2002 GMC Yukon Xl Tires & wheels Problems

WAS DRIVING APPROX 60MPH ON NEWLY PAVED 4 LANE HIGHWAY (US 31). VEHICLE BEGAN TO MAKE A NOISE AND THEN SHAKE. FRONT DRIVER'S SIDE TIRE WAS COMPLETELY DESTROYED WITH APPROX 80% OF THE TREAD AND BELT SEPARATED FROM THE TIRE AND NUMEROUS HOLES IN THE TIRE. MANY SHARP STEEL PRONG ENDS WERE STICKING OUT OF THE TIRE AND THE SEPARATED TREAD/BELT. DESTROYED THE WHEEL WELL COVERING. 2002 YUKON XL. TIRES HAD BEEN INSTALLED IN MARCH 2008. WHEN LOOKING AT THE FRONT PASSENGER SIDE TIRE, IT HAD NUMEROUS LARGE CRACKS FROM THE TREAD EXTENDING INTO THE SIDEWALL. TO AVOID HAVING ANOTHER BLOWOUT/SEPARATION, QUICKLY REPLACED THAT TIRE AND RETURNED BOTH TO THE DEALER WHERE PURCHASED. HAVING THE DEALER CONTACT COOPER AND INSPECT THE REAR 2 TIRES AS WELL (VISUAL INSPECTION DID NOT SHOW THE TREAD/SIDEWALL CRACKS). *TR

NHTSA ID

10277517

Incident

Jul 18, 2009

Mileage

125,000 mi

(1) NONE (2) PULLED OUT ON HWY AT NORMAL SPEED, LOUD WINING, AND LOUD POP.TRANSMISSION FAILED, LEFT WITH ONLY 2ND AND 3RD GEAR.(3) CALLED TRANSMISSION SHOP AND THEY DESCRIBED IN DETAIL THE FLAW THAT CAUSED FAILURE. THEY INFORMED ME THAT THIS WAS QUITE COMMON IN THIS MODEL. I FEEL THAT THIS SHOULD BE REPORTED AS A RECALL, TO CORRECT THIS DEFECT.

NHTSA ID

10120966

Incident

May 12, 2005

Mileage

68,750 mi

SPARE TIRE CARRIER WINCH CABLE FAILED ON 2002 GMC YUKON XL AT HIGHWAY SPEED. THE SPARE TIRE COLLIDED WITH THE AUTO FOLLOWING ME CAUSING EXTENSIVE DAMAGE.*AK

NHTSA ID

10118019

Incident

Apr 17, 2005

Mileage

65,000 mi

ON 11/23/04 LEFT FOR VACATION NOTICED THAT FLUID WAS LEAKING ABOUT TWO HOURS INTO OUR TRIP. STOPPED AT DEALERSHIP IN BARSTOW, WHERE WE WERE TOLD TRANSFER CASE WAS HEATING UP AND EXPANDING AND THAT IT HAD TINY CRACKS THAT THE FLUID WAS LEAKING OUT OF. NEEDED A NEW TRANSFER CASE ORDERED ON 11/24 AND AUTHORIZED OVERNIGHT SHIPPING. CALLED FROM 11/29 TO 12/3 WHEN I WAS FINALY TOLD THAT PART WAS ON NATIONWIDE BACKORDER AND WOULD NOT BE SHIPPED. MY CAR WAS NOT READY UNTIL 12/15. I HAVE CONCERNS THAT THIS IS A WIDE SPREAD PROBLEM SINCE THE PART WAS ON BACKORDER AND THAT GMC WILL NOT REIMBURSE PARTS AND LABOR OR RENTAL CAR FEES. I WAS ALSO VERY DISAPPOINTED IN THE CUSTOMER SERVICE DEPARTMENT. CONTACTED THEM AND WAS TOLD WHAT INFO. TO SEND. SENT IT DID NOT HEAR FROM FOR APPROXIMATELY THREE WEEKS THEN WAS TOLD THAT THEY DID NOT RECEIVE ALL INFO. LEFT AT LEAST 15 MESSAGES AND NEVER RECEIVED PHONE CALL BACK CALLED AND ASKED TO SPEAK TO SUPERVISOR AND FIRST WAS TOLD NO THEN FINALLY FOUND A REPRESENTATIVE THAT GAVE ME SUPERVISOR. I RESENT PAPERWORK THAT WAS SUPOSSEDLY MISSING AND WAS TOLD ABOUT A WEEK AND A HALF LATER THAT THEY WOULD GIVE ME CREDIT TOWARD A NEW PURCHASE OR OIL CHANGES FOR THE EQUIVELANT OF 1 YEAR. *AK

NHTSA ID

10116482

Incident

Nov 23, 2004

Mileage

64,209 mi

WHILE DRIVING MY 2002 YUKON XL, THERE IS YELLOW LIGHT APPEARED ON THE I/P CLUSTER MESSAGE CENTER. "SERVICE 4WD" AND WHEN GENTLY APPLY/PRESSING ON THE BRAKE PEDAL, THE IS SOME KIND OF LOUD MECHANISM NOISE IN THE FRONT WHEEL DRIVER SIDE, AND PREVENT THE BRAKE PEDAL FROM COMING DOWN. THREE TIMES THAT I ALMOST REAR END OTHER VEHICLES. TOOK THE VEHICLE TO THE DEALERSHIP TO GET IT FIXED, THE COST WAS $2212.93 FOR FIXING BRAKE SYSTEM FAILURE INCLUDING ANTI BRAKE SYSTEM AND 4WHEEL DRIVE. DEALER RECOMMENDED TO A REPORT TO NHTSA.

NHTSA ID

10108502

Incident

Jan 18, 2005

I AM THE ORIGINAL OWNER OF A 2002 YUKON XL TRUCK. I PURCHASED THE TRUCK TWO YEARS AGO FROM A GMC DEALER IN MACON GA. I NOTICED THE STEERING COLUMN FELT LOOSE AND MADE UNUSUAL NOISE WHEN GOING OVER BUMPS AND WHEN TURNING. I TOOK THE TRUCK INTO A LOCAL DEALER UNDER A WARRANTY CALL. THE SERVICE DEPARTMENT REPAIRED/ADJUSTED THE STEERING SYSTEM AND THE VEHICLE DROVE FINE FOR APPROXIMATELY 6 MONTHS. HOWEVER THE SAME NOISE CAME BACK AND THE TRUCKS ANTI LOCK BRAKE LIGHT AND TRACTION ASSISTANCE LIGHTS CAME ON. I TOOK THE TRUCK TO A REPAIR SHOP TO HAVE IT LOOKED. THE SHOPS OWNER DISCOVERED ONE OF THE FRONT HUB ASSEMBLIES HAD FAILED AND NEEDED TO BE REPLACED. THE OWNER TOLD ME THE HUBS BEARINGS HAD COMPLETELY FAILED AND THERE WAS A STRONG POSSIBILITY THE WHEEL COULD HAVE SEPARATED FROM THE VEHICLE. THIS TRUCK IS 2 YEARS OLD AND ONLY HAS 50,000 MILES ON IT. *JB

NHTSA ID

10098650

Incident

Nov 2, 2004

Mileage

49,900 mi

UPON ROTATING THE TIRES MECHANIC DETERMINED THAT ALL 4 TIRES INNER TREAD WAS CUPPING. HOWEVER, MECHANIC COULD NOT IDENTIFY THE CAUSE OF THE TIRE CUPPING BECAUSE VEHICLE'S ALIGNMENT WAS UP TO SPECS, AND TIRE PRESSURE WAS WELL MAINTAINED.*AK *MR

NHTSA ID

10061245

Mileage

19,000 mi

TREAD SEPARATION ON FIRESTONE WILDERNESS TIRE. *AK

NHTSA ID

10056745

Incident

Feb 6, 2004

Mileage

24,000 mi

TIRES ON 2002 GMC YUKON XL FIRESTONE WILDERNESS P265R70-16 ARE CUPPING AND ARE WORN OUT. 26000 MILES. GMC DEALER SAYS IT IS TIRE DEFECT, FIRESTONE DEALER SAYS IT A DESIGN DEFECT IN VEHICLE. FIRESTONE DEALER SAYS THEY SEE NUMEROUS CASES OF PREMATURE TIRE WARE DUE TO DESIGN DEFECT IN VEHICLE FRONT SUSPENSION. NEED ASSISTANCE IN RESOLVING ISSUE OF DEFECT TIRE VS VEHICLE. *LA

NHTSA ID

10043795

Incident

Oct 28, 2003

Mileage

26,000 mi

I BOUGHT A NEW 2002 YUKON XL WHICH CAME WITH FIRESTONE WILDERNESS LE TIRES INCLUDING THE SPARE. I HAVE ROTATED ALL TIRES PROPERLY AND ACCORDING TO THE MAINTENANCE SCHEDULE, EVERY THREE TO FIVE THOUSAND MILES. I HAVE HAD THE FRONT END ALIGNMENT CHECK OUT, WHICH WAS FOUND TO BE PERFECTLY IN ALIGNMENT. THE TIRES HAVE 24,000 MILES ON THEM. ALL FOUR OF MY TIRES ARE DEFECTIVE WITH HIGH/LOW SPOTS ON THE OUTSIDE AND INSIDE TREAD. THE THREE CENTER ROWS OF TREAD ARE WEARING PERFECTLY CORRECT AND EVEN. THE TIRE SHOP AND THE DEALERSHIP RECCOMMENDS REPLACING ALL THE TIRES BECAUSE THEY ARE A SAFETY HAZARD AND COULD POSSIBLY CAUSE ME TO HAVE AN ACCIDENT AT HIGHER HIGHWAY SPEEDS.*AK

NHTSA ID

10032851

Incident

Aug 12, 2003

Mileage

24,000 mi

FIRESTONE TIRE EXPLODED WHILE DRIVING SPEED LIMIT TOO LAKE HAVASU, AZ, MAY 28, CAUSING ERRATIC CONTROL OF VEHICLE. APPEARS SIDEWALL DISLODGED FROM TIRE AND AND TREAD DISLODGED FROM BASE TIRE FRAMING. TIRE INFO: FIRESTONE WILDERNESS LE - P265/70R16 111S M/S; TUBELESS; OTHER NUMBER ON SIDE OF TIRE: DD726G G09R (E4) 027680 DOT 8 X 72 WL2 .DAMAGED AREA SHOWS A NUMBER ?4601? (? = DENOTES UNKNOWN NUMBERS IF ANYIN THESE PLACES) DAMAGE TO UNDERCARRAGE OF VEHICLE AS WELL TO THE WHEEL WELL.*AK

NHTSA ID

10020892

Incident

May 28, 2003

Mileage

23,079 mi

I WAS DRIVING ABOUT 70 MPH WHEN MY LEFT REAR TIRE BLEW OUT. TIRE HAD ABOUT 26,600 MILES AND WAS IN GOOD CONDITION UNTIL THIS TIME. TIRE HAD ABOUT 35 PSI. *NLM

NHTSA ID

10018962

Incident

May 10, 2003

Mileage

26,665 mi

FIRESTONE TIRE WITH 10,571 MILES ON IT SHREDDED. P265/70R16 IIIS M/S INSTALLED ON 2002 GMC YUKON XL

NHTSA ID

10002613

Incident

Jan 13, 2003

Mileage

10,571 mi

AFTER OWNING MY 2002 GMC YUKON XL, I NOTICED UNEVEN TIRED TREAD WEAR AT ABOUT THE 5000 MILE MARK. WHEN MY VEHICLE WAS TAKEN INTO THE CARRIAGE MOTORS COMPANY SERVICE DEPARTMENT FOR MY VEHICLE'S 7500 SERVICE, I MENTIONED MY CONCERN FOR MANNER IN WHICH MY TIRES WERE WEARING. BOTH THE FRONT AND BACK TIRES HAD THE SAME TIRE WEAR SINCE THEY HAD BEEN ROTATED AT 5000 MILES. THE TREAD WEARS UNEVENLY ON THE INSIDE OF BOTH THE FRONT TIRES, CAUSING EXCESSIVE TIRE NOISE FROM INSIDE THE CABIN AND MORE IMPORTANTLY, THE VEHICLE PULLS FROM SIDE TO SIDE. MOST NOTEABLY RIGHT AFTER THE TIRES ARE ROTATED. I HAVE SINCE COMPLAINED ON NUMEROUS OCCASSIONS TO CARRIAGE MOTORS AND EACH TIME WAS GIVEN THE RESPONSE THAT IT IS NORMAL TIRE WEAR FOR A GMC YUKON. SECOND OPINIONS WERE SOUGHT FROM DIFFERENT TIRE DEALERSHIPS IN THE TEMECULA AREA, WITH ALL STATING THAT IT IS NOT NORMAL. MY CONCERN IS FOR MY WIFE AND THREE CHILDREN, AS MY SPOUSE IS THE PRIMARY DRIVER OF THIS VEHICLE. THE VEHILCE HANDLES VERY POORLY ON THE FREEWAY AND MOST RECENTLY, HAVING RECEIVED SOME RAIN IN OUR LOCAL AREA, I WAS ALARMED AT HOW POORLY THE VEHILCLE HANDLED ON THE WET ROADS. A LOCAL TIRE COMPANY IN MY AREA STATED THAT MY TIRES ON NOT CONTACTING PROPERLY WITH THE ROAD, WHICH RESULTS IN POOR HANDLING. IN ADDITION, THE CARRIAGE MOTOR COMPANY STATED THE REASON FOR THE MANNER IN WHICH THE TIRES WEAR FOR "YUKONS" WAS THE DESIGN BY GMC IN AN ATTEMPT TO MAKE A SMOOTHER RIDE FOR THIS VEHICLE. I AM SEEKING THE NHTSA ASSISTANCE IN THIS MATTER AS I HAVE EXHAUSTED ALL EFFORTS WITH THE CARRIAGE MOTORS AND GMC CUSTOMER ASSISTANCE. IF YOUR AGENCY IS UNABLE TO ASSIST ME PLEASE DIRECT ME TO THE APPROPRIATE AGENCY THAT WILL PROVIDE ASSISTANCE IN THIS MATTER. DT

NHTSA ID

770720

Incident

Apr 16, 2002