2000 GMC Sierra 1500

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

ODI OPENED PE03-057 TO ASSESS PARKING BRAKE INEFFECTIVENESS IN THE SUBJECT VEHICLES.THESE VEHICLES ARE EQUIPPED WITH FOUR WHEEL DISC BRAKES THAT INCORPORATE A SINGLE-SHOE DRUM-IN-HAT PARKING BRAKE INDEPENDENT OF THE SERVICE BRAKES.COMPLAINT AND WARRANTY DATA INDICATE THAT THE PARKING BRAKE LININGS TEND TO WEAR OUT EARLY IN THE LIFE OF THE VEHICLE (AT AN AVERAGE OF 24 MONTHS IN SERVICE), REDUCING THE PARKING BRAKE SYSTEM'S TORQUE BELOW THAT NEEDED TO IMMOBILIZE THE VEHICLE.GM HAS ATTRIBUTED THIS ACCELERATED WEAR TO FOREIGN MATERIAL INTRUSION AND A FAILURE OF THE BRAKE SHOE TO PROPERLY SELF-CENTER WITHIN ITS BRAKE DRUM.EFFECTIVE WITH THE START OF MY 2003 PRODUCTION, A NEWER REDUCED FORCE HOLD-DOWN CLIP WAS INTRODUCED TO FACILITATE BRAKE SHOE DISENGAGEMENT FROM THE DRUM SURFACE.THIS PART IS ALSO AVAILABLE AT THE SERVICE LEVEL FOR THE MY 1999-2002 VEHICLES.GM HAS INDICATED THAT THE PAKING BRAKE IS INTENDED TO OPERATE IN CONJUNCTION WITH THE TRANSMISSION TO IMMOBILZE PARKED VEHICLES, AND THAT IN MANY CASES, ACCELERATED PARKING BRAKE LINING WEAR IS CAUSED BY ROUGH USE, VEHICLE MODIFICATIONS, AND DRIVING WITH THE PARKING ENGAGED. ODI HAS UPGRADED THE PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING PARKING BRAKE USAGE FACTORS AND THE CIRCUMSTANCES SURROUNDING THE SEVENTEEN REPORTED VEHICLE CRASHES.

The contact owns a 1995 N/A GMC Sierra 1500. The contact stated that after parking, turning the vehicle off, and exiting, the vehicle suddenly rolled forward, down a slight incline, and crashed into another parked vehicle. The cause of the failure was not determined. The manufacturer and local dealer were not contacted regarding the failure. In addition, while making a left turn into an intersection, a second vehicle crashed into the front of the vehicle. During the crash, no air bags deployed. The contact sustained injuries to both the shoulder and the chest. No medical treatment was required. A police report was filed at the scene. The cause of the failure was not determined. No further information was available. The VIN was not available. The failure mileage was 4,000.

NHTSA ID

11688357

Incident

Mar 5, 1998

Mileage

4,000 mi

No wreck

NHTSA ID

11686984

Incident

Sep 12, 2025

The contact owns a 1999 N/A GMC Sierra 1500. The contact received notification of NHTSA Campaign Number: 00V097000 (SEAT BELTS); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11641210

Incident

Feb 6, 2025

THE NP246 TRANSFER CASE OIL PUMP PLATE WEARS A HOLE INTO THE CASE, CAUSING IT TO LEAK. THERE IS A SAVER PLATE THAT CAN BE INSTALLED THAT PREVENTS THIS PROBLEM.

NHTSA ID

11389425

Incident

Mar 10, 2020

Mileage

270,000 mi

I'VE HAD SEVERAL PROBLEMS WITH THE TRUCK SINCE I BOUGHT IT 3 MONTHS AGO. I'VE FIXED ALMOST ALL OF THEM-ABS WAS ACTIVATING WHICH WAS PUSHING ME INTO TRAFFIC NEARLY CAUSING A WRECK SO I CHANGED THE ABS SPEED SENSOR AND HUB ASSEMBLY. FRONT SUSPENSION WAS GONE SO I REPLACED THAT; AS WELL AS STEERING PARTS, BRAKES, THE PARKING BRAKE DOESN'T WORK, FIXING IT NEXT. OIL SENDING UNIT, A/C BELT AND REFRIGERANT REPLACED. THE PROBLEMS LEFT ARE EVAP EMISSION VENT VALVE SOLENOID, THROTTLE PEDAL POSITION SENSOR, AND RANDOM/ MULTIPLE CYLINDER MISFIRE SOMETIMES AND CYLINDER 4 MISFIRE OTHER TIMES. IN 4X4 WHEN IT GETS UNDER A LOAD SOMETHING SOUNDS LIKE IT'S BINDING UP AND IT POPS BUT IT STILL WORKS. WHEN I SHIFT INTO DRIVE OR REVERSE OR ACCELERATE FROM A STOP IT HAS A SHIFT FEELING IN THE REAR WITH A THUMP SOUND. SOMETIMES I CAN PUSH THE GAS AND IT WON'T DOWNSHIFT TO SPEED UP WHEN I'M ON THE HWY BUT THAT'S PROBABLY THE TPPS. I JUST WANT MY 4X4 WORKING AND MY SHIFT THUMP FROM A STOP TO GO AWAY. HELP. IN 4X4 THE NOISE HAPPENS IN FWD REVERSE AND WHEN TURNING AND WORSE IN 4LO BUT HAPPENS IN 4HI AND AUTO BUT NOT IN 2HI. *TR

NHTSA ID

11326914

Incident

Mar 1, 2020

Mileage

270,000 mi

TL* THE CONTACT OWNS A 2000 GMC SIERRA 1500. WHILE DRIVING AT A LOW RATE OF SPEED, THE BRAKE PEDAL WOULD NOT ENGAGE UNLESS EXCESSIVE FORCE WAS APPLIED. WHEN THE CONTACT APPLIED PRESSURE TO THE BRAKE PEDAL, THE ABS ENGAGED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 190,000.

NHTSA ID

11245279

Incident

Aug 13, 2019

Mileage

190,000 mi

I BOUGHT THIS TRUCK FROM A USED CAR DEALERSHIP IN BLAIR, NE WASHINGTON COUNTY. THE DEALERSHIP SOLD THIS TRUCK TO ME WITH REPLACED AIRBAGS THAT DIDN'T WORK. THEY REPLACED THE ORIGINAL FACTORY AIR BAGS WITH WHAT NOW ARE MARKED CHEVROLET AND NOT GMC ACCORDING TO MECHANICAL SHOP. SAME MECHANIC EXPRESSED TO ME THAT THIS TRUCK WAS IN ACCIDENT THAT NOT ONLY BENT THE FRAME BUT ALSO CAUSED THE ORIGINAL AIR BAGS TO DEPLOY. WHEN I PICKED UP TRUCK AFTER SALE I ASKED THE DEALERSHIP OWNER WHY THE LIGHT WAS ON, HE SAID HIS MECHANIC COULD FIX IT. HIS MECHANIC COULD ONLY WORK MONDAY THRU THURSDAY WHICH MADE MAKING ANY APPOINTMENT IMPOSSIBLE FOR ME, SO I TOOK IT TO AN AUTHORIZED DEALER TO LOOK AT IT AND THAT IS WHEN I FOUND THE AIRBAGS HAD BEEN REPLACED IMPROPERLY. I FILED A COMPLAINT WITH THE NE DEPARTMENT OF VEHICLES AND WAS TOLD TO FILE A FEDERAL COMPLAINT ABOUT THE AIRBAGS. THANK YOU FOR YOUR TIME

NHTSA ID

11204381

Incident

Mar 21, 2019

TL* THE CONTACT OWNS A 2000 GMC SIERRA 1500. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC) BY WEHR FORD (11311 US-60 BUS, MOUNTAIN GROVE, MO 65711, (417) 926-3192). THE CONTACT STATED THAT THE DEALER ONLY CLEANED THE ABS SENSOR FOR CORROSION. YEARS LATER, THE BRAKE PEDAL FAILED TO RESPOND DUE TO INTERNAL CORROSION REGARDING THE SENSOR. ALSO, THE ABS KEPT INTERMITTENTLY ACTIVATING AND CAUSED EXTREME DIFFICULTY WHEN BRAKING. THE BRAKE PEDAL FAILED TO STOP THE VEHICLE AND CAUSED THE DRIVER TO HAVE TO REVERSE MORE THAN TWICE TO PREVENT A CRASH. THE DEALER WAS NOTIFIED OF THE FAILURES AND INDICATED THAT THE ABS SENSOR MAY NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

11195833

Incident

Oct 26, 2009

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This service bulletin explains how to measure for oil consumption and possible reasons for loss of oil.

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.

GM is receiving damaged (cracked or broken) transmission cores returned to the reman facilities. The damage is being caused either in the removal process by the technician, or inadequate packaging or shipping. This bulletin advises the dealers to be more careful not to damage the transmissions during removal and to package the core properly for return.