2021 Hyundai Ioniq Hybrid

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

The contact owns a 2021 Hyundai Ioniq Hybrid. The contact stated that upon depressing the accelerator pedal, there was an abnormal ratting sound coming from the vehicle, and the vehicle failed to accelerate as needed. The contact stated that the check engine and oil warning lights were illuminated on the instrument panel. The vehicle was taken to a dealer where the vehicle was diagnosed with connecting rod bearing failure. The contact was then provided an estimate for an engine replacement. The manufacturer was also notified of the failure and the contact was provided a case number. The vehicle remained in the possession of the dealer and was not yet repaired. The failure mileage was 73,020.

NHTSA ID

11659724

Incident

May 1, 2025

Mileage

73,020 mi

Auto brake fault has been a constant issue with this 2021 Hyundai Ioniq Hybrid. This causes lots of system functions to stop working (adaptive crusice control, lane keeping assistant, etc.) The dealer originally replaced the wiring harness, but it came back again and again with the same issue. They finally figured out that replacing the rear calipers seemed to make it stop. They have done that twice and this past weekend the fault warning appeared again. So, for the 4th time, we will be taking the car back in so this error goes away. For additional details, I will give you the most recent time, but note that the other 3 times all happened with in the first 1-3 years of ownership.

NHTSA ID

11618338

Incident

Oct 4, 2024

On a recurring basis, the warning lights come on for”AUTO HOLD” and “EPB” or emergency parking brake. Car continually beeps and gives warning until car is reset. During this time, the cruise control will turn off, causing safety issues during travel. Also, the other safety features seem to stop working during the time this warning is activated. Emergency stop, et cetera. Only activated when vehicle is operating under highway mph. Typically local roads with stops/starts trigger this issue. Mechanics have no idea what is wrong with vehicle warning. I see online that this is a common issues with Hyundai Ioniq. A possible recall is needed to investigate/fix this issue as local dealerships arent aware of a solution.

NHTSA ID

11588365

Incident

May 13, 2024

The contact owns a 2021 Hyundai Ioniq Hybrid. The contact stated that while driving at various highway speeds, the electronic parking brake and auto hold indicator lights erroneously activated. The cause of the failure was not yet determined. The local dealer was notified of the failure, but no assistance was offered. The manufacturer was not yet contacted. The VIN was not available. The failure mileage was 16,000.

NHTSA ID

11541595

Incident

Jan 15, 2023

Mileage

16,000 mi

I’m driving with cruise control on the highway at 65 and all of a sudden it shuts off. The check cruise system light comes on along with a triangle with an exclamation point in the middle of it in the lower left side of dashboard and the letters EPB lights up on the lower right side of dashboard.

NHTSA ID

11536725

Incident

Jul 24, 2023

The contact owns a 2021 Hyundai Ioniq Hybrid. The contact stated while driving at an undisclosed speed, the electronic parking brake warning light, the auto-hold feature warning light, and other unknown warning lights were illuminated. The contact veered to the side of the road. The contact turned off and restarted the vehicle; however, the failure persisted. The contact was able to continue driving. The vehicle was taken to the local dealer where it was diagnosed that the brake caliper had failed and needed to be replaced; however, parts were not available. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 19,000.

NHTSA ID

11484263

Incident

Aug 1, 2022

Mileage

19,000 mi

The backup mirror remained on while driving down the road.

NHTSA ID

11480586

Incident

Jun 15, 2022

The Apple car play system quits when you are using maps.

NHTSA ID

11480584

Incident

Aug 8, 2022

The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or non‑certified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious injuries and fatalities. Please see attached announcement, provided by NHTSA, for more details.

The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts. These dangerous inflators have ruptured during deployment, posing a serious risk of injury or death due to metal fragments entering the vehicle cabin. To date, Hyundai is aware of three people who have died while driving a Hyundai vehicle with one of these substandard replacement airbag inflators that deployed in what likely would have been a survivable crash. NHTSA has issued a public advisory urging vehicle owners and service professionals to have vehicles inspected if there is reason to believe that a non-genuine replacement airbag may have been installed. Vehicles with salvage or rebuilt titles, prior airbag deployments, or unknown repair histories may present a higher risk. NHTSA strongly cautions against self-inspection by vehicle owners and recommends inspection by trained technicians.

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.

This bulletin provides information related to the changes introduced in the 2025 1st Navigation Map and Software Update. The changes may vary depending on vehicle type, model, and navigation system as described in this TSB.

This bulletin provides information related to the changes introduced in the 2024 2nd Navigation Map and Software Update. The changes may vary depending on vehicle type, model, and navigation system. Refer to the 2024 2nd Navigation Map and Software Update Improvements section in this TSB for a list of specific changes. The software can be downloaded via Navigation Updater (NAU) and updated by USB. The NAU website is https://update.hyundai.com/US/EN/navigationUpdate. For certain models equipped with a relevant Bluelink package, the software may be downloaded and applied via OTA update.

Some vehicles may exhibit a loss of connectivity or interruptions in the middle of using Bluelink Service functions. This may be due to an irregular disconnection on Verizon’s communication network. Follow the procedure in this TSB to reestablish the connection via the AVN pinhole reset method.