2017 Hyundai Sonata Fuel system Problems

I am writing to report a direct violation of the Theta II Class Action Settlement terms by Hyundai Motor America. This morning , I emailed an Executive Case Manager explicitly explaining that my 2017 Sonata has an active P1326 code, has the 2019 KSDS update, and requires a mandatory diagnostic under NHTSA Recall 17V226 that cannot be denied due to a salvage title. Instead of replying to my facts, the Case Manager Kathy gave me a hard denial falsely framing my federal recall safety request as a "voluntary goodwill warranty" issue to justify her rejection. Please help me in getting authorization my car with Hyundai dealership in Plano Tx to run the bearing rod test and get it fixed.

NHTSA ID

11751813

Incident

Jul 11, 2026

Supplemental Information to Existing NHTSA Complaint involving a 2017 Hyundai Sonata Plug-in Hybrid (VIN: [XXX] ) While traveling at approximately 70 MPH on a heavily traveled highway, the vehicle suddenly and completely lost propulsion without warning. The vehicle rapidly decelerated in traffic, creating a significant safety hazard for my family and surrounding motorists and requiring emergency maneuvering to reach the shoulder. The vehicle was towed to an authorized Hyundai dealership, where diagnostic testing identified multiple high-voltage battery system fault codes: • P0B68 • P0B6D • P0B72 The dealership diagnosed a high-voltage battery system failure requiring battery replacement. The vehicle is currently non-drivable. During my research, I found multiple owner reports involving Hyundai Sonata Hybrid and Plug-in Hybrid vehicles experiencing loss of power, hybrid system failures, limp mode conditions, and propulsion-related incidents. I also learned that Hyundai previously issued Recall 18V166000 involving 2016–2018 Sonata Plug-in Hybrid vehicles due to battery management system and voltage protection device concerns that could result in loss of power while driving. Dealer says does appply for my car. Although my vehicle’s fault codes may differ from those addressed in the recall, both involve battery-related failures capable of affecting propulsion and creating a highway safety risk. My concern extends beyond my individual vehicle. A high-voltage battery or battery management system failure that can cause a complete loss of propulsion at highway speed without warning presents a potentially serious safety risk. I respectfully request that NHTSA evaluate whether similar incidents involving Hyundai Sonata Hybrid and Plug-in Hybrid vehicles indicate a broader safety concern warranting further review. I can provide dealership diagnostic reports, repair estimates, towing records, photos, and videos upon request. Thank you for your consideration, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATI

NHTSA ID

11741174

Incident

Apr 11, 2026

To whom it may concern, I have own my vehicle since Jan 2018, which was purchased from the dealership's owner w/less than 10k miles. Maintenance has been performed iaw Hyundai's recommended schedule. However, yesterday, I was informed that my vehicle needed a new engine and other replacements totaling $13,934.89. This is OUTRAGEOUS. How can a well kept vehicle w/106445 miles, need such replacements? Thus your assistance will be greatly appreciated.

NHTSA ID

11688064

Incident

Sep 17, 2025

My 2017 Hyundai Sonata Limited check engine light came on at approximately 103,000 miles of use. This happened last week. The code it was pointing to was a faulty Fuel Pressure Sensor. Could also be combined with faulty fuel pump, but the primary code indicates the sensor. I will be taking it in to the Hyundai dealership shortly. The main reason I’m reporting this is because of my previous experience owning a 2011 Hyundai Santa Fe that had to have the engine replaced three times all under warranty. There ended up being a class action lawsuit because of several owners experiencing the same proglem. While this may not be the same case, I am Leary of engine problems like this. I take very good care of my cars with regular maintenance, so I’m reporting this just in case others are experiencing the same problem.

NHTSA ID

11681665

Incident

Aug 4, 2025

My Hyundai consumes oil and I have to put oil in it every two weeks! Also my ignition coils has had to be changed 4 times. Also check engine light just came on code saying catalytic converter or oxygen sensor changed oxygen sensor a couple months ago. I purchased it brand new and as soon as I got over 100,000 miles nothing has been going good since then please help also my paint on the top of the car is starting to peel. Will never buy a Hyundai again.

NHTSA ID

11677661

Incident

Jul 31, 2025

Hello! I bought a car in the USA, I live in another country. Errors that appear in the car are similar to these: [XXX] Еrror appears then, the cogd I give more gas and let go of the pedal. When the engine is heated at different speeds. The scanner showed these errors: P1326 Ignition Control Module - Combustion Quality Input Signal; U0293 Lost Communication With Hybrid Powertrain Control Module; U1004; B2AAA. But the electricians do not know what the reason is and no one can help. So I go for one year with an error ((( Please help! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11635442

Incident

Jan 15, 2024

I have had many problems with my car since 1st day of purchase timing belt oilpans valve cover gasket burning excessive oil caliper brake hose last few events I have experienced my ABS light coming on in the car stop moving while am in traffic very dangerous I work for the hospice reserve one day while driving the car started shaking compulsive and the check engine light came on I was informed oil was leaking onto my spark plug and engine was going out I experienced extreme hot air inside the car coming out vents back firing etc my warranty in finical company seems to be ripping me off more concerned about money I have reported all these problems to them the past 13-14 months i was suppose to hear back from lisa warranty about this problem this past week no contact I reached out to Hyundai Corporation after visiting local dealership on Bedford automile a service rep by the name of aaron basically told me they cannot help me car will need a engine

NHTSA ID

11622064

Incident

Oct 13, 2023

I was driving down the freeway when my engine made a loud knocking noise, the noise got worse as the RPMs increased. The check engine light began to flash and I lost power, the vehicle will not exceed 60mph and vibrates when moving down the road. I believe this issue is widely know about and should be addressed and forced into a recall. I have maintained the vehicle and should not be responsible for a manufacturing error.

NHTSA ID

11593577

Incident

May 24, 2024

While driving on a highway at ~60 mph, the check engine light came on (plus other indicator lights) and the car immediately dropped to ~45 mph. ~20 seconds later, while trying to pull into a school parking lot, the hybrid system fault warning came on and the car dropped to ~5-10 mph and then became extremely difficult to control. The car was towed ~80 miles to my home dealership and it was diagnosed as a partially blocked EGR tube. ~1 month later, on the next longer drive I had to make (all other drives were short distances), ~70 miles into the drive, the car started making a knocking sound and then suffered the same failure under the same kind of conditions. This was diagnosed as a failed knock sensor. One week later I tried to drive it a long distance to see if the problem would happen again (but closer to home) and while traveling on an interstate highway the same issue occurred. This time it was diagnosed as oil in the wiring assembly for the just replaced knock sensor. The dealership tried to give me the car back but I demanded that they do a long test drive. It took 4 days to get them to do what I asked and then they had it break down on them in the same way. I'm not 3+ weeks after that and still don't have the car back (now they're planning to replace the EGR assembly and intake manifold). Each breakdown has thrown the P1326 trouble code but Hyundai refuses to admit that the issue may be the engine itself (related to the recall). It took until the 3rd breakdown and a lot of demands to get a loaner vehicle. I don't know if this is the known engine issue, something else or new but don't feel that Hyundai is taking it seriously. If nothing else, the programming that was added to put the car in safe mode and prevent fires is too aggressive and in each case has made the car undrivable in less than 1 mile. I have gotten lucky in all cases that a safe place to stop was nearby but it is not safe to drive in many areas due to lack of safe pull off location

NHTSA ID

11585677

Incident

Feb 18, 2024

I'm reporting the growing concern of my engine having rod knock or seizing . It has been burning excessive oil since I bought it at 80k miles. I have reached out to hyundai and they have denied me any help as the vehicle is past their 10y/100k mile warranty. Although my vehicle has extended warranty up to 150k miles for engine seize or rod bearing failure through them. There's no warning lamp but the piston slap noise is getting louder, I'm scared this problem might leave my family and I stranded in the middle of the night. Also scared that it can catch on fire due to almost running with no oil. I have to do my oil change every 1200 miles, instead of 3000. corporate hyundai has denied any type of assistance, I went to a dealer to get it checked out and they insist without proof of oil changes there's nothing they can do, i do them myself on all my cars and I'm VERY on top of my maintenance. I have scheduled an appointment 02/07/2024 to try and diagnose the growing issues with the engine itself.

NHTSA ID

11567578

Incident

Jun 15, 2022

During travel on highway (~60 MPH), the vehicle suddenly lost power and the engine stopped functioning properly. The effect of the problem was that the vehicle began to 'buck' - as if the engine was having significant trouble running continuously. The engine light then illuminated solidly (not blinking). The vehicle slowed from lack of power and I was forced to move to the right lane/break-down lane through high speed highway traffic (NJ). I was able to travel /limp a few miles slowly to the next exit and get off the highway to a gas station. The engine ceased operation upon arrival to the gas station. The vehicle was towed to a mechanic who diagnosed the issue as engine failure. The vehicle was towed to a Hyundai dealership for diagnosis by the manufacturer (Denville, NJ). The diagnosis was 'engine failure'. No conditions existed prior to this event. In the recent past, the spark plugs and ignition coils were replaced. The vehicle had ~140,000 miles but it was used every day and was maintained very well during its life. I am the original owner. No insurance claim has been filed.

NHTSA ID

11567481

Incident

Jan 16, 2024

High pressure fuel pump defective. Code p016b. Dealer replaced high pressure pump, gasket, bolt. Sonata has 43265 miles and 80 months.

NHTSA ID

11565133

Incident

Jan 10, 2024

The vehicle has twice been disabled while driving due to “lost communication with hybrid module powertrain control module.” This breakdown is a significant safety hazard as the car loses power and coasts to a stop without any warning. The second time was on a 65 mph highway. Neither time has had any warning before the malfunction lights appeared. The first time occurred on 10/7, and the vehicle was towed to the dealership. Nothing was done besides clearing the trouble codes and test driving with the car, which returned at the end of October—the second time the breakdown occurred about a month later on 12/3. This second time, I removed the code myself on the roadside so as not to be in more danger, and I am currently awaiting an update from the dealership’s service department on their next steps after initially being told to just have it towed in again. Losing power without notice is incredibly concerning. I want to report this safety issue and determine my next steps to resolve it, as this has dramatically impacted my trust in the vehicle and its safety.

NHTSA ID

11558308

Incident

Dec 3, 2023

Steering wheel has electrical issue and only works if you turn it to the left. Also check engine light comes on for emissions problem and oil burning faster than usual as well as the fuel.

NHTSA ID

11547380

Incident

Aug 1, 2023

The oil is leaking into the engine. My catalytic converter has failed as a result of the oil consumption issue.

NHTSA ID

11546299

Incident

Sep 25, 2023

This is my second report and no one helped me. I have a safety issue and I am driving an unsafe car Hyundia refuses to help me.

NHTSA ID

11534746

Incident

Dec 17, 2022

Car is burning an excessive amount of oil. After getting the oil changed I needed to add additional oil. Car is driving sluggish and won't pick up speed. In 2023 the car bucked, check engine light came on and the car failed to drive over 60mph. I took to Firestone to be repaired and they fixed the knock sensor. After a few weeks, the car bucked, check engine light came on and car would not drive over 60, they also informed me the car used too much oil since I drove it last, there was a service bulletin for the oil consumption and to take to Hyundai. Took to dealer for repair, they said engine consumption is fine. After a few days cars started becoming sluggish not picking up speed. I checked the oil - it was empty.

NHTSA ID

11521804

Incident

Mar 15, 2023

The check engine light started flashing Check hybrid system turn off engine massage appeared The gas pedal doesnt work and the car jumps The problem happened 4 times so far with me The same problem happened about 5 times with my uncle that drives 2016 sonata hybrid

NHTSA ID

11514331

Incident

Dec 27, 2022

Mileage

157,187 mi

Car completely lost all power train systems while in motion after repair at dealership for HSG. Car was able to be restarted after shifting into park after complete stop. All instructions in user manual for restarting vehicle while in motion were followed but not successful. The vehicle died again pulling into dealership and the tech began diagnosis.

NHTSA ID

11504025

Incident

Jan 27, 2023

Complete loss of power. Car shut down at freeway speeds. Dealership runs codes and they cannot find out what specifically is causing issue. Issue cannot be replicated as it only happens a few times a year and has existed since shortly after purchase of the car brand new. There is articles all over the internet people having similar experiences. This car is NOT safe. Hyundai does not communicate hybrid system codes through their telematics system so there is no paper trail. The car also clears the codes out after 3 reboots following the check hybrid system codes. Dealer has reported car shut down due to voltage issues-not able to determine the reason since after reboot the car drives normally.

NHTSA ID

11500049

Incident

Dec 28, 2022

The car lost all acceleration and my check hybrid system light came on. The car would not handle safely to drive. After 3 resets the car finally accelerated as normal. The codes clear themselves before the dealer can check them to give a specific issue. It is not giving the diagnosis for the hybrid issue in the diagnostic log.

NHTSA ID

11498886

Incident

Dec 25, 2022

Car was bought in march of 2022 and has had major oil problems since . The oil needs to be changed / filled every 2 weeks . Was taken to a proper mechanic shop where it was stated the car is consuming large amounts of oil and it’s burning leaving the oil level bone dry .mechanic stated the oil most likely was leaving through the tail pipe / exhaust on a blue kinda of smoke .

NHTSA ID

11489130

Incident

Apr 13, 2022

Engine intermittingly stalls while driving. Unsafe/dangerous!

NHTSA ID

11484370

Incident

Sep 13, 2022

It's knock sensor issue code was showing since 85000 mileage, dealer just got rid of the code and said can drive safely. Then again at 101000 mileage knock sensor code and Hyundai dealer said software is updated can drive safely. Also it's engine oil burning faster that we keep on topup oil all time. Then at after 108000 mileage my car started overheating, & it's engine seized. Now Hyundai don't want to fix such problems. I don't know maybe it get fixed, then catches fire on highway can cause death.

NHTSA ID

11475225

Incident

Jul 22, 2022

I work from home so I don't travel that much. A few months ago, my car was jerking when trying to accelerate. The engine light was flashing on and off. I took it on to the dealership and was told it was a computer update causing the problem. After leaving, the car was doing better, but not completely right as it was prior to the issue. I returned back to the dealership later to explain what else was going on. The car still Jenks on acceleration, but not as forceful. I was then told it is possibly my intake manifold and spark plugs. I plan to take my car back for the spark plugs, but I'm curious about the intake manifold. Either way, this is an issue for when I'm trying to accelerate after a stop and I have a long delay. It also does this on an incline. My car doesn't want to climb on an incline.

NHTSA ID

11473870

Incident

Apr 30, 2022