2016 Hyundai Tucson Visibility Problems

The contact owns a 2016 Hyundai Tucson. The contact stated that while the vehicle was parked, the front passenger’s side door failed to unlatch as needed. The front passenger's side window failed to roll up or roll down. The driver's side rear door failed to unlatch or latch as needed. Additionally, the trunk switch failed to operate as needed. The dealer was made aware of the failures but provided no assistance. The contact was informed that the repairs were not covered under recall or warranty. The contact stated that the vehicle was unsafe to operate. The contact feared being locked inside the vehicle and being unable to exit the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 52,000.

NHTSA ID

11747133

Incident

Feb 11, 2026

Mileage

52,000 mi

The regulators and motors for the automatic windows have failed. The windows do not remain in the closed position causing the window to slide open. The front passenger window motor failed first and the driver's window failed shortly after. Both regulators and motors were replaced by the dealer in April 2024. The back passenger side window failed in December 2024 and has not been replaced. If needed, the faulty mechanism could be provided for inspection. Failure of the closing mechanism for the windows means they can easily be opened from outside. A malicious person could break into the vehicle simply by sliding the window down. To my knowledge, no one has inspected the regulators or motors. Two other 2016 Hyundai Tucson owners I know have also had their window regulators and motors replaced. There was no warning to the automatic window failure.

NHTSA ID

11661358

Incident

Dec 15, 2024

Front passenger door won’t open Defroster/heat won’t work on drivers side

NHTSA ID

11624465

Incident

Nov 11, 2024

•Window regulator •Stops windows movement •Our independent service provider •No •No

NHTSA ID

11606671

Incident

Jul 29, 2024

The contact owns a 2016 Hyundai Tucson. The contact stated that on multiple occasions while driving at various speeds, the four windows rolled down independently. The vehicle was taken to an independent mechanic where the front driver’s side window was replaced; however, the three remaining windows failed to operate as needed. Recently, the rear passenger’s side window was locked in place by a mechanic to prevent the persistent failure. The dealer was notified of the failure and the contact was informed that the vehicle was not under recall or warranty. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 60,000.

NHTSA ID

11583802

Incident

Dec 1, 2023

Mileage

60,000 mi

The window regulator cables for all windows have failed multiple times, even after taking it to the dealership and paying to have this defect “fixed” they fail again. Now the only working window is the drivers and I cannot afford to have the other 3 fixed which is a safety hazard if an emergency were to happen. This is a manufacturer defect and there needs to be a recall done.

NHTSA ID

11567368

Incident

Apr 23, 2023

A/C failure & Heat Failure which resulted in an accident. Was not the thermostat. ACCEDENT was unable to defrost/defog windows, causing the driver to crash

NHTSA ID

11564862

Incident

Dec 28, 2023

Power window passenger side, stopped working, it is not the motor, you can hear motor running but window does not work.

NHTSA ID

11557026

Incident

Sep 15, 2023

Manufacturer’s defect, all (4) windows quit operating. Hyundai dealer where vehicle was purchased did repair my driver window, however; shortly after that window was repaired, all other (3) windows quit working at the same time. One (1) window was in the down position. Hyundai of New Port Richey said they would not repair my windows, however; they did get the window up and suggested I purchase door stops to place in the window to keep it up….this also happened to the other rear window. I live in Florida and on August 17, 2023 I had to drive myself to Mease/Countryside Hospital, the heat index was 115 degrees, I had to get into my extremely hot vehicle. I was diagnosed with heat exhaustion. My bill was $ 23,000. I also have a grand baby I have to place in my very hot vehicle when I babysit. Three (3) windows do not function. On September 08, 2023, Hyundai of NPR Service Advisor gave me a ball park quote of $ 750.00, including labor to repair all three (3) windows….I then made a formal complaint to the complaint number I found in my vehicle manual: Case Number [XXX] they did not help and referred me to the General Manager of the dealership. Now the price to repair is $ 2,100.00. They will fix if I pay half! I have talked with other 2016 Hyundai Tucson owners who have run into the same problem. The manufacturer is at fault, the window parts are defective! Please help me, my health has been affected and I hate putting my Grandchild [XXX] in unheathy environment. Thank you for anything you can help me with. [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11555918

Incident

Aug 17, 2023

The contact owns a 2016 Hyundai Tucson. The contact stated that while the vehicle was parked, the contact noticed that the window had become inoperable. No warning light was illuminated. The vehicle had not been diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised that the vehicle be taken to a dealer for the repair. The failure mileage was approximately 68,000.

NHTSA ID

11549817

Incident

Aug 1, 2023

Mileage

68,000 mi

On 10/24/22 I took my 2016 Hyundai Tucson into dealership Springfield Hyundai 754 Baltimore Pike Springfield PA 19064 for a faulty drivers side window. At that time they advised the issue with the window was 'striped gear' and replaced 'drivers window regulator' under the extended warranty I purchased when I bought the vehicle. At that same time there was also an issue in the left front door latch and it was replaced under 'warranty.' On 03/03/23 the right rear door also had a latch issue and was replaced at that time. About a week ago, my front passenger side window stopped working. It will not go up or down. I returned to the same dealership on 07/27/2023. I was advised that 'found right front window regulator and motor gears are splined. Both parts need to be replaced. Charge is $890.98.' The car's extended warranty has expired and I would need to pay for this out of my pocket. My concern here is what I consider a trend with my vehicle experiencing window issues and it has not even reached 100K miles - in addition to the door latch issues. By the way, I also have a 2017 Hyundai Elantra which has also had to have almost every door latch replaced. After this second window issue popped up, I became curious and searched the internet for 2016 Hyundai Tucson window issues. And to no surprise, there are multiple consumers with complaints reporting the same exact issue as I am, with their windows as well. Based on current trends and concerns with your car manufacturing, parts, missing basic anti-theft tools, cars being stolen, and a plethora of other issues I am confident this issue with my window is at fault of Hyundai's poor production, manufacturing, and quality control. Windows are an emergency exit. In the case of an accident, you need to be able to open the window to exit if it is the only viable option. You can become trapped inside your vehicle if the windows do not work. Window needs to be operable to combat exhaust that may be trapped inside vehicle.

NHTSA ID

11546617

Incident

Jul 27, 2023

The contact owns a 2016 Hyundai Tucson. The contact stated that the driver’s and passenger’s side front windows and the passenger’s side rear door window regulators were inoperable. The contact stated that the regulators were making a whining sound but failed to roll up or roll down. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 76,000.

NHTSA ID

11544165

Incident

Jul 10, 2023

Mileage

76,000 mi

Car window regulator failed. window could not be rolled up and occupants subjected to outside weather conditions.

NHTSA ID

11540252

Incident

Aug 1, 2023

Car window regulator failed. window could not be rolled up and occupants subjected to outside weather conditions.

NHTSA ID

11540250

Incident

Aug 11, 2023

Both my front window (driver and passenger side) regulator and motor failed and needed to be replaced within the past 6 months. With both windows, I lowered and then they wouldn't close. Two separate occasions. First was December 2022, and second was July 2023. This is an expensive repair and for a vehicle with only 50,000 miles, I find this unacceptable. I have read multiple complaints for this same issue. Hyundai needs to make this right and reimburse for repair(s). Thank you, Barbara Miller

NHTSA ID

11537426

Incident

Dec 26, 2022

The contact owns a 2016 Hyundai Tucson. The contact stated that all four automatic windows failed to operate as needed. The front driver’s side window started failing and an appointment was scheduled with the dealer to repair the window. While testing the windows in the dealer parking lot after the repair, the front passenger’s side window fractured, and the dealer agreed to cover the cost of the repair free of charge. Over time, the rear windows started to lower independently, and the vehicle was repaired by an independent mechanic. In addition, the contact stated that the vehicle intermittently failed to accelerate while depressing the accelerator pedal. There was no warning light illuminated. The contact stated that the vehicle lunge forward while accelerating. The manufacturer was also notified of the failure. The vehicle was not repaired. The failure mileage was approximately 20,000.

NHTSA ID

11532800

Incident

Jan 1, 2022

Mileage

20,000 mi

excessive oil consumption. it has been confirmed by valvoline instant oil change center. after an oil change, round 600 miles the oil is to be checked and topped off completely because the reservoir is bone dry. can not make it a complete 3,000 miles until the next oil change. the oil has to be topped off at least 2-3 times until the next oil change. there are no warning lamps, messages, or other symptoms to notify of the problem. it has been inspected by hyundai dealership, whom at someone point replaced the turbo in the limited 1.6L. also, the windshield wiper reservoir decided to stop working. I have to wait until it rains or go through a car wash to clean my windshield. all hoses have been checked and there are no leaks or disconnection of the hose. the windshield wiper fluid will not come out and remains completely full.

NHTSA ID

11530483

Incident

Jul 23, 2021

The contact owns a 2016 Hyundai Tucson. The contact stated that when she was near her vehicle, she noticed that the driver's side window was down. The contact stated that she could not roll the window up. The contact stated that over the next month, the other three windows were lowered and could not be rolled up. Additionally, the contact stated that the headlights had failed, and she had them replaced. The contact had taken the vehicle to a local dealer where it was diagnosed and determined that the windows mechanism needed to be replaced. The vehicle had been repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 53,000.

NHTSA ID

11524041

Incident

Jun 9, 2021

Mileage

53,000 mi

While running errands in her 2016 Hyundai Tucson my wife rolled down her front driver and passenger side windows. When she encountered rain she attempted to roll both windows up, but the passenger side window would not roll up, causing a dangerous distraction where heavy rain was entering the vehicle while she was driving. Our mechanic inspected this part and said that the gears controlling the window were made of plastic which had been shredded over time and that the motor itself showed signs of corrosion. The vehicle is only 7 years old and has been well maintained, so i can't understand why this part failed so easily. Our mechanic informed us that this is a VERY common issue with Hyundai vehicles and that parts would be hard to come by because of high demand. This issue is available for inspection upon request and has been inspected by a licensed mechanic. There were no dash warnings associated with this issue.

NHTSA ID

11522025

Incident

May 12, 2023

In the past six months, three of the four window regulators on my 2016 Hyundai Tucson stopped working. Recently, one of my windows fell out while driving on the highway. Looks like this is a manufacturing defect as hundreds of complaints have been reported on the internet. The vehicle needs to be recalled as this seems to be a common problem in most 2016 Tucsons and poses significant risks while driving, especially on highways at high speeds. I’ve included some exact complaints for your reference here: https://www.vehiclehistory.com/questions/why-is-my-hyundai-tucson-2016-window-not-working-353123 I hope this problem gets resolved soon. Thank you.

NHTSA ID

11513263

Incident

Jan 6, 2023

Window regulator has broke in all 4 windows

NHTSA ID

11513143

Incident

Mar 21, 2023

All 4 windows have a failed regulator. It's a plastic gear attached to the window motor. The windows do not stay up/closed. I am afraid they will fall and break while driving. The Hyundai dealership quoted 3,800 to repair them.

NHTSA ID

11511291

Incident

Oct 1, 2022

Cheap plastic regulator for the driver side window broke and can't roll up my window

NHTSA ID

11510487

Incident

Mar 6, 2023

Driver door power window control fails. Window won't go up or down while the window motor in the door can be heard operating. After the failure it is possible to manually pull the window glass up and down in it's track. The glass moves freely in it's track. The weight of the glass is sufficient to prevent the window from remaining closed, ie the glass drops down into the door if it is not held up. Window must be manually wedged or some how mechanically held in the closed position. This is an obvious theft concern if the vehicle cannot be locked. Problem identified; The power regulator drum is a plastic that deteriorates with time. The splines in the drum strip away and the power motor shaft spins freely in the drum, in both directions.

NHTSA ID

11507799

Incident

Oct 1, 2022

Unable to roll passenger window down using the power control on the driver's door. Took it to a Hyundai dealership for diagnosis and repair. It cost $506.67 to fix, driver front main window switch was replaced.

NHTSA ID

11504186

Incident

Oct 4, 2022