Owner-reported complaints naming the engine system, filed with NHTSA
Data refreshed
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components. Every record below is an owner-reported complaint about the 2016 Hyundai Elantra submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 111 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 111, in the owner's own words
Engine burned oil and had knocking sound, despite having regular oil changes. Stalked out while driving took to dealer initial said it was covered by the exerted coverage but ultimately denied. It had 111,000 miles on it. I believe this engine has the same issues as the others.
The oil light & check engine started flashing. Took it to the auto shop. The mechanic stated that the oil level is very low and the engine has a bad lower-end knock. Removed the oil filter and found metal debris in the oil. No oil leaks were found under the vehicle at all. Oil is being burned out through the exhaust. The vehicle needs an the ngine replacement.
Car randomly will not start or will start but have no RPM's. Last year showed a crank shaft sensor code and had it replaced but car is doing it again.
Unknown
So I have a suspicion oh a connecting rod, might be a bearing but it’s making a tik tik noise, no other issue than that, no engine light no nothing, been doing it for a while but car still goes great
I received confirmation from my local Hyundai dealership that my 2016 Hyundai Elantra GT is consuming over 1.8 quarts of oil every 1000 miles. The mileage is currently 70k miles. This is not the result of lack of maintenance or neglect but because of Hyundais engine design. I was told by the local dealership that I would need a total engine re build. This was the only option to fix the issue 100%. I was told that if the issue is not fixed it will result in engine failure. Hyundai is not recalling their engines or acknowledging the inherent danger this will cause. I am at my engines will if I cannot afford this repair because Hyundai won’t honor the Powertrain warranty.
While driving on the freeway at normal highway speed, the vehicle experienced a sudden and catastrophic engine failure. The engine immediately lost power, and the vehicle shut down within seconds. There was no prior warning or opportunity to take corrective action. The vehicle became completely disabled and could not be driven. This occurred late at night with limited traffic, and I was LUCKY to be near a freeway exit. I was able to coast toward the exit, but the engine seized fully, resulting in total loss of propulsion and blocking the freeway exit ramp. Law enforcement had to assist due to the disabled vehicle creating a traffic obstruction and safety hazard. A tow truck was required to remove the vehicle because it could not be restarted or moved. Under normal traffic conditions, this sudden loss of engine power at freeway speed could have resulted in a SERIOUS, potentially FATAL COLLISION. The outcome depended on luck, timing, and location rather than any safety system functioning as intended. The engine was later diagnosed by an authorized Hyundai dealership as seized due to internal failure. Hyundai denied warranty coverage because a software safety campaign had not been completed prior to the failure, even though the failure occurred suddenly and without warning, leaving no opportunity to complete the campaign. However, at the time of the failure, the NHTSA recall lookup tool showed ZERO unrepaired recalls associated with this vehicle’s VIN. The campaign referenced by Hyundai is intended only to detect certain engine conditions and does not repair engine defects. In this case, the engine failed before any detection or warning could occur. The vehicle had just been refueled and was equipped with four brand-new tires, confirming it was being operated normally. This incident involved an unexpected and complete loss of engine power at freeway speed due to an apparent engine defect, presenting a SERIOUS SAFETY RISK to the driver and other motorists.
Engine turns off unexpectedly when driving. all power steering and brakes stop working when engine itself off. entire engine, drive train, and vehicle shakes while driving. Transmission is a replacement as first one failed after 90 days of purchase. paid labor for replacement and waited over 6 weeks without a vehicle. Now replaced oem transmission slips out of gear. making vehicle difficult to drive as the transmission and engine sputter and make ride jerky. car has turned off on the freeway in traffic 3 times. almost causing an accident each time. car has been robbed at least 5 separate times. stealing items within the vehicle. car was locked and next day it is unlocked and my stuff all gone. i am scared to drive the vehicle. i believe it is a lemon.
The coolant system is failing after it was fully replaced in November of 2024 and i got The car of may 2025 with only two previous owners. Coolant system failing after me only have the car for 6 months when the car sat for 5 months.
I own a 2016 Hyundai Elantra, and the engine makes a noticeable knocking or “tapping” noise when started cold. The sound resembles piston slap and usually lessens as the engine warms up, but it’s been gradually getting louder over time. It’s most noticeable for the first few minutes after startup, especially in cooler weather. I’m concerned this may indicate premature piston or cylinder wear. I’ve found many other 2016 Elantra owners reporting the same problem online, suggesting it may be a design or manufacturing issue. The vehicle has been properly maintained with the correct oil grade and regular service, so this shouldn’t be happening at this mileage. This could eventually lead to engine failure or costly repairs if the piston or cylinder surfaces deteriorate further. I’m reporting this so NHTSA can track the issue and determine if it poses a broader reliability or safety concern.
Bought a 2016 Elantra in 2020 with 44,000 miles on it and a clean repair/ maintenance history. Let me preface the rest of this by saying I am an ASE certified mechanic of 15 years who has been in the industry even longer. The first major issues I incurred with the vehicle happened approximately one year after purchase. The lifters started tapping and not long afterwards (about a week) I had a total engine failure on my hands. I was almost killed by a passing semi truck that was merging on to the interstate but was luckily able to avoid it and get the car on the side of the interstate where I had it towed to Ralph Sellers Hyundai in Baton Rouge Louisiana. Long story short , even though the second owner is entitled to a 5 year, 60,000 mile warranty, they made me pay for a new engine. Here we are only 19,000 miles later and the same issue is occurring; except this time due to the stress the failing engine is putting on the torque converter the transmission is now failing to do its job properly. I have been back to the dealership but they offered no help except lies (they told me my high pressure fuel pump was bad, this model doesn't even have one!!!!!) I fully intend to sue Hyundai of America unless some appeasement can be made. Do not EVER buy a hyundai, they are trash cars made to look nicer than they are. Additional details will reflect most recent incident with engine/transmission.
While driving the car will stall regardless of speed or distance. Hyundai dealership states that this is due to a drop in oil pressure due to a faulty oil pump. I replaced this pump 18 months ago on 6/7/2023 with 87K miles. The car is displaying the same issue again on this date (1/14/2025) with 104K miles, and I took it to the Hyundai dealership, and they state that it is experiencing the same oil pump failure. The service department at the dealership stated that this is a known issue with these Hyundai Elantras, and this would be the third replacement of this oil pump. It was replaced once by the original owner under warranty. My contention is that this is a safety issue, because when the oil pressure dips the engine shuts off, and we lose all power to the car. This is a danger to us if this happens while driving the car.
engine noise knocking sound, car hesitates and vibrates, reduced power...all getting worse...I try to avoid driving the car as much as possible.
I am writing to formally request an urgent investigation into a potential recall for my vehicle, a 2016 Hyundai Elantra GT. I purchased this vehicle in 2017 and completed my payments in March 2023. However, in late July, I experienced a catastrophic failure that has rendered my vehicle inoperable. While driving home from work, I suddenly experienced a complete loss of power. My car slowed down significantly, forcing me to pull over to the side of the road. Once I came to a stop, the engine failed to restart, despite the dashboard lights and radio functioning normally. It has now been over two months since my vehicle has been non-operational. After taking it to a certified repair shop for diagnosis, I was informed that the engine is seized. The estimated cost for repairs exceeds $13,000, which is financially unfeasible for me. This situation not only poses a significant financial burden but also raises serious safety concerns. A sudden engine seizure while driving can lead to dangerous situations, potentially endangering both the driver and other road users. Given the severity of this issue and its implications, I urge the NHTSA to investigate the possibility of a recall for engine-related issues affecting the 2016 Hyundai Elantra GT. It is crucial that affected owners receive the necessary support and that safety concerns are addressed promptly. Thank you for your immediate attention to this serious matter. I look forward to your prompt response.
I hear a lot of sounds from the engine of my 2016 Elantra that’s only 96600 miles. It sometimes pulls back even though I step on the gas, and when the car is not moving it shakes a lot, though there is no problem according to my mechanic.
This car is consuming oil to the degree that it is empty 1,000 miles after an oil change. The engine has stalled out on the highway twice, and once on a back road. It will not accelerate properly, and won’t go over 40 mph. I had the catalytic converter replaced less than a year ago, and I am experiencing these issues all over again.
The contact owns a 2016 Hyundai Elantra. The contact stated while driving at an undisclosed speed, the RPM fell to ZERO(0) and the vehicle hesitated while accelerating. The check engine warning light was illuminated. The contact was able to drive to the destination. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.
I was driving down the interstate when my car completely locked up, my brakes stopped working, the steering wheel wouldn't turn, the car completely shut down, so I had to make my way off the bisy interstate luckily I didn't have an accident so I took it to a mechanic and found out the alternator went out, so it was replaced then less than a year later i had issues with the headlights not working then magically comong on while driving, and the interior lighta will work then bot work but the bulbs are new, leading to another replacement alternator, then less than about 8 months pass and I have issues with the electrical stuff again not wanting to work even when new bulbs are pit in the car, the radio turning on and off by itself and I've had to put it a third alternator in less than 3 years, it's a driving hazard and safety hazard. My driver side door handle will only open from the inside and it doesn't shut inkess the door is locked and the car has to be turned on. The belt in my 2016 hyundai elanyra looks like it's shredding and it's throwing black stuff on the inside of my hood. I've had preoffwsional mechanics look at it and the alternator is assembled correctly, and now my ball joints are all of a sudden needing to be replaced inthe front.
The contact owns a 2016 Hyundai Elantra. The contact received notification of NHTSA Campaign Number: 24V146000 (Latches/Locks/Linkages) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure related to the recall campaign; however, the check engine warning light illuminated. The vehicle was not diagnosed or repaired. The failure mileage was unknown. Parts distribution disconnect.
Took car for a couple of recalls was working fine, then after the recall it did not want to accelerate or work. Called dealership that did it and they refused to fix that.
The contact daughter owns a 2016 Hyundai Elantra. The contact stated that while her daughter was driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was able to restart after 5 minutes. The vehicle was towed to the dealer where is it was diagnosed with engine failure, and that the catalytic converter failed due to oil entering from the engine. The contact was informed that the engine and catalytic converter and engine needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 80,000. The VIN was not available.
*4th report to NHTSA* Trouble getting response from HMA case manager. Delaying/not responding to multiple emails/calls/contact forms. Please advise. 1. What component or system failed or malfunctioned, and is it available for inspection upon request? - Multiple systems continuing to fail/malfunction. Multiple attempts to repair at Hyundai dealerships. Vehicle is currently at the dealer service center where it was originally purchased on [XXX] (Dealer number P113588 , Ron Carter Hyundai) now Big Star Hyundai. Yes - PLEASE conduct VIN inspection on this vehicle. I am waiting to hear back from dealer & HMA case manager to confirm vehicle specifications relating to VIN in their system and full engine inspection results. 2. How was your safety or the safety of others put at risk? - First reported and diagnostics completed by dealer [XXX]. Problems with engine have continued and escalated to current. Latest safety risk event occurred [XXX] while driving on high traffic freeway in Houston, TX with child passenger. Vehicle lost ability to control speed/driving power suddenly stopped/failed resulting in tow to dealership. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? - Yes. Included notes in attached reports from previous dealer visits. Symptoms, reporting & attempts to repair started within warranty window. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? - Previous inspection reports attached. 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? - CEL was on and off at the start of symptoms Dec. 2021. Dealer replaced MAP sensors and the issues continued without warning lamps. Dealer stated they could not diagnose anything without warning lamps. Dealer reported unknown diagnosis and closed case. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I just know that my vehicle has a high use of engine oil. I took it to the dealer about a year and half ago to have it checked but they said that was normal but the more I read up on this it sounds like it is not normal. Also the clear over spray paint on all 4 door handles has come off and the rear hatch top window spoiler has completely peeled off also.
Bought the car a yr ago and transmission started slipping and stalling sometimes even engine shutting off while driving at higher speeds unable to steer and when pulling into traffic is on interstate almost got hit because I could not speed up it's also using double the fuel while driving longer distances I tried to use my warranty 2x before my warranty was up but both neither time did Hyundai in Owensboro check what I booked the appt for. First one was booked to check transmission and power issue then called the day before and added oil change. When I arrived the tech retyped my order and changed the oil. Brought my keys I asked about the power/transmission issues and was told they didn't know to check that but at that point there was no time and had to reschedule... So I did. Waited almost 2 months booked appt for transmission / power issue and also check the fuel usage. Finish the service call quoting me over $1300 to fix the fuel issue because no one could find my warranty eventhough I had my original paperwork showing who warranty was with and also the acct number for the warranty. When I asked about transmission or power issue I was told there was no one to check that and I had to rebook but this time it was going to be 8 weeks and by then my warranty had expired. I feel like Hyundai did this on purpose because they are in cahoots with the lot I bought the car from. Now my car is getting worse and worse and scared to even drive the car im overpaying for. This was my first Hyundai and more than likely will forever be my last because the car I got was a lemon it seems, the customer service was worthless and the service even worse. I'm reporting to BBB and everywhere I can.
Initial report on March 7, 2022 (approx. 94K miles), second report on Dec. 12, 2023 (approx. 111,700 miles). Third report March 27, 2024: Recent event occurred on March 23, 2024 (approx. 112K miles) when my vehicle suddenly stopped moving while driving 55mph on a freeway with child passenger in the vehicle, putting both of us at risk for collision. Vehicle did not have any warning lights turn on prior to or during event. The vehicle did not move again after multiple attempts to accelerate to exit freeway safely. After shifting to neutral and back to drive, the vehicle suddenly jolted and accelerated randomly while holding foot on the gas pedal (no control over timing of acceleration). We were able to exit the freeway safely. This same issue repeated multiple times while driving us to a safe area to call for a tow truck. The vehicle was towed to dealership location it was originally purchased at on March 26, 2024. Diagnostics appointment scheduled for March 28, 2024. I have completed oil change services on this car about every 1,200 miles to keep the engine running since there was no solution for any of my previous reports to dealership (even when opening a case with Hyundai), their previous determination was to close case since the diagnostics report did not show error codes in report. Previous dealership advisor made a verbal comment that the real problem is something their computers do not scan codes for, and his recommendation was to "drive it til the wheels fall off" after paying thousands in services that did not solve the root problem. Hoping this appointment will lead to a safer outcome.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .