2005 GMC Yukon Brakes Problems

The contact owned a 2005 GMC Yukon. The contact stated that while her husband was driving at 80 MPH in an interstate with her in the passenger seat and her two children in the rear seats, the steering wheel seized inadvertently and the brake pedal was depressed but failed to respond. There were no warning lights illuminated. The vehicle veered off to the left side of the road. The contact stated as her husband was trying to regain control of the vehicle, the tires hit the pavement and the vehicle rolled over 7 times in a ditch, within 180 yards and landed on its passenger side. The air bags failed to deploy. The contact and her husband noticed that the children were no longer in the vehicle and they immediately exited the vehicle through the front driver's side window to search for them. The contact stated that her 12 year old daughter who was sitting in the rear passenger side seat of the second row with a seat belt, was ejected through an unknown window and landed in a bush, 80 yards away from where the vehicle had landed. The contact referenced NHTSA Campaign Number: 05V163000 (Seat Belts). The contact's 20 year old son who was sitting in the rear driver seat of the second row with no seat belt, was ejected through an unknown window and landed 50 yards away from where the vehicle had landed. The contact and her family were transported to the hospital with the assistance of emergency units. The contact's son sustained a concussion, swollen knee injury, laceration on the head with 18 staples in the back of his head, 3-4 stiches on his thump and lacerations all over his body. The contact's daughter, who had been airlifted from the first hospital to a second hospital, sustained fractured skull, epidural hematoma, 2 internal brain hemorrhages, an unknown fractured part of the body, 2 dislocated primary teeth , deep laceration on her left hand that required 10 stiches and could lead to permanent nerve damage, deep laceration on her torso that required 8-10 staples. The contact's husband sustained a dislocate

NHTSA ID

11457663

Incident

Aug 24, 2021

Mileage

270,000 mi

TL* THE CONTACT OWNS A 2005 GMC YUKON. THE CONTACT STATED THAT THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD ABNORMALLY WHEN DEPRESSED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEALER (KEYES WOODLAND HILLS BUICK GMC, 6133 TOPANGA CANYON BLVD, LOS ANGELES, CA 91367) WHO INFORMED THE CONTACT THAT A RECALL DID NOT EXIST. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 05V103000 (SERVICE BRAKES), BUT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 127,000.

NHTSA ID

11079567

Incident

Mar 14, 2018

Mileage

127,000 mi

LOST BRAKES COMPLETELY. THE WAS A CATASTROPHIC FAILURE IN THE CLUSTER OF BRAKE LINES IN FRONT OF ABS MODULE DUE TO RUST WHICH LEFT A PUDDLE CONTAINING ALL OF THE BRAKE FLUID ON THE GROUND. LUCKILY THE VEHICLE WAS IN A CHURCH PARKING LOT WHEN IT HAPPENED AND A SUDDEN STOP WAS NOT NEEDED FROM A HIGHER SPEED. THIS COULD HAVE BEEN BAD IF THAT WERE THE CASE. TOO BAD GM DID TO SPEND A FEW EXTRA DOLLARS ON RUST-PROOF BRAKE LINES GIVEN HOW EXPOSED TO THE ELEMENTS THEY ARE.

NHTSA ID

10928632

Incident

Nov 20, 2016

Mileage

116,123 mi

TL* THE CONTACT OWNS A 2005 GMC YUKON. THE CONTACT STATED THAT THE BRAKE PEDAL WENT TO THE FLOOR BOARD ABNORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BRAKE LINES WERE RUSTED AS WELL AS CORRODED PREMATURELY CAUSING THEM TO FRACTURE. THE BRAKE LINES WERE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 62,000.

NHTSA ID

10746528

Incident

Jun 5, 2014

Mileage

62,000 mi

THE 2005 YUKON BRAKE LINES HAVE RUSTED THROUGH, AND WHILE DRIVING OF ALL PLACES TO THE INSPECTION STATION IN UPSTATE NY. WHILE IN THE SHOP FOR REPAIR, IT WAS ADVISED THAT THE ALUMINUM ANTILOCK DISTRIBUTION BOX HAS MAJOR CORROSION AS WELL. IT NEEDS TO BE REPLACED.

NHTSA ID

10736168

Incident

Jul 20, 2015

Mileage

105,400 mi

MY WIFE, WITH THREE CHILDREN IN THE CAR, ATTEMPTED TO STOP AT A STOP SIGN WHILE TRAVELING AT APPROX. 35 MPH AND THE BRAKES COMPLETELY FAILED. AFTER GOING THROUGH ONE ADDITIONAL STOP SIGN AND RED TRAFFIC LIGHT, SHE WAS ABLE TO SAFELY BRING THE CAR TO A STOP ON THE SHOULDER. UPON INVESTIGATION IT WAS FOUND THAT ONE OF THE BRAKE LINES HAD COMPLETELY RUSTED THROUGH AND RUPTURED. WE ARE LUCKY THAT THEY ARE ALIVE. BASED ON THE NUMBER OF SIMILAR COMPLAINTS, AND POTENTIAL SEVERITY OF THIS TYPE OF BRAKE FAILURE THERE SHOULD BE A RECALL OF THESE CLEARLY DEFECTIVE BRAKE LINES.

NHTSA ID

10734492

Incident

Jul 15, 2015

Mileage

110,215 mi

I WAS DRIVING ON A DIVIDED HIGHWAY AND WENT TO SLOW DOWN TO MAKE A LEFT HAND TURN AND THE BRAKES INITIALLY WORKED BUT AT ABOUT 30 MPH THERE WAS A TOTAL FAILURE AND THE PEDAL WENT ALL THE WAY TO THE FLOOR. I HAD TO STAND ON THE PEDAL, SO TO SPEAK, TO GET THE 2005 YUKON TO STOP BEFORE HITTING THE TRAFFIC STOPPED IN FRONT OF ME. I HAD THE TRUCK TOWED HOME AND UPON INSPECTION THE BREAK LINE HAD FAILED RIGHT BELOW THE RADIATOR WHERE IT CONNECTS TO A PLASTIC RETAINER CLIP. I WAS AMAZED AT THE FACT WITH ONLY 118,000 MILES I HAD TOTAL RUST THROUGH ON BRAKE LINES. THIS IS ONE OF THE MOST IMPORTANT PARTS ON A VEHICLE AND WOULD EXPECT THE LINES TO LAST LONGER. I LIVE IN SOUTHERN INDIANA ABOUT 40 MILES FOR CINCINNATI, OH. THIS IS UNBELIEVABLE!! SINCE I REPAIRED THIS FAILURE, THE TRANS LINE AND ANOTHER BRAKE LINE HAVE FAILED DUE TO RUST.!! I HAVE OWNED GM PRODUCTS MY WHOLE LIFE AND HAD A 1998 YUKON WITH 235,000 MI. ON THE TRUCK AND NEVER HAD A PROBLEM WITH RUST THROUGH ON THE LINES. I WISH THERE WAS SOMETHING GM WOULD DO TO HELP FIX THIS PROBLEM. I WORRY EVERY TIME I USE THE TRUCK THAT ANOTHER LINE WOULD BREAK AND CAUSE A MASSIVE ACCIDENT. *TR

NHTSA ID

10667752

Incident

May 14, 2014

Mileage

118,115 mi

WHEN I WENT TO PULL THE YUKON INTO THE DRIVEWAY, THE BRAKE PEDAL WENT TO THE FLOOR AND I BARELY MADE IT INTO THE DRIVEWAY AND STOPPED. I HAD THE VEHICLE TOWED TO THE GM DEALERSHIP. I WAS CALLED WITHIN A COUPLE OF HOURS AND TOLD THAT THE BRAKE LINES HAD BURST AND HAD CORRUPTED ALL OF THE ROTORS AND THE COST WOULD BE OVER $3K TO REPAIR/REPLACE. NOTE: THE ROTORS WERE REPLACED SEP 2013 AND HAD LESS THAN 1K MILEAGE. I CALLED GM CORPORATE TO ASK FOR RELIEF ON 10/6/14 AND WAS TOLD I WOULD RECEIVE A CALL WITHIN 24 HOURS BY A SENIOR ADVISOR. AFTER NOT HEARING BACK, I CALLED ON 10/10/14 AND WAS TOLD THAT THE VEHICLE WAS OUT OF WARRANTY AND THEY COULDN'T DO ANYTHING. I CITIED ALL THE CASES ON LINE ABOUT FAULTY BRAKE LINES AND NHTSA EA11001 AND THE LADY HAD NO KNOWLEDGE OF ANY ISSUES. SHE STATED IT WOULD BE THE RESPONSIBILITY OF THE DEALERSHIP AND NOT GM. SHE STATED SHE WOULD CALL THE DEALERSHIP THE SAME DAY AND TURN IT OVER TO THEM. THERE WAS NOTHING GM WOULD DO TO ASSIST SINCE IT IS OUT OF WARRANTY. PLEASE HELP. WHAT IS THE STATUS OF THE INVESTIGATION? *TR

NHTSA ID

10643914

Incident

Sep 17, 2014

Mileage

116,000 mi

BRAKE LINES FAILED WHILE DRIVING THROUGH PARKING LOT. THE VEHICLE STOPPED JUST SHORT OF COLLIDING WITH OTHER VEHICLES IN THE LOT. ALL LINES INCLUDING TRANSMISSION COOLER LINES AND LINES FROM CALIPERS TO BRAKES NEEDED TO BE REPLACED DUE TO EXCESSIVE CORROSION. UPDATED 4/24/2015 *JS

NHTSA ID

10616935

Incident

Feb 20, 2014

Mileage

146,732 mi

I WAS PULLING UP TO A STOP LIGHT, AND THE BRAKES WENT OUT. I RAN INTO THE TRUCK IN FRONT OF ME WHILE GOING BETWEEN 20 TO 25 MPH. THE AUTO REPAIR SHOP SAID MY BRAKE LINE WAS CORRODED AND IT SNAPPED. *TR

NHTSA ID

10482017

Incident

Oct 17, 2012

Mileage

98,400 mi

WIFE ALMOST HAD ACCIDENT DUE TO SUDDEN BRAKE FAILURE. CORRODED METAL BRAKE LINE RUSTED THROUGH FOR REAR BRAKES. *TR

NHTSA ID

10466515

Incident

Jul 17, 2012

Mileage

74,000 mi

ON MY 2005 GMC YUKON, AFTER ABOUT 6 MONTHS OR SO, DURING BRAKING, THERE WAS A LOUD GRINDING/SLIPPING FEELING, THAT FELT LIKE IT CAME FROM THE FRONT END. AFTER GETTING THE BRAKES CHECKED OUT, I WAS TOLD THEY WERE FINE. TOOK THE VEHICLE TO ANOTHER PLACE, AND THEY DUPLICATED THE SOUND AND CHANGED THE REAR BRAKES. DIDN'T HEAR THE NOISE FOR ABOUT A MONTH, THEN IT CAME BACK. STILL FEELS AND SOUNDS THE SAME. TOOK IT BACK TO THE SHOP. THEY SAID THE FRONT BRAKES WERE FINE BUT I WANTED THEM CHANGED ANYWAY. SO THEY DID. NOISE STILL THERE. ANYONE ELSE WITH THIS ISSUE? THE NOISE AND FEEL OCCUR WHEN SLOWING DOWN TO A STOP OR TURN FROM NORMAL TRAVEL SPEEDS ON HIGHWAY OR ROADWAY. *TR

NHTSA ID

10260012

Incident

Feb 10, 2006