2025 Hyundai Santa Fe Driver assistance Problems

I am submitting a second and more urgent safety complaint regarding the Driver Monitoring and Driver Assistance systems in my vehicle. I previously reported this same core defect: the system falsely fails to recognize my face, sounds repeated warnings, and disables driving assistance while the vehicle is moving. Despite that prior complaint, the defect remains, and the seriousness of the danger has clearly not been recognized or addressed. This defect has now placed my life in immediate danger. While I was driving, the system falsely determined that it could not properly see my face. It sounded repeated warnings and then abruptly disabled driving assistance. That sudden withdrawal of assistance created a near-crash situation. I was attentive and was not experiencing a medical emergency. The danger was created by the system’s false detection and defective response. A safety system should reduce danger. This system detected a supposed problem and made the situation more dangerous by removing the assistance that was helping keep the vehicle under control. Had this occurred beside a concrete barrier, near stopped traffic, in a construction zone, on a curve, or next to a large truck, the result could have been a fatal collision. I could have been killed because of this system defect. When a driver cannot be verified, the vehicle should maintain lane control, reduce speed, activate hazard warnings, and perform a controlled safe stop. It should never abruptly withdraw assistance and create a more dangerous condition. I request that NHTSA investigate why a previously reported life-threatening defect remains unresolved and require Hyundai to correct this system logic before someone is seriously injured or killed.

NHTSA ID

11751090

Incident

Jul 17, 2026

The contact owns a 2025 Hyundai Santa Fe. The contact received notifications of NHTSA Campaign Numbers: 25V808000 (BACK OVER PREVENTION) and 26V218000 (SEAT BELTS). The vehicle was taken to the local dealer on several occasions, and the contact was informed that the parts were not yet available for the recall repair. The vehicle was not repaired. The manufacturer was notified of the issue, but no assistance was provided. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

NHTSA ID

11742243

Incident

Jun 5, 2026

I own a 2025 Hyundai Santa Fe that was purchased on 08/15/2025. The first malfunction occurred on 08/25/2025, only days after purchase, and the vehicle has experienced repeated safety-related issues since then. The vehicle has repeatedly displayed false Forward Collision Warning alerts, Blind Spot Warning failures, Park/Neutral errors, and intermittent disabling of safety features. The most serious incident occurred when the vehicle unexpectedly entered “Limit 20 MPH” mode while I was pulling into active traffic with my toddler in the vehicle, limiting acceleration and creating a safety risk. I have also experienced false collision alerts while parked and after the vehicle was shut off. The vehicle has been taken to the dealership multiple times for diagnosis and repair attempts. Some issues were duplicated by dealership personnel, while other visits were documented as “could not duplicate.” A front ultrasonic sensor was replaced, but the vehicle continued experiencing safety-related concerns afterward. During the repair process, I was informed and observed that dealership personnel appeared limited in what repair actions could be taken after consulting Hyundai through their diagnostic system. I was also informed that Hyundai influenced what could be included on service reports and that dealership personnel were instructed to “print the book” rather than fully document observed concerns. I believe this may have affected repair efforts and documentation of ongoing issues. The vehicle has been out of service for extended periods and the issues continue despite repeated repair attempts. Due to the ongoing malfunctions and inconsistent operation of the safety systems, I no longer feel safe driving the vehicle because I am concerned it may not function properly during a real emergency situation. Attached are photos of various dashboard errors and warning messages that occurred during these incidents to document the alerts and malfunctions experienced.

NHTSA ID

11740141

Incident

Aug 25, 2025

On April 27, 2026, my 2025 Hyundai Santa Fe experienced an intermittent electrical/system malfunction affecting multiple vehicle systems at the same time. Multiple orange warning lights/messages appeared on the dash, including driver-assistance warnings and the master warning triangle. At the same time, the front turn signal stopped working, causing rapid flashing; the power locks stopped working; the windows would not roll up or down; and the rear liftgate would not open using the key fob or exterior liftgate button. The vehicle/component is available for inspection upon request. This created a safety and access issue. The malfunction affected exterior signaling, locks, windows, and rear cargo access. My dog was in a crate in the rear cargo area, and I could not open the liftgate normally to access him. The failure of locks/windows/liftgate could create a serious emergency risk if a person, pet, or cargo needed to be accessed quickly, and the turn signal failure affected my ability to safely signal to other drivers. The issue lasted approximately 30–40 minutes and did not immediately clear after turning the vehicle off and back on. It later returned to normal on its own. This has happened more than once. The vehicle was taken to a Hyundai dealership for inspection. The dealer has been working with Hyundai Techline, but as of now they have not been able to reproduce the issue or find active diagnostic codes. I provided video evidence of the dash warnings from the incident. The dealer advised that scans currently show systems operating as designed because the issue is intermittent and not occurring during inspection. There were no prior symptoms before the failure. The warning lamps and messages appeared at the time the malfunction occurred. Seek reimbursement for rental car fees and diagnostic fee.

NHTSA ID

11734834

Incident

Apr 27, 2026

The contact owns a 2025 Hyundai Santa Fe. The contact stated that while driving at slow speeds, the vehicle independently accelerated while the accelerator pedal was only lightly depressed. There were no warning lights illuminated. The vehicle was taken to a dealer, where the pedal sensor was adjusted. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer; however, the failure could not be duplicated. The vehicle was not diagnosed or repaired. The contact stated that the vehicle was unsafe to drive. The manufacturer was made aware of the failure. The failure mileage was approximately 17,000.

NHTSA ID

11733094

Incident

Apr 22, 2026

Mileage

17,000 mi

The vehicle has two display panels, molded into a single frame. There is an infotainment panel on the right that handles music, maps, and phone interaction. There is an instrument panel on the left. The infotainment panel has not issues. The instrument panel blanks out for 3 - 5 seconds every few minutes, and then reappears. Occasionally the words "No SIgnal" in big red letters will appear. Occasionally the gear selection letter will remain on the otherwise blank screen. The screen also shudders / tears occasionally before blanking. It does this whether the vehicle is moving or parked. I purchased the vehicle used, Jan 2 2026. I noticed the problem a couple of days later. It has continued. It is not getting any worse or any better.

NHTSA ID

11733014

Incident

Jan 5, 2026

Since I bought the car the forward attention warning goes off constantly. I’ve taken it to the dealership multiple times. They took off my eztag, stated it was blocking my camera. This is not the issue. Now there are 56 cars ahead of mine. This will be the 3rd time for the exact same complaint. It affects everything in the car. My cruise control doesn’t work because of this issue. If you turn the toggle back on it has more warning. Just the beeping constantly is going to cause an accident. I’ve asked Hyundai to buy it back they refuse. This is a known issue.

NHTSA ID

11732200

Incident

Aug 6, 2025

While I was driving on the highway, a diagnostic trouble code (DTC) related to the blind-spot safety system appeared.

NHTSA ID

11730986

Incident

Apr 3, 2026

Dear NHTSA Team, My car was in a minor accident Last. After that, the repair shop replaced my bumper and front camera. Don Franklin Somerset Hyundai performed a calibration on my new radar. They calibrated it six times, but there are still many issues with the HDA driving system. 1. False Dual-Side Warning When a vehicle is present only on the right side, the vehicle camera system incorrectly detects vehicles on both the left and right sides. In reality, there is no vehicle on the left side. In this scenario, both the radar warning and the camera detection are incorrect. 2. Wrong-Side Warning In some cases, when a vehicle approaches from the left rear, no warning is issued on the left side, while a warning is incorrectly displayed on the right side. In this scenario, both the radar warning and the camera detection are incorrect. 3. False Warning During Smart Driving While driving on the highway using the smart driving function, when the vehicle is required to turn left or right, the system may generate a false dual-side warning. As a result, the vehicle aborts the intended left or right turn and continues driving in the center of the lane. In this scenario, both the radar warning and the camera detection are incorrect. 4. while driving manually (without HDA engaged) or parking, the vehicle shows left-side or right-side collision warnings without clear cause. I reported these issues to Hyundai USA approximately three weeks ago. I was instructed to bring the vehicle to the dealership for inspection. However, during my recent visit, the dealership representative only reviewed the videos I provided and concluded that no issues were present, without conducting a physical inspection or test drive of the vehicle. Given the ongoing safety concerns and lack of proper diagnosis or resolution, I am submitting this complaint for your review and assistance. Thank you for your attention to this matter. Thanks, Best Regards, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5

NHTSA ID

11725223

Incident

Jan 15, 2026

Forward Facing Driver Assist cabin camera will shut off the cruise while you are driving if it cannot detect your eyes. This is NOT a safety feature but rather an extremely dangerous safety hazard!!! While you are traveling at 70+ mph and put on sunglasses and all of a sudden the car starts alarming and decelerates without warning causing the driver to become EXTREMELY distracted trying to figure out what is going on is a recipe for a major incident. There is no way to shut the camera off so you are then forced to either drive with no cruise at all so you can wear sunglasses and for long trips creates added and unnecessary driver fatigue OR you forego wearing sunglasses and squinting causing unnecessary eye strain/fatigue so you can use the cruise. Please explain to me how this is a safety feature? Also the warning that 'you might need to take a break' is also NOT a safety feature and also creates driver distraction rather than safety and should just totally be removed from the vehicle software completely. We have literally driven the car over the center line on the rumble strips without a signal and then back into our lane again the warning does NOT go off, we've jerked the wheel to avoid an object in the road warning does NOT go off, BUT if you happen to drive to close to the center line but don't go over it then the warning DOES go off.....if we just left the house turned out of the driveway, the damn thing goes off. There is no making sense of when or why it goes off, it's completely random. And again, no option to turn it off. Had the dealership given COMPLETE details of these 2 specific "SAFETY" features - I use that term EXTEREMLY loosely - sharing they could NOT be turned off I never, EVER would have bought this vehicle. I am not alone in my complaints, I have seen hundreds of similar complaints on forums for Hyundai vehicles that have this feature. PLEASE PLEASE issue a directive to Hyundai that they need to push a fix allowing shut off of these 2 features

NHTSA ID

11721750

Incident

Jul 15, 2025

All normal sounds completely stop working, no audio or volume at all: no turn signal, no collision warning, no GPS audio, no radio; no hands-free phone volume. Hyundai Service department advised they have never heard of this type of incident. All warning systems are completely silent.

NHTSA ID

11720379

Incident

Feb 25, 2026

Side view camera that displays blind spot area in dash screen cluster, screen intermittently shows just a green screen and not the blind spot.

NHTSA ID

11718964

Incident

Feb 18, 2026

I tried to drive my 2025 Hyundai Santa Fe Hybrid; the vehicle displayed a gear selection error message stating something like "gear already selected". The vehicle would not shift properly and would not power off or restart. I attempted multiple shutdown and restart attempts using the Start/Stop button with no success. The vehicle remained in this condition for about 30 minutes and would not allow normal operation or shutdown. Due to safety concerns, Hyundai roadside assistance was contacted and a tow truck was dispatched. Before the tow arrived, the vehicle spontaneously allowed shutdown without any intervention. This was a safety related failure involving the shift-by-wire system and vehicle power-down logic. The issue occurred without warning and left the vehicle inoperable. The vehicle had app 7150 miles at the time of the incident.

NHTSA ID

11714997

Incident

Feb 1, 2026

This car was in a BBB binding Arbitration and Hyundai was told to fix: speed control malfunction, speed linit not posting to hub arbitrary fan engagement. The Dealership ALM West had the car 2 weeks and the car sat on their lot. They said we are unable to duplicate the problem. Now in addition I showed them the cracked windshield and they were not responsible. I had an insurance complaint I took it to Safelite and replaced the windshield yesterday and I got it back with a new windshield and it also had a Crack in the replacement windshield. I think Hyundai knows there's a problem with the glass which is also part of the safety system of the car.

NHTSA ID

11711053

Incident

Jan 14, 2026

I am reporting a safety hazard with the Driver Monitoring/Driver Assistance system in my 2025 Hyundai Santa Fe SEL (VIN: [XXX] ). The system frequently misinterprets my normal driving behavior as inattentiveness and triggers constant, loud beeping while I am driving. In many cases, it also disables assistance functions mid‑drive, which is dangerous and unexpected. The false alerts appear to be caused by the system misreading my eyes due to their natural shape and size. This issue does not occur with my wife, who has larger eyes, which indicates the system is biased toward certain physiologies and does not reliably detect all drivers. I have tested this repeatedly: if I strain my eyes unnaturally wide, the alerts stop, but this is extremely uncomfortable and only sustainable for a few seconds. The system is effectively pressuring the driver to adopt unsafe, unnatural behavior to avoid constant alarms. Environmental conditions such as sun glare, rain, and darkness make the false alerts even more frequent. The sudden loud beeping is startling and forces me to divert attention from the road. The unexpected loss of assistance features during driving further increases the risk of an accident. This system is not functioning as an assistive feature. Instead, it creates distraction, encourages unsafe compensatory behavior, and fails to accommodate normal variations in driver physiology. I request that NHTSA investigate whether Hyundai’s driver monitoring system meets safety and reliability standards and require corrective action if necessary. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11707370

Incident

Dec 25, 2025

There have been several times that I have been driving and either turning onto a 4-lane road (2 lanes going each way) or driving on the parkway, where my car has slammed on the brakes by itself. Not only was I not prepared for this to happen, but neither were the cars behind me. I tend to drive with at least 1.5 car-length space between myself and the car in front of me. Last week, I was making a right hand turn (going north) into the right lane from a residential street. The only other car near me was the one driving in the left lane (also going north). My car drove about 100 ft and maybe realized that there was a car next to me and just slammed on the brakes. I was suddenly thrown forward. My seat belt locked and I was thrown back into my seat. I had a bruise from my seat belt and came too close to slamming my head on my steering wheel. Thankfully, the car behind wasn't tailgating. About a month ago, I was driving on the parkway going east. I was originally in the right lane. I put on my blinker and when it was clear, I changed lanes to the middle lane. After I was clear and my blinker was off, my car started screaming to tell me that there was a car in my driver's blind spot (this happens EVERY time I switch lanes). I drove for maybe 1.5 - 2 miles and then suddenly, my car slammed on the brakes. Someone must be watching over me because the Escalade behind me (definitely tailgating) was somehow able to swerve into the left lane and then swerve around me to cut me off in revenge. They were screaming and honking at me, while I was screaming and yelling at my car. They could have easily have plowed into me (we were driving at least 60mph) and could have caused a horrible accident that could have killed myself or others around me. I have notified Hyundai of this issue and have read many similar complaints online. Hyundai claims they cannot "replicate the situation" and therefore, Hyundai Corp is unable to fix the problem.

NHTSA ID

11705955

Incident

Nov 26, 2025

The adaptive cruise control does not allow the use of sunglasses to be worn while the cruise control is engaged. The cruise control will immediately shut off when sunglasses, and some prescription glasses are worn. This is a safety issue as you are not allowed to wear sunglasses on a sunny day or when the sun is low in the sky and it is below the car's sun visor. The same camera that is looking at the drivers eyes also controls other safety features and disables them when the driver is wearing their sunglasses, and some prescription glasses as well

NHTSA ID

11702663

Incident

Dec 1, 2025

Consistently after 10-20 minutes of driving with steering assist or immediately upon driving on cold days (under 50F), the steering wheel generates loud squeaking noises with the steering wheel stiffening and becoming harder to turn, creating a potential safety issue. The change is gradual but required a full stop of the car, shutdown, and restart to remedy. This issue has persisted for months and other Hyundai owners have shared the issue on various forums with Hyundai’s solution to replace the full steering column in some instances. Many owners seem to not be able to get help as dealers are not able to easily replicate this issue without lengthy drives.

NHTSA ID

11701815

Incident

Apr 30, 2025

1. [XXX] – I went to get into the Satna FE, the lights blinked and mirrors moved into the unlock position, but doors would not open. I had to use my husbands car since he was out of town to get to work. I came home at lunch after calling my husband and my salesperson , Paula and used the valet key and was able to unlock and get into the vehicle. I then started the Santa FE and this is when the safety warning message appeared. I felt unsafe and Paula had the Hyundai of Statesboro tow the vehicle from my home, retained it for approximately three days, and reported the issue resolved after clearing diagnostic messages and conducting a 50-mile road test. Vaden of Statesboro contacted me on October 17th stating it was ready for pickup and all the codes were cleared. I picked it up on October 18th. 2. [XXX] – The same issued with the doors not opening and had to use the valet key again, the safety warning reappeared around midday while driving, accompanied by a hard shift / drivetrain shock. The vehicle was returned to Hyundai of Statesboro at approximately 5 p.m. The dealer acknowledged the repeated issue and provided a rental vehicle for me ([XXX]), while repairs continue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11699299

Incident

Oct 14, 2025

We purchased a 2025 Hyundai Santa Fe Caligraphy Vin [XXX] in July 2025. During a road trip the following week when we got on the interstate and my wife turned on Cruise Control she began getting notifications on the front panel telling her to keep her eyes on the road and drive safely. These notifications were showing up during the entire trip (300 miles) every 2-5 minutes. We contacted the dealer and have had it in the shop five times now for them to trouble shoot and try to determine the issue. We also opened a case with Hyundai Corporate which they closed indicating they could not find a problem. I have spent multiple hours riding with my wife, reviewing the owners manual, and researching online in a attempt to resolve this issue. During driving test we have experienced a situation where the Message “Take Control of the car the system is shutting down. Shortly afterwards the Cruise Control shuts down and the driver briefly looses control of steering and acceleration. This is a very dangerous situation at 70 MPH. During my trouble shooting I feel I have narrowed down to issue to the Driver Assist System and the Forward Attention Warning system on our Hyundai. Online research (Reddit) indicates numerous other users are experiencing the same issue across multiple Hyundai models. It’s my opinion that this is a Safety issue since the driver can momentarily loose vehicle control. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11698442

Incident

Jul 20, 2025

I just purchased a 2025 Hyundai Santa Fe and the Smart Cruise Control won't work with sunglasses on. There is an Infared sensor on the steering column that has to see your eyes. Sunglasses are needed for this vehicle. If you don't wear them, the sunlight blinds you. The system will beep, display a message stating full face can't be seen, and it shuts the cruise control off and the vehicle decelerates, which is unsafe.

NHTSA ID

11693461

Incident

Oct 3, 2025

Wearing any kind of polarized sunglasses prevents you from seeing the Heads-Up display and will abruptly disable the adaptive cruise control. The Santa Fe forum has hundreds of complaints about this, yet Hyundai has not done anything to correct the problem. I have asked three different dealers about this problem, and they just repeat the company line (you need to find sunglasses that don't cause a problem). This situation is dangerous and unacceptable.

NHTSA ID

11692363

Incident

Oct 5, 2025

The attention detection system is the worst designed feature of any vehicle I have ever experienced. It constantly dings while looking directly at vehicles ahead. It is distracting and turns off by looking DOWN directly at the steering wheel. It is a safety hazard and Hyundai needs to push out a fix ASAP or allow the feature to be disabled entirely. You cannot use cruise control without it activated and the feature is a safety hazard that makes the car LESS safe.

NHTSA ID

11680172

Incident

Aug 12, 2025

I am unable to use speed control while wearing sunglasses due to the driver attention monitoring. It would be dangerous to drive without sunglasses.

NHTSA ID

11648602

Incident

Mar 16, 2025

The sensor always goes off stating my eyes aren't on the road to the point it trys to stop the vehicle in traffic. This prevents me from being able to use cruise control because the sensor is causing issues by not detecting my eyes

NHTSA ID

11646900

Incident

Mar 7, 2025