2022 Honda Pilot Steering Problems

I am the original owner of a 2023 Honda Pilot with only 17,500 miles. I brought the car to an auto repair facility for its annual New York State inspection. My trusted mechanic discovered that there was a problem with the “rack and Pinion” steering assembly it and could not pass inspection. This problem also ruined the two front tires. He called a local Honda service center to inquire about the problem and check on outstanding recalls. He was told that this was a known problem, but there has not been a recall yet. I have since searched online and found many references to the steering assembly issue in 2023 Hondas. Recalls have been announced for other Honda models. Since there was not a recall yet I had to pay over $4,600 to get this repaired. That is a great deal of money to repair a four year old car with low mileage. I contacted Honda customer service to try to resolve this issue and get reimbursed. I was told since there has not been a recall yet I can’t get reimbursed. Honda is aware of but is not attempting to correct the issue. In particular, since the car could not pass inspection I believe this model is unsafe to drive without these repairs but Honda is not issuing a recall to ensure these vehicles remain safe when on our roads.

NHTSA ID

11774058

Incident

Oct 21, 2026

We purchased a 2022 Honda Pilot Sport brand new. In 2024, it began shaking while slowing down. Hennessy Honda blamed worn tires. We replaced all four by 2025; the shaking briefly improved but returned. Hennessy then diagnosed bad control arms. On [XXX] at approximately 97,000 miles, an independent mechanic instantly identified a broken steering rack. He demonstrated that both front wheels had excessive play and could move independently when manually checked. He warned that this could cause loss of steering control or a catastrophic accident and told us to stop driving immediately. He considered the failure abnormal for the vehicle’s age/mileage and indicative of a defective component. Authorized dealer Ed Voyles Honda confirmed excessive internal play and a clacking noise inside the steering rack. It also identified an axle/half-shaft concern. Repairs are estimated at $5,274.54. Both an independent mechanic and authorized Honda dealer confirmed the problem. The vehicle remains unrepaired to this day. American Honda opened a case and received the diagnostic findings, but no corporate representative has physically inspected the vehicle. Police and insurance representatives have not inspected it because no collision occurred. The first symptom was shaking while decelerating in 2024. Collision-avoidance and driver-assistance sensor warnings began to appear at the beginning of 2026 while the problem was occurring. No warning specifically identified the steering rack before the independent inspection. This unstable steering system severely endangered our family of seven and other motorists, especially at highway speeds. We unknowingly continued driving after two incorrect diagnoses. We have now been without our only vehicle for more than 1.5 months, with no loaner offered. There needs to be a resolution for us and an official public recall for 2022 Honda Pilot steering racks in addition to the recall for 2023-2024 Pilot vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552

NHTSA ID

11773665

Incident

Sep 9, 2026

The steering box has failed twice in under 60000 miles 53601-TG7-A02

NHTSA ID

11759895

Incident

Aug 6, 2026

With about 59,800 miles, a rattling noise under the driver's side of the car began near the end of June, 2026 and gradually became louder, specially on bumpier streets. By the last week of July 2026, the steering started getting erratically stiffer becoming harder to control the direction of the vehicle. A neighborhood mechanic replaced the inner & outer tire rods but this didn't resolve the problem. I brought the vehicle to the dealership, "Honda of Harvey" and was informed that the steering mechanism was failing including the steering RACK and would cost $5,000 to repair. Internet searches revealed that many 2023 Honda Pilots and some 2022 Pilots had been recalled for this same problems. My vehicle wasn't but apparently should have.

NHTSA ID

11758801

Incident

Jun 25, 2026

Bought brand new, I am at almost 68,000 miles. I have had vibration, rattling, etc near the front left of the car. After inspections and diagnostics. They said I need a new steering rack. It seems pre-mature to need a steering rack. No damage or high impact things have happened. Please investigate this issue to see if it could be manufacturing issue. Thank you! I am having it repaired by next week, if you need a receipt please email me at [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11750028

Incident

Aug 1, 2025

2022 Honda Pilot - steering wheel / front of car started to make a clanking noise when driving over speed bumps / noise started around 35k miles on odometer. Two different service appointments with Honda pointed to shocks and sway bar links; 3rd non honda service appointment found the issue to be a failing rack and pinion. 3rd service appointment replaced the rack and pinion / sound is gone and vehicle steers tight once again. mileage was 44k when replaced.

NHTSA ID

11713282

Incident

Feb 11, 2025

The contact owns a 2022 Honda Pilot. The contact stated that while driving and turning in either direction, there was a clicking and squeaking sound coming from the steering column, and the steering wheel was difficult to turn. The vehicle was taken to the local mechanic, who was unable the identify the cause of the failure. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The contact was informed that the vehicle was not included in the extended coverage or recall related to the failure. The failure mileage was 58,900.

NHTSA ID

11691839

Incident

Apr 7, 2025

Mileage

58,900 mi

When you brake and turn the steering wheel to the left it makes a loud clanging noise and the steering wheel shakes. The car feels loose and it does not feel safe to drive. The dealership states it’s the steering rack. It has been happening for 5 months.

NHTSA ID

11626942

Incident

Jun 1, 2024

Vehicle suddenly stop in the middle of traffic no electricity at all wouldn’t start stay cold black out for 5 min . After waiting it power back up on it own after closing the hood

NHTSA ID

11620171

Incident

Oct 13, 2024