOR PROBLEM AND GM IS HOLDING OUT DOING A RECALL. THIS INCIDENT CAUSED ME TO NARROWLY MISS AN ACCIDENT AND IT MADE FOR A TENSE AND ANXIOUS TIME. I BELIEVE GM SHOULD RECOGNIZE THIS ISSUE AND DO SOMETHING QUICKLY BEFORE MORE SERIOUS ACCIDENTS OCCUR. *TR

NHTSA ID

10631323

Incident

Sep 4, 2014

Mileage

111,588 mi

REAR BRAKE LINE FAILED WHEN BRAKE PEDAL WAS PRESSED. UPON INSPECTION BRAKE LINE SHOWED MAJOR CORROSION, AND REMAINING LINES APPEAR TO HAVE MAJOR CORROSION AS WELL. *TR

NHTSA ID

10627655

Incident

Jun 28, 2014

Mileage

180,000 mi

THE STEEL BRAKE LINES GOING TO THE REAR BRAKES RUSTED AND BLEW. AFTER A INSPECTION ALL THE STEEL BRAKE LINES NEEDED TO BE REPLACED. *TR

NHTSA ID

10618147

Incident

Jul 7, 2014

Mileage

115,000 mi

CORDED BRAKE LINES CAUSED THE FLUID TO BE LOSS UPON STOPPING CAUSING THE BRAKES TO GO OUT, THIS HAPPENED IN 2012 WITH ALL THE MAIN BRAKE LINES TO ALL 4 WHEELS HAVING TO BE REPLACED, THEN AGAIN IN 2013 THE BRAKE LINES ATTACHED TO THE REAR DIFFERENTIAL, CORRODED CAUSING A RAPID LOSS IN BRAKE FLUID AND, AND LOSS OF BRAKES. *JS

NHTSA ID

10609096

Incident

Jun 29, 2012

Mileage

115,000 mi

HIT BRAKES HARD TO AVOID DEER, RAN UP ON CURB VEHICLE CAME TO A STOP, DROVE OFF A SHORT DISTANCE WHEN KNOWN THERE WAS NO BRAKE PRESSURE. SLOWLY WAS ABLE TO GET VEHICLE TO FRIEND HOUSE, STILL BROKE WAS ABLE TO STOP BUT THERE WAS NOT PRESSURE. THE WHOLE BRAKE LINE IS RUSTED AND CORROSION. UPDATED 1/28/2015 *JS

NHTSA ID

10608455

Incident

Jul 3, 2014

Mileage

124,000 mi

WENT TO STOP AND ABS CAME ON AND PAVEMENT WAS DRY AND NOW IT COMES ON EVERY TIME YOU PUT ON BRAKES AND SLOW DOWN TO 5 OR 6 MPH ... *TR

NHTSA ID

10596765

Incident

Jun 3, 2014

Mileage

119,000 mi

I PUT MY FOOT ON THE BRAKE PEDAL TO START THE TRUCK AND THE PEDAL WENT ALL THE WAY TO THE FLOOR. FORTUNATELY THE TRUCK WAS PARKED. I HAD THE CAR TOWED TO THE GM DEALER AND HAD THE LINES FIXED FOR $890.00. *TR

NHTSA ID

10594980

Incident

May 22, 2014

Mileage

153,000 mi

ALL BRAKE LINES RUSTED AND LEAKED CAUSING BRAKES TO FAIL. ALSO THE ABS SYSTEM FAILED. *TR

NHTSA ID

10593362

Incident

May 22, 2014