2016 GMC Yukon Xl Owner Complaints

After my child had thrown up all over the car seat her father had taken her inside to clean up and I took the car seat apart to throw the pieces into the washer to clean them. The harness strap did not come out fully clean so I contacted Graco for a replacement piece and I was told that they don’t replace those and that the strap being removed totaled my car seat. It has a woven material tab that goes up through the hard plastic base and locks in by opening itself. It’s essentially a T in the material so it can be folded to go back through the hard plastic base. I was told that since the manual doesn’t provide instructions regarding that piece that I should know it’s not to be removed. No where in the manual, on the car seat or on the strap says it’s not to be removed. I did not damage/break/cut any pieces to get it in or out of the car seat. I was a mom in a panic trying to clean the car seat as quickly as possible so I could tend to my sick child. There were no warning signs telling me anywhere not to remove it. I don’t want other parents to do what I did and have a totaled car seat that they continue to use. I did not have the manual at the time of removing the pieces for cleaning but I have since located the PDF and read through all 96 pages.

NHTSA ID

11746486

Incident

Jun 1, 2026

My wife was driving down the highway and out of no where there was a loud taping sound, the vehicle started running real bad (skipping), the vehicle lost power and she lost control of the steering. As a result, she ran off the road into a ditch. this is a known concern with the 6.2 liter engines and all signs are pointing to lifter failure. She could have ben seriously injured and GM is responsible for this.

NHTSA ID

11732911

Incident

Apr 21, 2026

TRANSMISSION FAILURE ON 8L90 8 SPEED TRANSMISSION. 93,000 MILES.

NHTSA ID

11732277

Incident

Apr 1, 2026

I am submitting this complaint to report what I believe to be a serious and systemic safety defect involving GM 6.2L engines equipped with fuel efficiency systems such as Active Fuel Management (AFM) or Dynamic Fuel Management (DFM). I have experienced catastrophic engine failure in two separate GMC Yukon Denali vehicles with nearly identical symptoms, which strongly suggests a broader design defect rather than isolated mechanical issues. My first vehicle, a 2015 GMC Yukon Denali XL, developed significant engine performance problems consistent with known lifter and camshaft failures widely reported in GM vehicles using these fuel efficiency systems. Due to ongoing reliability concerns and the financial burden of potential repair, I was forced to trade this vehicle at a loss. My second vehicle, a 2016 GMC Yukon Denali XL equipped with the same engine platform, suffered sudden and catastrophic engine failure in February 2026. This failure occurred abruptly and without meaningful prior warning, rendering the vehicle inoperable and creating a potentially hazardous situation. Sudden engine failure of this nature presents a significant safety risk, particularly if it occurs at highway speeds or in heavy traffic. An oil service had been performed on this vehicle in December 2025 at a Jiffy Lube franchise. After the failure, an independent service provider documented that the oil fill cap had been left loose. However, the Jiffy Lube franchise and its insurance carrier have denied responsibility, asserting that the engine failure is attributable to known defects and reliability issues associated with GM’s fuel efficiency engine systems. As a result, both the manufacturer and the service provider are denying responsibility for a catastrophic mechanical failure that has serious safety implications. This leaves consumers exposed to sudden engine failure risk with no meaningful recourse. Based on my direct experience with two separate vehicles exhibiting similar catastroph

NHTSA ID

11727109

Incident

Feb 28, 2026

AFM system failed resulting in engine replacement.

NHTSA ID

11719971

Incident

Nov 10, 2025

I was test driving the vehicle after some and as I was test, driving it, the steering lot up on me. Luckily, I was entering a residential area when it occurred down the street from my residency; in which I was able to drive it to my residency, during that short ride, you could smell a burning smell coming out along with some crackling noises. I had to get the vehicle towed a week later to the mechanic shop where they fix one of my engine problems and verified that I needed a new power steering unit and gave me a quote, I couldn’t afford the word and started doing research and came across the recall for the power steering within my vehicle year, make and model. I replaced the power steering unit, but I’m having a difficult time celebrating the system..

NHTSA ID

11719051

Incident

Jan 11, 2026

My vehicle has been in 16 times since I bought it the most recent incident is for the engine which started about six months ago. It’s been in since then for other issues concurrently with this one it hesitates like it’s getting stuck in sand before it wants to go first the mechanic told me he didn’t sense it but the thermostat was stuck open so they fix that. Second time it went in they thought it was some sort of a filter and some other components I’m not sure. Again it was not fixed then my son and I were out in Minnesota freezing cold night in November and go and drive and then when again it was the drive train this time that got fixed a month ago about a week ago it starts making a noise like there’s too much snow in the tires. I get my car washed every few days but I got it washed again and that didn’t fix it so it’s in the shop again and I’m paying for a rental again. I have the Walser guard thank the Lord because it’s paid for itself about 15 times over. I’ve gotten two transmissions, an air conditioner, two sensors the arm that other people have complained about I don’t know exactly the name of it the trailer component that you plug into also blew out my seven way and I had to have my seven way wire fixed so I’m nervous about plugging that back in. My dad passed away and I spent $70,000 of my inheritance by this car. I should’ve flushed it down a toilet instead. Everybody makes fun at work that this car is literally gonna kill my kids and I because every other day it feels like we’re stuck on the side of the road.

NHTSA ID

11717371

Incident

Jan 30, 2026

Driving after dark on a main street in St George Utah, the engine suddenly surged and then revved down. It felt like someone jamming it into 4WD. Traffic was tailgating me, and I was nearly hit. I could not pull completely out of the right lane. I put on hazard lights. Check engine light came on, and TCS light came on. I decided to get out of traffic & crawled forward about 30 yards into a Sinclair station lot, then backed it into a spot where a tow truck could get it. It was clearly not drivable. Called AAA and a driver was able to get to me within 1/2 an hour. Checked the AAA website for mechanics since I was merely travelling through St. George and had no knowledge of the area. Hawker's Automotive was listed first, with many excellent reviews. Tow truck arrived and driver loaded it on the JerrDan bed. I asked him to take me to the Hawker's garage location. I locked it and put the key in the overnight box with my name, number, and description. Next day the mechanics said lifter arm was collapsed. Needed tearing down, replacing and probably new camshaft. Gave me estimate for "estimated" repair of about $8,000 or new engine at about $12,000! This is a KNOWN GMC failure apparently. Recalls have been initiated on newer models, but every mechanic will tell you that this happens all the time to all the 6.2L, V8 engine at around 150,000. I bought it used at about 156,000 miles and have put about 5,000 miles on it. And changed the oil at purchase, and about 1,000 miles ago. I researched model and year before purchasing. All online reviews I found were positive. Nothing out there on this know manufacturing flaw. But now when I type in 'catastrophic engine failure 2016 Denali XL" many many reviews and videos state that it is a known problem to both GMC and NHTSA. I or someone could have been killed by such a dramatic loss of power! This is a SAFETY issue and NHTSA needs to review ALL THE COMPLAINTS ON FILE ALREADY. Thankyou

NHTSA ID

11713229

Incident

Jan 21, 2026

There is a hesitation when trying to accelerate. The car will then slam forward and there is a rattling noise that the car also makes. This has almost caused accidents. I was driving in town which is where I do most of my driving.

NHTSA ID

11711810

Incident

Jan 1, 2026

The engine is the component that failed and is available for inspection. The issue has been confirmed by an independent service center, and the repair quote is attached. There were no prior warning signs before the failure; the vehicle suddenly began making a knocking noise and experienced a loss of power.

NHTSA ID

11707617

Incident

Oct 11, 2025

While driving vehicle the vehicle appears to shut off as if someone is turning off the ignition. The steering control becomes stiff, power is lost and electronics flash and turn off and on. This has happened on multiple occasions and is intermittent during acceleration. The accessible grounds have been checked, battery checked and replaced, and alternator checked and verified to be charging appropriately. Several codes are present and have been cleared to return indicating low voltage issues with multiple systems.

NHTSA ID

11699390

Incident

Nov 14, 2025

The car started to have issues shifting when driving- automatic transmission. It would jolt or shudder to try to shift. I was at a light intersection attempting to turn left to go on the on ramp of a highway, it attempted to shift as I sped up from a stop and it got stuck and started making a sound as if you were to press the brake and gas at the same time, similar to that, a car was coming in my direction at the same time and it finally clicked into gear. Absolutely terrified me, my father in law came and switched me vehicles and took mine to the dealership where it stayed for 3 days and they diagnosed it saying it needed a new transmission, quoting us at $11,000. Obviously we can’t afford that. We had all the filters and lines of the transmission cleaned. And now it’s just gotten worse and worse. That was the first time it happened. Now it’ll shudder like that any time it’s switching gears at any speed. Another time since then, it got stuck in the same situation after pulling out of my kids school driveway, it got stuck and wouldn’t click, when it finally did it started shaking uncontrollably in the street and thankfully I live two streets over and made it to my street before it just shut off on its own. I coasted it right into the front of our house and then it would not come back on, at this time we searched the internet over and over to find try to find an easy fix. We let it sit before it came back on. This is our family vehicle. I’ve seen that many many people have this exact issue with this exact same year and model. Its not coincidental and It’s extremely unsafe. Especially with kids in these vehicles. I’m terrified one day when it gets stuck or shuts off we will get hit.

NHTSA ID

11696843

Incident

Apr 17, 2025

Faulty Transmission at 90,000

NHTSA ID

11691609

Incident

Oct 6, 2025

I bought 2016 Yukon XL 9/2020. At 74k miles (2022), the transmission was replaced by warranty. Now (2025), at 126k miles, the transmission needs replaced again. This can’t be normal.

NHTSA ID

11682518

Incident

Aug 14, 2025

The transmission is going out and it started with a shudder. The change for the transmission filter and oil was only a temporary fix. It also shifts hard or there is a delay in the shift.

NHTSA ID

11680537

Incident

Aug 1, 2025

We own a 2016 GMC Yukon XLT Denali with the GM 6.2 engine. On Saturday, July 26, 2025 our vehicle suddenly lost power and became undrivable in traffic. We had it towed to our GM dealership who still has the vehicle (Reiselman GMC- Springfield, TN) They called today and said the engine could not be repaired. They stated it had no compression in Cylinder 8. The said our only option was a new engine. THIS IS THE SECOND CATASTROPHIC FAILURE we have had. In November 2021 we experienced another CATASTROPHIC FAILURE when the vehicle suddenly lost power. The engine required a valve and valve spring and seal on cylinder #1. This is 2 major failures we have had which could have been dangerous had we not been able to get out of traffic. The vehicle currently has 116k miles. These types of major failures in a vehicle that has been serviced according to schedules and receives only typical local and commuter use is out of the norm. It is the first generation of GM's 6.2L engine and the sister engine to the one currently under major recall and no-sell orders. We believe that GM knows of these issues as we have spoken with other people who have had similar problems. The problems involve the valve train and the crank and pistons much like the recall on the later models. Please advise what we need to do to move our complaint through the system to see if we can get some relief on this matter. The dealer still has the vehicle so we don't have any paperwork yet on the latest incident. I will send the November 2021 information

NHTSA ID

11677624

Incident

Jul 26, 2025

Chest clip does not remain clipped. It releases without pressing the release buttons.

NHTSA ID

11676773

Incident

Jul 1, 2025

I have repair the trailer brake system warning light prior. Now again this faulty wiring module is constantly dinging and flashing warning messages while driving. It's very distracting and irrelevant considering I not towing anything. It covers the speedometer and is a complete nuisance.

NHTSA ID

11674962

Incident

Jul 21, 2025

The contact owns a 2016 GMC Yukon XL. The contact stated while driving approximately 70 MPH, the check engine warning light started to flash. The contact stated that the vehicle started to lose motive power. The contact depressed the accelerator pedal, and the vehicle shook violently. The contact pulled off the highway and the vehicle stalled. The contact restarted the vehicle, and the check engine warning light was flashing with DTC: P0300 displayed. The contact stated that the engine was making an abnormal knocking sound. The contact turned off the vehicle and the vehicle towed to the residence and then to a local dealer. The dealer diagnosed the vehicle and determined that a bearing in the cam shaft had failed and had sent metal shavings into the engine. The dealer determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the VIN was not included. The failure mileage was approximately 175,000.

NHTSA ID

11672770

Incident

Jun 23, 2025

Mileage

175,000 mi

The transmission quit working and we were almost in an accident. This is a known issue on the interweb and I think GM needs to step in and help!

NHTSA ID

11672231

Incident

Jul 5, 2025

In June 2024 I took my vehicle to the dealership for a ticking/clacking noise. The dealership determined lifter failure and that the engine needed to be replaced because the lifters/cam were not readily available from the manufacturer due to a known issue with L87 GM motors. Long block was replaced 7/17/24. I believe this should be part of the recall issued against L87 motors and should be extended beyond the 2021-2024 years initially noted.

NHTSA ID

11659061

Incident

Jun 24, 2024

6.2L collapsed lifter on cylnder 5. This os my second engine with the exact same problem as the first engine reason for replacement

NHTSA ID

11651502

Incident

Mar 26, 2025

When accelerating from a stop, the engines revs up to really high RPM's before shifting hard into 2nd gear, and again while shifting hard into 3rd gear. This started in the last week. The engine/trans currently have ~133,000 miles. Accelerating slowly, not exceeding 1,500-1,700 RPM will reduce this occurence, but it takes significantly longer to get up to speed, which is a problem when entering 55 MPH traffic. We've had to pull off the road to avoid causing an accident while merging with traffic since the transmission seems like it won't shift, causing me to have to let off the accelerator to try and allow the transmission to shift so I can continue accelerating.

NHTSA ID

11649607

Incident

Mar 15, 2025

After leaving a car wash on 12/19/22, the engine began sputtering and did not seem to be able to get any gas. After pressing gas pedal, the vehicle slowly moved forward, but was shifting hard. Pulled over in gas station parking lot and turned vehicle off. Checked Engine. Vehicle would not restart. Vehicle was towed to dealership. They uncovered a broken valve spring, which also caused the catalytic converters to fail. Total bill was over $7500

NHTSA ID

11640077

Incident

Dec 19, 2022

Driving a company vehicle [XXX], heavy smoke started coming from under the drivers side dash. Unhooked battery, the smoke stopped. I had vehicle towed to a local garage. They advised the engine wiring harness and other wiring had caught on fire. They couldn't repair it. On [XXX]. I had the vehicle towed to the local GMC dealer in Bedford, VA. At first they said they could fix it, then around 7/3/24 they said the couldn't fix it, charging several hundreds of dollars. On July 5/2024 I had the vehicle towed to a GMC dealership in Lynchburg, VA who I had check with and said they could fix it. The first part of September 2024, this dealership advised me the couldn't fix the vehicle. I had the vehicle tow to our companies office in Lynchburg. The dealerships are saying they can't get the needed wiring harnesses. Our insurance company had sent an adjuster to the GMC in Bedford, VA. No warning lamps came on before the smoke. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11632955

Incident

Mar 28, 2024