2012 Harley-Davidson Flstn

PURCHASED MY FIRST BIKE, A 2012 SOFTTAIL DELUXE WITH 4,700 MILES PURCHASED FROM MY COWORKER WHO HAD ONLY PUT 500 MILES ON THE BIKE IN LAST TWO YEARS (SINCE THE 5000K SERVICE WAS DONE @ 4200MI.). TOOK THE BIKE OUT ON A COUNTY ROAD FOR THE FIRST TIME AS A NEW RIDER AND THE BIKE DEVELOPED A HANDLEBAR SHAKE THAT I COULD NOT FIGHT AT 45 MI/HR. THEN WHEN THE BIKE WAS SLOWING THE WHOLE BIKE WOULD WOBBLE. MY FIRST RIDE ENDED UP BEING TO THE LOCAL DEALERSHIP WHERE THEY FOUND THE SPOKES ON THE REAR RIM HAD COME LOOSE AND HAD ELONGATED THE SPOKE HOLES IN THE RIM. MY DEALERSHIP CALLED IT UNSAFE TO RIDE AND URGED ME TO LEAVE THE BIKE. A NEW RIM WAS BACKORDERED, THEN DELAYED TWICE BEFORE I CHANGED THE ORDER TO A MAG REAR WHEEL WHICH I'M STILL WAITING FOR. THE DEALERSHIP WHERE THE PREVIOUS OWNER HAD THE BIKE SERVICED WOULD NOT ACCEPT ANY RESPONSIBILITY. MY DEALERSHIP ACKNOWLEDGES THAT THIS SHOULD NOT BE AN ISSUE AT SUCH LOW MILEAGE. ESTIMATE TO REPLACE THE RIM AND THE BATTERY WAS $1280.00.

NHTSA ID

11031815

Incident

Sep 14, 2017

Mileage

4,700 mi

ABOUT 10:30 PM WHILE EN ROUTE TO WORK I WAS RIDING ON THE FREEWAY AT THE POSTED SPEED LIMIT AND I NOTED FLASHING LIGHTS APPEARING ON THE SPEEDOMETER- THE LOW FUEL LAMP AND ELECTRICAL SYSTEM LAMP. I PULLED OVER THE EMERGENCY LANE RIGHT AWAY TO MAKE ANY ASSESSMENT. I WAS ABLE TO EXIT THE FREEWAY TO SECURE A SAFER ENVIRONMENT FOR ME. THE FLASHING LOW FUEL LAMP AND ELECTRICAL SYSTEM LAMP PERSISTED. I CALLED FOR MY TOWING SERVICE THE FOLLOWING MORNING BECAUSE I DIDN'T THINK IT WOULD BE SAFE TO DRIVE THE MOTORCYCLE HOME. ON 7/1/2014 I CALLED FOR MY TOWING SERVICE TO TRANSPORT MY BIKE TO AN HD DEALERSHIP TO REQUEST A DIAGNOSTIC SERVICE. MY MOTORCYCLE IS IN THE SERVICE DEPARTMENT AS OF TODAY, 7/3/2014. I LOOKED AT MY MOTORCYCLE THIS MORNING AND SPOKE TO THE TECHNICIAN DOING THE SERVICE. I WAS SHOWN A PART THAT NEEDED REPLACEMENT AND WAS TOLD THAT THE PART MAY BE THE CAUSE. THERE IS A DEFECT IN THE WIRING. I AM NOT A MECHANIC OR A MOTORCYCLE TECHNICIAN BUT I NOTED WHAT MAY BE A FACTORY RELATED DEFECT. THIS DEFECT IS SERIOUS IN THAT IT AFFECTED MY SAFETY. I READ THE FOLLOWING AND IT DOES APPLY: "..UNITED STATES CODE... (TITLE 49, CHAPTER 301) DEFINES MOTOR VEHICLE SAFETY ... SAFETY AS THE PERFORMANCE OF A MOTOR VEHICLE OR MOTOR VEHICLE EQUIPMENT....ACCIDENTS OCCURRING BECAUSE OF THE DESIGN, CONSTRUCTION, OR PERFORMANCE OF A MOTOR VEHICLE, AND AGAINST ... RISK OF DEATH OR INJURY IN AN ACCIDENT, AND INCLUDES NONOPERATIONAL SAFETY OF A MOTOR VEHICLE. A DEFECT INCLUDES ANY DEFECT IN PERFORMANCE, CONSTRUCTION, A COMPONENT, OR MATERIAL OF A MOTOR VEHICLE OR MOTOR VEHICLE EQUIPMENT. GENERALLY, A SAFETY DEFECT IS DEFINED AS A PROBLEM THAT EXISTS IN A MOTOR VEHICLE OR ITEM OF MOTOR VEHICLE EQUIPMENT THAT: POSES AN RISK TO MOTOR VEHICLE SAFETY, AND MAY EXIST IN A GROUP OF VEHICLES OF THE SAME DESIGN OR MANUFACTURE, OR ITEMS OF EQUIPMENT OF THE SAME TYPE AND MANUFACTURE." *TR

NHTSA ID

10608186

Incident

Jun 28, 2014

Mileage

7,500 mi

2012 HARLEY DAVIDSON FLSTN WITH ONLY 2,000 MILES. WIRE WHEEL SPOKES WORKED LOOSE. WHEEL WOBBLED. MY HARLEY WAS UNCONTROLLABLE AND NOT SAFE TO RIDE. I HAD THE SPOKES TIGHTENED UP BY THE HARLEY DEALER, BUT AT ABOUT 5,000 MILES SPOKES CAME LOOSE AGAIN. SAME THING HAPPENED AROUND 10,000. MY HARLEY IS NOT SAFE TO RIDE AND THE HARLEY DEALERS ARE NOT WILLING TO RECOGNIZE THE PROBLEM OR FIX OR REPLACE MY WIRE WHEELS . *TR

NHTSA ID

10542570

Incident

Oct 15, 2012

Mileage

2,000 mi

TL* THE CONTACT OWNS A 2012 HARLEY DAVIDSON FLSTN. THE CONTACT STATED THAT WHILE PARKED THE MOTORCYCLE FAILED TO START. IT WAS ABLE TO RESTART AFTER HAVING A JUMP PERFORMED. ALSO, THE MOTORCYCLE WOULD STALL INTERMITTENTLY WHILE RIDING IT. THE MOTORCYCLE WAS TAKEN TO THE DEALER WHO DIAGNOSE THAT THE BODY CONTROL MODULE NEEDED TO BE REPLACED. THE MOTORCYCLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 15,000. UPDATED 09/26/12*LJ

NHTSA ID

10474494

Incident

Aug 4, 2012

Mileage

15,000 mi

TL* THE CONTACT OWNS A 2012 HARLEY DAVIDSON FLSTN. THE CONTACT WAS DRIVING 40 MPH WHEN THE MOTORCYCLE BEGAN TO VIBRATE ABNORMALLY. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING. THE DEALER ADVISED THAT THE REAR WHEEL WAS FAULTY AND NEEDED TO BE REPLACED. THE DEALER REPLACED THE REAR WHEEL BUT THE REPLACEMENT DID NOT REMEDY THE ISSUE. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER WHERE THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE MOTORCYCLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 800. UPDATED 02/15/12*BF

NHTSA ID

10444627

Incident

Nov 9, 2011

Mileage

800 mi

SERVICE BULLETIN M1490 (V 26.0.2): DIGITAL TECHNICIAN II - UPDATES AND RELEASE NOTES. PURPOSE: Revision. This bulletin informs dealers that Harley-Davidson has made a software update to Digital Technician II (DT II). DIGITAL TECHNICIAN II (PART NUMBER: HD-48650). New Software Update Version 26.0.2. Release Date: Week of November 18, 2025. New Features, Changes. 2026 Vehicles, 2025 Softail and LiveWire S2DM/MH/AP EV3. NOTE: Digital Technician II (DT II) supports additional Harley-Davidson motorcycle models and model years outside of those listed.

SERVICE BULLETIN M1391A (REVU): MIDTRONICS GRX-3110 AND DCA-8000 SOFTWARE. PURPORSE: Revision U. The purpose of this bulletin is to inform the dealer network that a software update to the GRX-3110 and DCA-8000 is now available. DYNAMIC DIAGNOSTIC CHARGER SYSTEM (PART NUMBER: DCA-8000). [Rev U] Added: Description of improvements made to the testing algorithm for GRX software Version P and DCA-8000 software Version E.

GENUINE MOTOR PARTS AND ACCESSORIES BULLETIN PAB1171 (REV B): SOFTWARE UPDATE FOR SCREAMIN EAGLE PRO STREET TUNER. PURPOSE: Revision B. Updated: Summary. The App has returned to the Apple App Store. This bulletin informs dealers that a recent software update to the Screamin' Eagle Pro Street Tuner application will require the use of a Personal Computer (PC) to complete a Bluetooth Communication Interface (BCI) firmware update.

SERVICE BULLETIN M1490 (V 25.8.9): DIGITAL TECHNICIAN II - UPDATES AND RELEASE NOTES. PURPOSE: Revision. This bulletin informs dealers that Harley-Davidson has made a software update to Digital Technician II (DT II). DIGITAL TECHNICIAN II (PART NUMBER: HD-48650). New Software Update Version 25.8.9 Release Date: Week of September 2, 2025. Changes: LiveWire 2024 S2MH: Removal of incorrect Electro Hydraulic Control Unit (EHCU) reflash support; EHCU Module (Part No. 41100123): Addressed issue where module became unrecoverable after failed reflash attempted. NOTE: Digital Technician II (DT II) supports additional Harley-Davidson motorcycle models and model years outside of those listed.

SERVICE BULLETIN M1391A (REV T): MIDTRONICS GRX-3110 AND DCA-8000 SOFTWARE. PURPORSE: Revision T. The purpose of this bulletin is to inform the dealer network that a software update to the GRX-3110 and DCA-8000 is now available. DYNAMIC DIAGNOSTIC CHARGER SYSTEM (PART NUMBER: DCA-8000). [Rev T] Updated: New Software Update, Previous Software Updates and DCA-8000. Added: 192-210335P. Software update 192-210335P for GRX-3110 and DCA-800 to add new battery part numbers.

SERVICE BULLETIN M1490 (V 25.8.7): DIGITAL TECHNICIAN II - UPDATES AND RELEASE NOTES. PURPOSE: Revision. This bulletin informs dealers that Harley-Davidson has made a software update to Digital Technician II (DT II). DIGITAL TECHNICIAN II (PART NUMBER: HD-48650). New Software Update Version 25.6.4, Release Date: Week of August 19, 2025. Includes New Features and Changes for the Models & Model Years listed. NOTE: Digital Technician II (DT II) supports additional Harley-Davidson motorcycle models and model years outside of those listed.