2013 GMC Sierra 2500 Fuel system Problems

The contact owns a 2013 GMC Sierra 2500. The contact stated while driving 60 MPH, the vehicle stalled. There was no warning light illuminated. The contact was able to coast to the side of the road, where a mobile independent mechanic diagnosed that the fuel pump had failed. The mechanic determined that the entire fuel system assembly needed to be replaced. The vehicle was not repaired. The vehicle was then towed to an unknown dealer but was not diagnosed or repaired. The vehicle was currently being towed to the residence. The manufacturer was notified of the failure and informed the contact that the repair could not be covered because the VIN was not included in a related recall and the vehicle was not covered under warranty. The failure mileage was approximately 206,000.

NHTSA ID

11633823

Incident

Nov 29, 2024

Mileage

206,000 mi

I was traveling east bound on i26 when the Bosch fuel pump exploded and sent metal shavings throughout the fuel system. It's the same pump GM has settled a class action lawsuit when I spoke to the adjuster I was told.my truck wasn't included but yet it has the Bosch fuel pump the lawsuit is for cost me 10000 to repair. I have repair bill. And then I was in a accident and the air bag curtain deployed but the passenger side and driver side did not I think there's a recall on the also.

NHTSA ID

11631474

Incident

Mar 29, 2022

Vehicle Shows on the Dash readout that the truck must keep going to clean out exhaust keep Driving, then comes to a Slowdown, and on a slight hill Stops. When you shut it off, and start it up again, it goes about a Mile, states the same thing on the dash panel, then starts to slow down, I was in the Desert of New Mexico, Had left Flagstaff, AZ. an hour before this started happening. I had no Previous warning. Took 6 hours to reach a GMC Service Center. usually takes 2 hours to reach the same town. Cortez, Colorado. They Could NOT Help Me, they had to referred me to a Service Center in town, that Put me on his machine, and Made the Vehicle Heat up, Run HOT, and Exhaust itself for two hours, this got me to my home in Monte Vista, CO. Then No further Problems until about a Month later i started getting the Same Messages, i took it to a Service Center in AR. where he Forced the Vehicle to Get Hot, exhaust itself for four and a half hours, to Clean it out, and Clear my dash Pannel.

NHTSA ID

11457358

Incident

Dec 9, 2021

Diesel Fuel Gage is Not reading Properly. On a Full Tank which use to say I have approx., until 468 Miles, until I Have to re-fuel. Now Reads Less then 288 Miles, on a Full tank. I have reported this Problem to the Town and Country, GMC, Dealer, of Alamosa, CO. when I have taken My Vehicle in for Service on several Occasions, and Nothing has been done about it. and GMC, has still NOT replaced the Recalled Passenger Air Bag. My Wife sits there and Could be Killed Should Her Airbag be deployed. Thank You [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID

11457356

Incident

Jun 28, 2020

I have a 2013 GMC Sierra, purchased new in 2012, has approximately 35,000 miles. The check engine light came on while driving and suddenly another light came on. Then a third light came on claiming poor engine fluid quality. I immediately stopped at an auto parts store and put DEF fluid in the pickup and continued to drive thinking the lights would go out, but instead a warning was flashing on the dash that says after so many miles the truck will be slowed down. We started getting nervous because we were driving on the highway and if the truck suddenly slows down whilst driving in highspeed traffic, our slower vehicle would potentially cause a collision and put us and others in harms way. In reading your own safety site, there is a recall on the vehicle regarding faulty airbags, so it could be even worse! In our investigations of our current issue, we have found that there was a lawsuit from 2019 against GM and their faulty fuel system with their trucks. See link here https://www.detroitnews.com/story/business/autos/general-motors/2019/08/07/lawsuit-says-gm-sold-trucks-not-compatible-american-diesel-fuel/1943084001/ many people on many different forums have also complained about this same problem with no fixes, the only suggestions are to remove the emissions parts and refab the motor. GM tells them that they need to only use their specific DEF fluid, which is steering. GM is very well aware of the problems, because they have employees following these forums and commenting on them.(Dieselplace.com) The truck can be made available for you to see/inspect and I refuse to drive the truck until this issue is resolved.

NHTSA ID

11439435

Incident

Oct 29, 2021

TL* THE CONTACT OWNS A 2013 GMC SIERRA 2500. THE CONTACT STATED WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITH SEVERAL UNKNOWN WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TOWED BACK TO THE RESIDENCE. AN INDEPENDENT MECHANIC WENT TO THE CONTACT'S RESIDENCE TO DIAGNOSE THE VEHICLE. THE CONTACT WAS INFORMED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE FUEL PUMP WAS REPLACED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE MANUFACTURER AGREED TO PAY 20% OF THE REPAIR COST. THE FAILURE MILEAGE WAS APPROXIMATELY 106,000.

NHTSA ID

11415966

Incident

Apr 14, 2020

Mileage

106,000 mi

I'M GETTING AN INACCURATE FUEL GAUGE READING.

NHTSA ID

11186284

Incident

Oct 10, 2018

Mileage

110,000 mi

P21DD CODE LOW VOLTAGE. THIS IS SECOND TIME IT HAS BEEN REPLACED. 62145 MILES ON TRUCK..

NHTSA ID

11156085

Incident

Nov 20, 2018

Mileage

62,145 mi

BOSCH CP4 FUEL PUMP FAILURE. PLEASE REFERENCE EA11-003 AND FIND THE SAME FUEL PUMPS THAT WERE FOUND TO FAIL ON AUDI/VW VEHICLES ARE ALSO USED ON GM, FORD, AND DODGE VEHICLES. SAID PUMP FAILED DURING DRIVING WITHOUT WARNING CAUSING COMPLETE ENGINE SHUTDOWN AND LOSS OF POWER. CERAMIC AND METAL INTERNALS OF THE PUMP DISINTEGRATED AND TRAVELED THROUGH THE FUEL SYSTEM, SUBSEQUENTLY CAUSING THE INJECTORS TO FAIL. SIMILAR TO THE FINDINGS IN EA11-003, PAGE 16 PARAGRAPH 2, THE REPAIR IS TO COST APPROXIMATELY $10,000 TO FIX THE ENTIRE FUEL SYSTEM. *TR

NHTSA ID

10943828

Incident

Dec 27, 2016

Mileage

49,000 mi