2022 Hyundai Tucson Exterior lighting Problems

While driving at night, the headlights on my 2022 Hyundai Tucson Hybrid shut off randomly, including when using the turn signal. The lights will turn off without warning at highway speeds, creating a serious safety hazard. Using the turn signal can cause the headlights to turn off, and sometimes using the turn signal will temporarily turn them back on. The headlight mode also changes by itself while driving (AUTO to OFF to ON to OFF). Additionally, when the vehicle is turned off, the headlights often stay on no matter what mode the switch is in. I have to restart the vehicle and manipulate the turn signal/headlight stalk multiple times to get the lights to turn off. This is a recurring and dangerous failure that affects nighttime visibility and safety for me and my family. No other electrical issues are present. This is available for inspection. Safety for my family and all others on the road put at risk as the headlights randomly shut off at night. The problem was reproduced by the dealer. The dealer quoted a $1,500 repair, but this a safety‑critical defect in the lighting control system.

NHTSA ID

11755276

Incident

Jul 1, 2026

The contact owns a 2022 Hyundai Tucson. The contact stated that while his wife was operating the vehicle, the vehicle lost headlight functionality without warning. In addition, the contact stated that the radio intermittently failed to operate while driving the vehicle. The contact stated that the headlight became operable when his wife was near to her destination. The vehicle was not diagnosed or repaired. Upon investigation, the contact discovered NHTSA Campaign Number: 21V938000 (Electrical System, Exterior Lighting); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was approximately 25,800.

NHTSA ID

11754364

Incident

Aug 2, 2026

Mileage

25,800 mi

Brake lights, hazard lights, and turn signals in the back of the car stopped working. Took vehicle into Glenbrook Hyundai dealer in Fort Wayne, Indiana and the dealer confirmed the problem is caused by the open safety recall. No remedy exists yet, so dealer charged me diagnostic fees for recall-related work.

NHTSA ID

11709015

Incident

Jan 5, 2026

First incident: While driving on the highway, my vehicle began to vibrate intensely, jerking, lost acceleration and ultimately was unable to drive. Smelled burning. No warning lights came on- no indication of a problem. I only had time to exit on ramp and car stopped in the middle of traffic. Car had to be towed to dealer. Second incident: I was driving and the vehicle began jerking and vibrating with no acceleration. Smelled burning again. Only after this happened did the engine light appear. I was able to get over to the side of the road. Luckily I wasn’t far from home. Car had to be towed to dealer again Very unsafe and no recall from Hyundai.

NHTSA ID

11575832

Incident

Jan 23, 2024

On 3/8/22 between 5:10 pm ET and 5:45 PM ET, I was traveling to a destination with a friend following behind me in her vehicle. Later, when it was dark, we traveled back to our homes. She followed me again until the location that we parted to head in different directions. After arriving home, she messaged me to state that my "tail lights kept going on and off the whole way" to our destination. She also stated "They were fine on the way home though in the dark". I'm unsure if my vehicle was part of the 12 vehicles recalled for lighting issues/reflashing, but if it is, it didn't work, or if it wasn't, the recall may not have covered everything.

NHTSA ID

11455850

Incident

Mar 8, 2022

The headlights on the 2022 Hyundai Tucson are a road safety hazard and should be outlawed from US roadways. Turning on the headlights creates a dark shadow covering over half of the windshield from top to bottom with a triangle at the bottom of shadow at each end. The triangles can be seen on each headlight lens. Driving the Tucson at night is like wearing a pair of dark sunglasses. The bottom of the shadow moves with every movement of the vehicle which is distracting hazardous, hypnotizing and not safe. If I would have driven this vehicle at night, I would not have purchased it.

NHTSA ID

11450274

Incident

Oct 24, 2021

I purchased my Hyundai Tuscon Limited Saturday 10/30/21 and during the day its perfect at night the headlights produce a black shawdow on the driver side headlight. I am now nervous to drive my vehicle at night due to causing an accident. The visibility in the road from the blind spot has mimicked something black crossing the road and slammed my breaks on thinking I was going to hit an animal or something. It causes visibility issues that are a safety hazard. The dealership can't seem to see what I see or don't have any information on this issue. But if you go to https://www.hyundai-forums.com/threads/2022-tucson-headlight-problem-black-void-shadow-on-driver-side.677546/ Many are having the same issue, no warning lights or anything its a defect in the headlights

NHTSA ID

11438978

Incident

Nov 1, 2021

Nothing happened...yet. Has the NHTSA noticed how several new Hyundai vehicles, as well as a few Infiniti and Toyota vehicles, have turn signals mounted on the rear bumper? This is ridiculous and should be UNACCEPTABLE. There's absolutely no reason turn signals and reverse lamps can't be mounted where the stop and tail lamps are mounted. It's nearly impossible to see turn signals on the bumper. PLEASE CONSIDER A HEIGHT MANDATE FOR REAR TURN SIGNALS AND REVERSE LAMPS. And, if possible, also consider a mandate for *bright* side repeater signals, amber rear signals, and a height requirement for front signals as well. It's about time that North America joined the rest of the world in these mandates. Thank you!!!

NHTSA ID

11425983

Incident

Jul 22, 2021