2025 Grand Design Lineage Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2025 Grand Design Lineage, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure120.0%
- Fuel system120.0%
- Interior & seats120.0%
- Other / unspecified120.0%
- Suspension120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
The contact owns a 2025 Ford F-600 SD. The contact stated that while driving at an undisclosed speed, the front of the vehicle raised up and the contact discovered that the vehicle, which had been converted into a motorhome, was improperly weighted, causing excessive weight on the rear axle. The contact stated that there was no clearance between the rear spring pack and the bump stop because the rear of the vehicle was significantly heavier than the front. The contact stated that the rear springs were resting on the frame of the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that additional rear springs needed to be installed to increase the clearance between the springs and the bump stops. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 3,300.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
On 6/30/25 I originally reported the Safety Issue (Case #11670309). The engine dies while driving. The display indicates "Low Fuel Pressure" and the Check Engine light comes on. The vehicle has been to the Ford Service Center several times for repair. They have validated the issue and have documented the DTS codes. Some components have been replaced or overlaid. My and other's safety has been put at risk. When the engine dies the vehicle has no power steering or power brakes. Pulling over to a safe location is difficult or not available. Most recent event occurred on 8/10/25.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
The contact owns a 2025 Grand Design Lineage RV built on a 2024 Mercedes-Benz Sprinter 4500 Chassis. The contact had received notification of NHTSA Campaign Number: 25V473000 (EQUIPMENT, LATCHES/LOCKS/LINKAGES); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool showed no open recall.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
The contact owns a 2025 Grand Design Lineage RV built on a 2024 Mercedes-Benz Sprinter 4500 Chassis. The contact had received notification of NHTSA Campaign Number: 25V473000 (EQUIPMENT, LATCHES/LOCKS/LINKAGES); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool showed no open recall.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
The contact owns a 2025 Ford F-600 SD. The contact stated that while driving at an undisclosed speed, the front of the vehicle raised up and the contact discovered that the vehicle, which had been converted into a motorhome, was improperly weighted, causing excessive weight on the rear axle. The contact stated that there was no clearance between the rear spring pack and the bump stop because the rear of the vehicle was significantly heavier than the front. The contact stated that the rear springs were resting on the frame of the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that additional rear springs needed to be installed to increase the clearance between the springs and the bump stops. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 3,300.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .