RoadVitals

2011 Heartland Cyclone Owner Complaints

Reports submitted to NHTSA by owners and drivers, shown in full

Data refreshed

Complaints on fileComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
4
Latest Oct 11, 2024
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0
Filed in the last 12 monthsReports filed with NHTSA in the trailing 365 days. Recent volume reflects attention and vehicle age as much as anything else.
0
Reports on file since Oct 8, 2012

What this page shows

Our database holds 4 NHTSA owner-reported complaints for the 2011 Heartland Cyclone. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Complaints, most recent first

Showing 1–4 of 4

Body & structureOther / unspecifiedSuspension
Filed Oct 11, 2024

Before a recent trip, I noticed that one of the wheels on my trailer had cracked. I checked the other wheels, and they appeared fine, so I replaced the damaged one at my local Les Schwab. After a four-hour drive, I discovered that three more wheels had cracked. I contacted Les Schwab, and they came out to replace all the wheels and tires. While at camp, I inspected further and found that two of the frame trusses above the axle area were broken. The welds on these trusses were poor, with rust behind them. We had to repair the trusses at camp. After some research, I found this seems to be a common issue with Lippert frames. My wife was so concerned, she refused to ride in the truck while towing the trailer. Now that I was able to get it home without anyone getting injured I'll have to inspect the entire frame.

NHTSA ID
11619324
Incident
Sep 26, 2024
Other / unspecified
Filed Aug 12, 2016

TOWMAX STR ST235/80R16 TIRES. TIRE ON LEFT SIDE REAR OF TRAILER BLOW OUT AT 45-50 MPH ON INTERSTATE I80E COLFAX CA ABOUT 1 HOUR INTO TRIP WITH TOTAL RADIAL SEPARATION CAUSING DAMAGE TO RV BODY AND RIM. TIRES HAVE ABOUT 800 MILES ON THEM SINCE NEW WITH NEW LIKE TREAD AND CHECKED PSI OF 80 PRIOR TO TRIP. SAME INSTANCE HAPPENED ABOUT 1 YEAR PRIOR TO THE RIGHT SIDE REAR TIRE ABOUT 30 MINS INTO TRIP AT ABOUT 55 MPH IN SACRAMENTO I80E AGAIN WITH TOTAL TREAD SEPARATION.

NHTSA ID
10895473
Incident
Aug 9, 2016
Mileage
800 mi
Tires & wheels
Filed Nov 1, 2012

WHILE TRAVELING NORTH FROM SAN ANTONIO, TX TO LANCASTER, PA WITH OUR 2011 HEARTLAND CYCLONE 3950 WE HAD A SEVERE BLOWOUT ON THE DOOR SIDE OF THE FIFTH WHEEL(PASSENGER SIDE OF TRUCK). THIS BLOWOUT CAUSED SIGNIFICANT DAMAGE TO THE REAR SIDE OF THE CYCLONE. THIS FIFTH WHEEL ONLY HAD 200 MILES OF TRAVEL TIME PRIOR TO LEAVING SAN ANTONIO. THIS INCIDENT OCCURRED ON JULY 20, 2012 ABOUT 16 MILES FROM EMPORIA, VA. THE TIRES WERE THE ORIGINAL TIRES THAT WERE MOUNTED ON THE FIFTH WHEEL AT PURCHASE TIME. WE WERE DELAYED FOR AT LEAST 5 DAYS IN EMPORIA AND HAD TO HAVE A MOBILE REPAIRMAN COME OUT TO REMOVE SOME OF THE SHEET METAL SO THAT WE COULD CONTINUE ON OUR TRIP NORTH. WE ALSO HAD ALL SIX TIRES REPLACED BECAUSE OF OUR UNTRUST OF THE POWER KING TOWMASTER TIRES. DURING OUR TRIP NORTH WE STOPPED EVERY 4 HOURS AND AT THAT TIME I CHECKED THE AIR PRESSURE. THE TIRES WERE INFLATED TO 80 PSI SINCE THIS IS A VERY HEAVY FIFTH WHEEL (18,000 LBS GVWR). THESE TIRES SHOULD NOT BE USED ON ANY TYPE OF FIFTH WHEEL. THEY ARE DANGEROUS AND THANK GOODNESS NO ONE WAS INJURED. THERE WAS NO DEBRIS THAT WAS RUN OVER AND IT WAS A MODERATE TEMPERATURE THAT DAY (85 DEGREES). *TR

NHTSA ID
10482885
Incident
Jul 20, 2012
Mileage
1,677 mi
Tires & wheels
Filed Oct 8, 2012

6000 MILES OF NORMAL TRAILER TOWING. NO IMPACT OR OTHER UNUSUAL ACTIVITY. DURING PARKING OF TRAILER, FOUND TIRE WITH BELT DEFORMATION AND RELATED ABNORMAL WEAR ("FLAT SPOT"). TIRE WAS OUT OF ROUND. TIRE REQUIRED REPLACEMENT, REPLACED ALL 6 TIRES DUE TO POSSIBLE/VISIBLE SIMILAR FAILURE. *TR

NHTSA ID
10479302
Incident
Sep 29, 2012
Mileage
6,532 mi

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Data sources

Data on this page last refreshed .