RoadVitals

2025 Grand Design Lineage Owner Complaints

Reports submitted to NHTSA by owners and drivers, shown in full

Data refreshed

Complaints on fileComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
3
+1 complaint in 30 days
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0
Filed in the last 12 monthsReports filed with NHTSA in the trailing 365 days. Recent volume reflects attention and vehicle age as much as anything else.
3
Reports on file since Aug 18, 2025

What this page shows

Our database holds 3 NHTSA owner-reported complaints for the 2025 Grand Design Lineage. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Complaints, most recent first

Showing 1–3 of 3

Body & structureSuspension
Filed Aug 5, 2026

The contact owns a 2025 Ford F-600 SD. The contact stated that while driving at an undisclosed speed, the front of the vehicle raised up and the contact discovered that the vehicle, which had been converted into a motorhome, was improperly weighted, causing excessive weight on the rear axle. The contact stated that there was no clearance between the rear spring pack and the bump stop because the rear of the vehicle was significantly heavier than the front. The contact stated that the rear springs were resting on the frame of the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that additional rear springs needed to be installed to increase the clearance between the springs and the bump stops. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 3,300.

NHTSA ID
11754990
Incident
Aug 5, 2026
Mileage
3,300 mi
Interior & seatsOther / unspecified
Filed Mar 27, 2026

The contact owns a 2025 Grand Design Lineage RV built on a 2024 Mercedes-Benz Sprinter 4500 Chassis. The contact had received notification of NHTSA Campaign Number: 25V473000 (EQUIPMENT, LATCHES/LOCKS/LINKAGES); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool showed no open recall.

NHTSA ID
11727477
Incident
Oct 30, 2025
Fuel system
Filed Aug 18, 2025

On 6/30/25 I originally reported the Safety Issue (Case #11670309). The engine dies while driving. The display indicates "Low Fuel Pressure" and the Check Engine light comes on. The vehicle has been to the Ford Service Center several times for repair. They have validated the issue and have documented the DTS codes. Some components have been replaced or overlaid. My and other's safety has been put at risk. When the engine dies the vehicle has no power steering or power brakes. Pulling over to a safe location is difficult or not available. Most recent event occurred on 8/10/25.

NHTSA ID
11681267
Incident
Aug 10, 2025

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Data sources

Data on this page last refreshed .