2012 GMC Sierra 1500

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

June 29, 2025, Driving on the St. Francis loop in Amarillo, TX, brake lights start flashing, the warning sounds happening, no brakes. I had already slowed down to 35-45 mph due to road construction ahead. I weaved through the cones and as soon as possible, hit the ditch and then coasted to a stop. (I didn’t think about the emergency brake, in my panic.) I turned the vehicle off and called my husband. I decided that I wasn’t pulled over far enough over in the ditch, so I started the pickup again. The lights and warning signals for the brakes were gone and when I pressed on the brake pedal, there were brakes again. I drove home at 35 mph, knowing I could use the emergency brake at that speed, if needed, and had brakes all the way home. GMC Bender repaired truck. After driving approximately 3 miles since repaired, our daughter took the truck to Grease Monkey. She was at the garage door; employee said the pickup didn't need an oil change. She backed out and didn’t have brakes (no warning lights or sounds) and as the truck continued backing, it hit the Grease Monkey sign at the east end of their lot and broke it, knocked the sign over. An employee walked over to see what happened, she told him that she didn’t have brakes. He sat in the pickup seat and pushed on the brakes and said, yes, you don’t have brakes! The police were called, and the officer who showed up took pictures, gave us his card, talked with my husband and talked to the Grease Monkey boss. August 6, 2025, I called GMC Bender Service Department (11 mins. 8 secs.) I told them what had happened. They sent a tow truck to bring the pickup back to their shop. September 16, 2025, my husband texted me saying GMC Bender said that the pickup shows another EBS Modulator Fault. No new parts… used one would be $1293 installed. A week to get it here, no guarantees. There's more details, but the vehicle cannot be repaired to guarantee brakes will work properly. Please help us know what to do next.

NHTSA ID

11756257

Incident

Jun 29, 2025

They should be responsible for repairs or replacement of the cheap made frames that rust away so fast so u ain’t gotta worry about your truck fallling apart going down the rd and the lower control arms made of cast that rust from inside out and you don’t know until breaks while driving along with camber adjustments where they can throw alignment out with a single bump. Mostly the frame replacement is major always having to plate frame or check to make sure it will be able travel long trips or haul stuff in bed or a trailer with breaking or falling off truck causing wreck frame repair is major and time consuming if you don’t have proper stuff and definitely expensive and lower control arms that’ll make a wheel come real fast and it’s time consuming and expensive too but very dangerous and breaks and causes damage right then and there at high or low speed on highways or interstates

NHTSA ID

11739589

Incident

May 22, 2026

The contact owns a 2012 GMC Sierra 1500. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted, especially between second and third gears. The check engine warning light was intermittently illuminated. In addition, the contact stated that the engine felt as though the engine mounts were inoperable. The contact pulled over to the side of the road and turned off the vehicle. The vehicle was restarted, and the vehicle resumed normal driving. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that the failure persisted. The manufacturer was made aware of the failure, but no assistance was offered. The failure mileage was approximately 20,000.

NHTSA ID

11711216

Incident

Jul 14, 2014

Mileage

20,000 mi

Odometer Fraud. The contact purchased a 2012 GMC Sierra 1500. The contact stated that it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the mileage was 111,000, and at the time of registration, it was discovered that the mileage was 243,000. The Carfax Report indicated that the vehicle was serviced at 149,000 and 179,000 miles, then registered at 149,000 and 179,000 miles on August 8, 2024. The contact had filed a police report with the Dillon Police Department -Special Ops Police Department.

NHTSA ID

11682085

Incident

Aug 15, 2025

Mileage

243,000 mi

P0521 has been addressed/replaced almost nine (9) times. “Low Oil Pressure-Stop Engine” is another one that is not completely functional. The truck is using oil but we cant find evidence of leakage. Services performed at dealership or certified shop. Troubleshooting was performed, Im told. I cant vouch for the quality of the workmanship. This should not be an issue at this mileage 100,100 ohe hundred thousand miles and oil components going bad is not good. GMC has sold me a truck that needs a new engine component. Please help. Thanks [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11652682

Incident

Apr 3, 2025

The contact owns a 2013 GMC Sierra. The contact stated that while driving at 70 MPH, she lost consciousness. After regaining consciousness, the contact discovered that the vehicle had crashed into two vehicles and that the driver's side air bag had deployed. The police and paramedics arrived at the scene; however, no one involved in the accident needed immediate medical assistance. A police report was filed. About a week after the accident, the contact stated that they began to develop open sores on both arms as black metal fragments began to leak out of these sores. The contact went to the doctor and was treated for the injuries and was referred to a dermatologist for further assistance. Upon investigation, the contact linked her injuries to the Takata air bag recall. The vehicle was towed to the contact's home and an independent mechanic was able to repair certain parts of the vehicle to make it drivable. The manufacturer was notified of the failure and a claim was filed. The contact was also informed that an inspector would be sent to inspect the vehicle. The vehicle had been repaired. The failure mileage was approximately 312,000.

NHTSA ID

11592379

Incident

Mar 9, 2024

Mileage

312,000 mi

Faulty Tire Pressure Management system. Looking for recalls or service bulletins.

NHTSA ID

11590951

Incident

May 28, 2020

Manufacturer interior defect - Crack on dash w/potential to crumble all the way in Diminishes vehicle

NHTSA ID

11578132

Incident

Jan 1, 2023

This preliminary information communicates information about how to determine if a wheel and tires size change is available.

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

This Preliminary information communicates the steps on how to save a GDS2 Session Log and upload to a Technical Assistance Case in CX Connect.

This PI Communications information on an alternative product dealers can use to perform 19-NA-255: Wax Coating on Frame Peeling, Metal Shows Corrosion/Rusting due to issue with getting product from current supplier listed in the bulletin.

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

This Preliminary Information communication provides information to the technician about vehicles that have had multiple repair attempts that are being performed on customer’s vehicles that exhibit vibration conditions without utilizing the support of General Motors Technical Assistance Center. If valid vibration frequency or Road Force Variation data has been collected and a repair attempt does not correct the customer complaint, contact General Motors Technical Assistance Center for further support. For any vehicles that remains unrepaired after being at the dealer for three days or more and a related bulletin or PI is not found, contact General Motors Technical Assistance Center for further support.