2022 GMC Sierra 3500 Problems

The contact owns a 2022 GMC Sierra 3500. The contact stated that while driving at 30 MPH, the message “Trailer Brake Disconnected" was displayed on the instrument panel. The contact was hauling a 5th-wheel trailer during the failure. The contact pulled over to the side of the road, turned off the vehicle, and waited for several minutes before restarting the vehicle. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that the failure persisted. Most recently, while driving 55 MPH, the message "Trailer Brake Disconnected" was displayed. The contact pulled over to the side of the road, turned off the vehicle, and waited before restarting the vehicle and continuing driving. The contact stated that before the most recent failure, the vehicle was taken to the dealer and the trailer plug was replaced. The vehicle was not diagnosed or repaired after the most recent failure. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 21V758000 (SERVICE BRAKES, HYDRAULIC); however, the VIN was not included. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was approximately 30,000.

The contact owns a 2022 GMC Sierra 3500. The contact stated while the vehicle was parked, the trailer plug was connected, and electrical fuses popped. The contact stated that all the fuses were blown. In addition, the contact stated while driving the vehicle, the trailer brakes failed to function as intended. The contact stated that the trailer brakes went off and on. The vehicle was taken to the dealer where it was diagnosed with trailer brake control module failure. The contact was informed that the trailer brake control module needed to be replaced. The vehicle was repaired. The contact referenced an unknown recall; however, the VIN was not included in the recall. Additionally, the contact stated that the failure had previously occurred, and an unknown part was replaced; however, the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was approximately 31,308.

Catastrophic failure of drivers side rear tire. Complete delamination of tire causing severe vehicle damage. Tire and vehicle is available for inspection upon request. Tire exploded causing serious risk to passengers at highway speeds. Tire has not yet been inspected due to date of incident being on Saturday. Immediately prior to incident a small vibration was noticed in the rear approximately 1 minute before failure. Tire pressure was at 80 psi when troubleshooting vibration while traveling. Tire size 275/65 R20

The contact owns a 2022 GMC Sierra 3500 equipped with Goodyear Tires, Tire Line: Wrangler Trailrunner AT, Tire Size: LT275/65/R20, DOT: (N/A). The contact stated that while hauling a camper and driving approximately 45 MPH and making a left turn, the driver's side rear tire had a blowout and the tread detached from the tire. During the failure, the camper swayed to the left. The contact was able to regain control of the vehicle and decelerated until the contact was able to stop the vehicle. While on the side of the road, the contact replaced the tire with the spare tire. The dealer was contacted and notified of the failure. The cause of the failure was not determined. The manufacturer was not made aware of the failure. The failure mileage was 27,666.

MY TRUCK IS EXPIERANCING THE SYMPTOMS OF RECALL # N242454440 TRANSMISSION VALVE BODY, ITS SHUTTERING BETWEEN SHIFTS AND CLUNKING IM AFRAID OF THE REAR WHEELS LOCKING UP FROM THE HORROR STORIES I HAVE READ THE TRUCK IS AT COULTER GMC NOW FOR EXACT DIAG BUT FROM EVERYTHING I HAVE READ THIS IS COMMON ISSUE FOR THIS RECALL THAT MY VIN DOES NOT FALL UNDER FOR SOME REASON

While driving on the interstate we were exiting to pull into a rest area while slowing down the rear wheels momentarily locked up and the truck downshifted hard and abruptly with that happening the check engine light came on along with a decreased power message. We pulled into a parking spot during so we tried to shift into reverse and it didn’t want to shift into reverse, we tried this for a while. We finally got it into reverse and we were able to back out of the parking spot. When we tried shifting to drive we encountered the same issue. The vehicle did not want to go into drive. Once finally into drive it did not want to shift into any higher gears. It was essentially stuck in one of the gears. We made it to a GMC dealer on the next exit -we drove on the side of the interstate to get there- when we arrived we had them run the codes and they told us it was a transmission control valve which GMC has had a major recall on. While we had this “fixed” at a different dealership previously in march of 2025 it only entailed “updating the software” involving the transmission control valve. We had to leave the truck at the GMC dealer that we were able to ‘limp’ to in Crestview FL. We’ve been told our truck now needs an entirely new transmission that is going to cost $7,000. We had a similar issue right after the “software update for the transmission control valve” on march 20, 2025. The software was updated roughly a week before that incident which seemed to have cleared itself because it was momentarily and never happened again until now. Our safety was at risk because we had to drive on the side of the interstate to get to a shop because we were out of town and a tow truck was going to cost between 600-1000 dollars to get home.

• What component or system failed or malfunctioned, and is it available for inspection upon request? The issue appears to be with the gear shifter assembly and/or park position sensor within the power train system. The vehicle fails to detect that it is in “Park,” even when the gear lever is physically in the Park position. Yes, the vehicle and component are available for inspection upon request. ⸻ • How was your safety or the safety of others put at risk? This malfunction prevents the vehicle from shutting off properly and displays a “Shift to Park” message even when parked. This creates a risk of the vehicle rolling away if the parking brake is not engaged and prevents secure shutdown, potentially draining the battery or creating confusion in an emergency. It compromises both driver and public safety. ⸻ • Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the issue was reproduced and acknowledged by a certified GMC dealership service department. They noted it is a known issue affecting other GM vehicles but stated there is no open recall or warranty extension currently available for my specific model. ⸻ • Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has only been inspected by a GMC-certified dealership. No inspection has been conducted by the manufacturer, police, or insurance representatives at this time. ⸻ • Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes, a “Shift to Park” message appears on the dash even when the shifter is correctly placed in the Park position. This message began appearing intermittently and has now become a consistent issue over the past few weeks.

The GM N242454440 “collision Rear Wheel Lock Up from Transmission Valve Failure” was performed. The recall rendered the electrical charging system inoperable. GM engineering has been working on the vehicle for more than one month and recently determined that the recall software does not work properly with all vehicles. My truck is being returned to me without the recall being performed. Accordingly the safety hazard associated with rear wheel lockup has not been addressed and cannot be addressed at this time. Presumably GM will develop software in the future to address the safety condition. Meanwhile the safety hazard remains unaddressed for my vehicle and an unknown number others. Reference Riverview Chevrolet GMC repair order 894074

The contact owns a 2022 GMC Sierra 3500. The contact stated that the rear windshield frame was cracked, which allowed water to leak into the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 29,000.

While traveling at highway speed, the hood-mounted air vent (factory-installed component) on my 2022 GMC Sierra 3500 HD suddenly detached from the vehicle without warning. Upon separation, the vent was propelled backward, striking both the hood and the windshield. The incident occurred during normal driving conditions, with no prior indication of looseness, damage, or defect in the component. The force of the detachment caused damage to the hood and posed a significant safety risk, as the debris impacted the driver’s line of sight and could have resulted in loss of control or injury. There were no external factors (such as collision or road debris) that contributed to the failure. This appears to be a failure of the factory-installed component and its mounting system. Safety Concern: This type of failure presents a serious hazard not only to the vehicle occupants but also to other motorists. A detached component at highway speed could strike nearby vehicles, cause sudden driver distraction, or lead to more severe accidents.

Engine lag and performance drops while driving vehicle. Vehicle was taken to the dealership and remained at dealership for five days. Employee was given permission to drive the vehicle to experience the issue. Issue was confirmed by dealership, but they stated it's one of three issues and they would have to repair all three issues at my cost to figure out what's causing the engine lag.

VARIOUS WARNING LIGHTS ARE COMING ON SINCVE I PURCHASED THIS VEHICLE, SUCH AS ABS, ENGINE POWER REDUCED, OIL CHANGING SERVICE, SERVICE ENGINE LIGHT, SERVICE TRAILER BRAKE SYSTEM, WHEEL TRACKING, SERVICE ESC, PASSING GEAR CUTS OUT. MY VEHICLE HAS BEEN IN THE SHOP MANY TIMES AND IS IN THE SHOP NOW. I HAVE A DEEP CONCERNED FOR THE SAFETY PERFORMANCE OF THIS VEHICLE FOR MYSELF AND MY FAMILY.

I tried to honk the horn when a car started to come into my lane and discovered that it was not working. I took it to the dealership, and they said it needed a new steering wheel as the contacts that operate the horn were faulty. they told me that the steering wheel airbag would not be operational due to this problem until it was fixed. This is a 2022 pickup with only 10,000 miles on it. I’ve never had to use the Horn before I, so to discover that the issue is pretty serious was disconcerting, and of course my 36 month bumper-to-bumper is used up. This vehicle is basically brand-new, and there should be a recall on this vehicle.

On July 27, 2022 I was driving my 2022 GMC truck on the freeway. I was rear ended by a semi truck and the passenger side was side swiped by the semi. I was driving the truck with my wife and two kids as passengers. The truck was completely totaled. No airbags deployed and the seat belts did not restrain us. All 4 of us were wearing seat belts. Also, the drivers seat completely broke, it looked like it had been completely reclined to a laying position. A police report was made. All 4 of us were taken by ambulance to the hospital. All 4 of us needed medical care. The truck was totaled and towed, the insurance has since taken possession of the truck. There were no warning lights, service lights or any indication that there was anything faulty with the truck. We had just purchased it in February 2022. My safety, as well as the safety of others was put at risk. The semi truck driver stated he was driving 60mph. If this isn't enough for air bags to deploy, I don't know what is. The seat belts also failed to restrain us. The seat belts were completely loose and during the accident failed to secure us. Again, the drivers entire seat completely broke causing severe head, neck and back injuries.

I purchased 2022 GMC Sierra HD last year. Due to Micro Chip shortages at the time GMC provided custo.ers a $50.00 credit and notice that they provide the chips ASAP and that it should be provided by December 2022. I like many others accepted the risk for not having parking assist sensors and other features for this period of time. I contacted GMC last month after speaking with my dealer and was told by GMC customer service that GMC has instead adopted an approach of providing Chips to new vehicles while they work on getting chips for those vehicles already sold. No where in the agreements that customers signed did it acknowledge that we would be prioritized by GMC in order for them to make new vehicle sales over the increased safety risks. I drive a GMC HD (3500) which has significant blind spots and Increased safety risks to pedestrians as a result of no warning detection systems during parking in lots and on streets. I would like to have this risk mitigated by having GMC honor the agreements and commitments to its customers by providing the Micro Chips required to fulfill these safety requirements ahead of new sales, so no injuries or loss of life are sustained as a result of this profit over safety stance that GMC has adopted. I would like the NHTSA to assist consumers in addressing this safety issue.

Bought. New 2022 GMC HD 3500 last year and signed form from GMC saying front and rear parking sensors were delayed until December 2023, related to supply chain issues. I have continually tried to get a status of the needed micro chips and now have been told today that GMC has no status as they are focusing on the new vehicles so they can continue to sell vehicles and make profits. GMC knows this is an on going safety issue but continues to ignore vehicles already sold.

The contact owns a 2022 GMC Sierra 3500. The contact stated that the rear windshield frame was cracked, which allowed water to leak into the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 29,000.

While driving on the highway at night during mixed precipitation/icy conditions I noticed I was loosing visibility. I had to pull over on the highway to see if my headlights were on. I discovered they were completely covered in 1.5-2in of ice. The entire front grill of the truck was covered in ice. I had to chip off the ice on the headlights so I could see. I had to pull over three times during my 2hr drive to scrape the lights just so I could see! The headlights on the 22 model have shape, not straight or a smooth curve like prior models, which is part of the problem. Although, it was strange how the entire grill was covered in ice. I have always owned GMC or Chevy trucks and have never had anything like this happen. I wish I took a picture to send in but I didn't think of that in the moment. This is absolutely a safety hazard. I hope in the near future there will be a recall to have this issue addressed.

On July 27, 2022 I was driving my 2022 GMC truck on the freeway. I was rear ended by a semi truck and the passenger side was side swiped by the semi. I was driving the truck with my wife and two kids as passengers. The truck was completely totaled. No airbags deployed and the seat belts did not restrain us. All 4 of us were wearing seat belts. Also, the drivers seat completely broke, it looked like it had been completely reclined to a laying position. A police report was made. All 4 of us were taken by ambulance to the hospital. All 4 of us needed medical care. The truck was totaled and towed, the insurance has since taken possession of the truck. There were no warning lights, service lights or any indication that there was anything faulty with the truck. We had just purchased it in February 2022. My safety, as well as the safety of others was put at risk. The semi truck driver stated he was driving 60mph. If this isn't enough for air bags to deploy, I don't know what is. The seat belts also failed to restrain us. The seat belts were completely loose and during the accident failed to secure us. Again, the drivers entire seat completely broke causing severe head, neck and back injuries.

On July 27, 2022 I was driving my 2022 GMC truck on the freeway. I was rear ended by a semi truck and the passenger side was side swiped by the semi. I was driving the truck with my wife and two kids as passengers. The truck was completely totaled. No airbags deployed and the seat belts did not restrain us. All 4 of us were wearing seat belts. Also, the drivers seat completely broke, it looked like it had been completely reclined to a laying position. A police report was made. All 4 of us were taken by ambulance to the hospital. All 4 of us needed medical care. The truck was totaled and towed, the insurance has since taken possession of the truck. There were no warning lights, service lights or any indication that there was anything faulty with the truck. We had just purchased it in February 2022. My safety, as well as the safety of others was put at risk. The semi truck driver stated he was driving 60mph. If this isn't enough for air bags to deploy, I don't know what is. The seat belts also failed to restrain us. The seat belts were completely loose and during the accident failed to secure us. Again, the drivers entire seat completely broke causing severe head, neck and back injuries.

The contact owns a 2022 GMC Sierra 3500. The contact stated that while driving at slow speeds, there was a loud banging sound coming from the vehicle. The contact exited the vehicle and became aware that the front passenger’s side tire was inverted towards the engine compartment. Pictures of the damages were taken to a dealer, and the contact was informed that the control arm had snapped; however, the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 10,000.

The contact owns a 2022 GMC Sierra 3500. The contact stated that the check engine warning light was illuminated intermittently. The contact stated while driving approximately 50-70 MPH, the check engine warning light illuminated. Additionally, the contact noticed that the vehicle was experiencing reduced power and performance. The vehicle was taken to the dealer, where the NOx sensor was replaced and a manual DPF regeneration was performed. The vehicle was repaired and remained at the dealer. The contact related the failure to GM Campaign Number: N212351211. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 68,000.

While driving on the highway at night during mixed precipitation/icy conditions I noticed I was loosing visibility. I had to pull over on the highway to see if my headlights were on. I discovered they were completely covered in 1.5-2in of ice. The entire front grill of the truck was covered in ice. I had to chip off the ice on the headlights so I could see. I had to pull over three times during my 2hr drive to scrape the lights just so I could see! The headlights on the 22 model have shape, not straight or a smooth curve like prior models, which is part of the problem. Although, it was strange how the entire grill was covered in ice. I have always owned GMC or Chevy trucks and have never had anything like this happen. I wish I took a picture to send in but I didn't think of that in the moment. This is absolutely a safety hazard. I hope in the near future there will be a recall to have this issue addressed.