2016 Hyundai Equus

The contact owns a 2016 Hyundai Equus. The contact stated that while driving at an undisclosed speed, the headlights and both turn signals became inoperable and failed to illuminate. The vehicle was taken to the dealer where the vehicle was not diagnosed or repaired. The contact was informed that the failure could not be duplicated. The contact further stated that the failure persisted after the vehicle was returned from the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 66,000.

NHTSA ID

11740882

Incident

May 29, 2026

Mileage

66,000 mi

Suspension air Block and airbags failing, even after being replaced by dealership 2 months ago. Most recently happened on the interstate at 70 mph. Fixed by dealership only to happen again!! Known problem by Hyundai dealership yet keep replacing with same defective part number. Twice have had new parts fail during test drive. Very expensive to repair $10,000 so far and just had the rear airbag go burst. Not safe to drive vehicle!! Never know when it will go out again. Last one just lasted two months!! Will never get money back from selling the car! Just want a safe vehicle and Hyundai needs to provide parts that work and are not a safety hazard!!

NHTSA ID

11622368

Incident

Jun 15, 2024

There are actually 3 problems that my dealer has not been able to fix/diagnose. The first is the headlights, when set to the auto position, they will often turn off and on while driving at night. Service says that they were unable to duplicate the problem, but it keeps happening. The second is the Navigation system updates, that they claim they cannot provide any updates to my 2016 Equus (just about all other years and models are available). The third is the voice recognition system, which only recognizes my voice for phone calls, but not for directions. The dealer (Gettel Hyundai of Sarasota FL) had my vehicle for two weeks and was not able to fix any of these problems, although they charged me over $500 for diagnostics. If I look at the Hyundai Owners Forum, I see these problems documented over and over and I provided the dealership with that information to no avail. I also notified the BBB of my problems, (case# [XXX]), but they are not returning my calls to them in order to update them on my lack of resolutions to my problems. What if anything can I do to pursue this ? I have copied in the CEO of Hyundai USA (J. Munoz) and after initially designating someone under him to get involved, has since been unresponsive (since October 6th, 2023). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11554007

Incident

Apr 15, 2023

TL* THE CONTACT OWNS A 2016 HYUNDAI EQUUS. THE CONTACT STATED THAT THE POWDER COATING FROM EACH WHEEL DETACHED AND LODGED BETWEEN THE BRAKE PADS AND ROTORS CAUSING THE BRAKING SYSTEM TO MALFUNCTION AND THE BRAKING DISTANCE TO BE EXTENDED. THE FAILURE OCCURRED TO ALL FOUR WHEELS. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER - BRANDON HYUNDAI LOCATED AT 9915 E ADAMO DR, TAMPA, FL 33619, WHERE THE DEBRIS WAS REMOVED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED BY A POWDER COATING EXPERT THAT THE CAUSE OF THE FAILURE WAS DUE TO A FAULTY POWDER COATING APPLICATION PROCESS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100.

NHTSA ID

11375273

Incident

Sep 1, 2018

Mileage

100 mi

DRIVING AT 75 MPH AND WENT TO PASS SOMEONE. THE ENGINE KICKED DOWN A FEW YEARS AND THE ENTIRE CAR SHUT OFF. NO POWER BRAKES AND NO STEERING AND STEERING LOCKED UP FOR ABOUT A SECOND OR TWO. DURING THE TIME IT WAS OFF THE VEHICLE JERKED HARD LIKE IF THE TIRES HAD LOCKED UP. AFTER THE COUPLE SECONDS THE VEHICLE TURNED BACK ON AND EVERYTHING WAS NORMAL AND NO CHECK ENGINE LIGHTS OR ANYTHING TO INDICATE A PROBLEM I WAS DRIVING ON THE I-80 HEADING TO RENO

NHTSA ID

11363292

Incident

Oct 7, 2020

Mileage

48,200 mi

VEHICLE PRODUCES EXCESSIVE EXHAUST SOOT AT ALL TIMES. THE SOOT ADHERES TO THE REAR TAIL PIPE, REAR BUMPER, AND TRUNK LID CAUSING STAINING THAT LEADS TO PITTING OF CHROME PIECES. THE SOOT IS DIFFICULT TO REMOVE AFTER A FEW DAYS AND REQUIRES CONSTANT CLEANING. THIS COULD ADVERSELY AFFECT THE AIR QUALITY AND DAMAGE OR STAIN OTHER VEHICLES AND PROPERTY NEAR THE REAR OF THE VEHICLE, INCLUDING WALLS AND OTHER PARKED VEHICLES. EFFECTS ON LUNGS SHOULD BE STUDIED TO DETERMINE IF PERMANENT DAMAGE COULD RESULT FROM ACCUMULATION OF SOOT. ENOUGH SMALL PARTICULATE MATTER IS EMITTED TO HEAVILY STAIN REAR AREAS OF VEHICLE IN LESS THAN 1 WEEK. VEHICLE EMISSIONS CONTROL SYSTEMS COULD ALSO BE ADVERSELY AFFECT, CAUSING PREMATURE FAILURE OF O2 SENSORS OR CATALYSTS. TOUCHING THE REAR OF THE VEHICLE AFTER 1 WEEK FOLLOWING A DETAILING LEFT HEAVY, BLACK STRAINS SIMILAR TO THOSE FOUND AFTER MULTIPLE MONTHS OF SEMI-METALIC BRAKE DUST ACCUMULATION. EFFECTS COULD BE SEEN AFTER CITY DRIVING AND HIGHWAY DRIVING. SOME SOOT FORMATION CAN BE SEEN AFTER PROLONGED IDLE.

NHTSA ID

11291674

Incident

Dec 17, 2019

Mileage

36,000 mi

2016 HYUNDAI EQUUS - BLACK SOOT BEING EMITTED FROM ENGINE THROUGH EXHAUST SYSTEM. VERY HEAVY DEPOSITS ON REAR OF VEHICLE, SUFFICIENT TO BLACKEN CLOTHES, DISCOLOR THE VEHICLE, DOES NOT WIPE OFF AFTER A FEW DAYS AND CHEMICALS MUST BE USED TO REMOVE. MANUFACTURER SAYS: "THIS IS A NORMAL BYPRODUCT OF THE GDI ENGINE". SEE (PICS) MULTIPLYING THE NUMBER OF HYUNDAI VEHICLES IN THE U.S. BY WHAT I AM SEEING ON MY CAR, THIS COULD BE A SERIOUS AIR POLLUTION ISSUE.

NHTSA ID

11289370

Incident

Nov 21, 2019

Mileage

28,000 mi

2016 HYUNDAI EQUUS WITH CONTINENTAL CONTIPROCONTACT P245 / 45R / 19 98V TIRES; DOT AF7VP1H6 (0615); WHILE DRIVING MY DAUGHTER AND GRANDCHILD TO THE AIRPORT ON THE FLORIDA TURNPIKE THE STEERING WHEEL BEGAN TO VIBRATE. UPON RETURNING HOME, CALLED CAR DEALER AND SCHEDULED A SERVICE APPOINTMENT THE NEXT DAY. WE BOTH THOUGHT A FRONT TIRE HAD POSSIBLY THROWN A WHEEL BALANCING WEIGHT. DEALER FOUND BOTH FRONT TIRES HAD BELT SEPARATION CAUSING STEERING WHEEL TO VIBRATE. THE CAR AND TIRES WERE PURCHASED NEW AT THE DEALER AT THE END OF 2016, ARE ONLY 22 MONTHS OLD AND HAVE ONLY 19,700 MILES. WE HAVE NOT HIT ANY CURBS, ROUGH RAILROAD TRACKS OR LARGE POT-HOLES AND IT IS SUSPICIOUS THAT IT WAS BOTH FRONT TIRES. THE TIRE MANUFACTURER WAS CONTACTED BY THE DEALER, REFUSED TO ACKNOWLEDGE A LIKELY MANUFACTURING DEFECT AND OFFERED ONLY 50% OF THE TIRE REPLACEMENT COSTS AND THEY WANTED THE DEFECTIVE TIRES. I WAS ABLE TO PURCHASE OTHER NEW TIRES FOR LESS COST THAN WHAT THE MANUFACTURER OFFERED. I HAVE THE DEFECTIVE TIRES IN MY POSSESSION AND PLAN TO RUN ROOT-CAUSE FAILURE ANALYSIS ON THE TIRES SUSPECTING THAT IT IS A MANUFACTURING DEFECT WITH THE RUBBER USED CAUSING THE BELTS TO PREMATURELY SEPARATE FROM THE TIRE COMPOUND. I NOTED OTHER SIMILAR BELT SEPARATION FAILURES ON THE NHTSA WEBSITE LISTED UNDER THE TIRE MANUFACTURER, BRAND AND EVEN CAR BRAND. WILL ALSO BE CONTACTING THE CAR MAKER AND TIRE MANUFACTURER TO REGISTER A COMPLAINT OF A DEFECTIVE PRODUCT.

NHTSA ID

11111896

Incident

Jul 10, 2018

Mileage

19,700 mi

The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or non‑certified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious injuries and fatalities. Please see attached announcement, provided by NHTSA, for more details.

The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts. These dangerous inflators have ruptured during deployment, posing a serious risk of injury or death due to metal fragments entering the vehicle cabin. To date, Hyundai is aware of three people who have died while driving a Hyundai vehicle with one of these substandard replacement airbag inflators that deployed in what likely would have been a survivable crash. NHTSA has issued a public advisory urging vehicle owners and service professionals to have vehicles inspected if there is reason to believe that a non-genuine replacement airbag may have been installed. Vehicles with salvage or rebuilt titles, prior airbag deployments, or unknown repair histories may present a higher risk. NHTSA strongly cautions against self-inspection by vehicle owners and recommends inspection by trained technicians.

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.

This TSB provides a procedure to diagnose and replace, if necessary, an automatic transmission with Incorrect Ratio DTC (transmission clutch slip in gear above limit) listed on Page 2.

This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side of the wiper blade, which could lead to poor wiping performance and/or possible scratching of the windshield glass. Follow the procedure in this bulletin to properly remove the windshield wiper blade protective cover on all new wiper blades.

This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.