2021 Heartland Cyclone Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2021 Heartland Cyclone, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical133.3%
- Suspension133.3%
- Tires & wheels133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
The contact owns a 2021 Heartland Cyclone. The contact stated that the RV was parked at a campground charging station when the contact noticed there was dark grey smoke coming from inside of the RV under the bar area in the vehicle. The contact unplugged the main power from the vehicle and removed the fireplace station where the smoke was coming from to see that the outlet plugs and outlet box connection were burnt. The contact had a technician at the site inspect the RV and diagnosed the failure as a faulty outlet box and needed to be replaced. The contact was concerned that the failure was caused due to water dripping from the sink next to the outlet box that caused the failure. The RV was not repaired. The manufacturer was made aware of the failure. The failure mileage was unknown.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
The contact owns a 2021 Heartland Cyclone travel trailer. The contact stated that the two axles that support the weight of the trailer were bent. The axles only supported 14,000 pounds however, the trailer weighs 15,320 pounds, which caused the axles to bend. The travel trailer was taken to an independent mechanic and the axles were straightened. The manufacturer was made aware of the failure and informed the contact that they would send out replacement axles. The failure mileage was approximately 3,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
We were driving north on [XXX] from Albuquerque to Aztec, NM driving between 65 and 70 mph. There was no debris in the road and the tire on the passenger rear axle blew out. The tread separation tore up the side skirt and trim. I checked the tire pressure on the other 5 tires and all were inflated to the recommended PSI. Navitrac N116 HD ST235/80R16 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .