2022 Hyundai Tucson Problems

Vehicle Fuel Injector code P053F84 Reading on 9/9/26, this is the second time vehicle was taken to the dealership for the exact same problem, the idle button in orange, and displayed, first visit while vehicle within warranty limits technician stated couldn't find anything wrong, now vehicle is out of warranty and dealership wants $1300 to fix the same issue.also the Engine was hesitating at each occurrence.

In April 2026 (29,805 miles) I was on an interstate underpass U-turn and when I went to accelerate from the U-turn, the vehicle “revved”, had difficulty accelerating, and appeared to not go into the next gear for a roughly 10 seconds, meaning I was unable to accelerate and get out of the way from oncoming traffic. Traffic slowed and the vehicle suddenly returned to normal (no warning lights appeared) and I drove home cautiously with hazards on. When attempting to leave less than 45 minutes later, the vehicle started, then as I placed it into drive, it began lunging and the check engine light appeared. Because it was running rough and kept lunging, I parked and had it towed to the dealership. The DTC code listed was PO30300 (DTC system powertrain and subsystem EMS). Per the dealership, fuel injector #3 was bad and needed to be replaced. When I picked up the vehicle, notes stated “ GDI FUEL INJCTR REPL (ALL4)”. I picked up the vehicle after the repair. In August 2026 (30,923 miles), with less than 1,000 miles driven since repair, I started the vehicle and it immediately “died”. I restarted it and the check engine light came on and it began lunging out of my driveway. I also had difficulty getting the vehicle to brake and almost hit our community entrance/exit gate. A notification appeared on my infotainment system stating: “A possible condition with your Engine Control System has been detected. A full system check is recommended to be done soon. Please contact your local dealership to schedule an appointment”. The DTC codes listed on the Hyundai app were: PO30020, PO30040, PO30010, PO30000, and PO19185, P217700. (DTC system powertrain and subsystem EMS). I had the vehicle towed to the dealership. They didn’t have a loaner vehicle and I canceled my trip. Later, I was notified that “a hose was disconnected and was allowing air to enter the engine”. He stated, “we flushed it out and everything is working now”. I was told I could come pick it up before they closed.

Vehicle Fuel Injector code P053F84 Reading on 9/9/26, this is the second time vehicle was taken to the dealership for the exact same problem, the idle button in orange, and displayed, first visit while vehicle within warranty limits technician stated couldn't find anything wrong, now vehicle is out of warranty and dealership wants $1300 to fix the same issue.also the Engine was hesitating at each occurrence.

The car was shaking, idling and accelerating and engine lights on.

In April 2026 (29,805 miles) I was on an interstate underpass U-turn and when I went to accelerate from the U-turn, the vehicle “revved”, had difficulty accelerating, and appeared to not go into the next gear for a roughly 10 seconds, meaning I was unable to accelerate and get out of the way from oncoming traffic. Traffic slowed and the vehicle suddenly returned to normal (no warning lights appeared) and I drove home cautiously with hazards on. When attempting to leave less than 45 minutes later, the vehicle started, then as I placed it into drive, it began lunging and the check engine light appeared. Because it was running rough and kept lunging, I parked and had it towed to the dealership. The DTC code listed was PO30300 (DTC system powertrain and subsystem EMS). Per the dealership, fuel injector #3 was bad and needed to be replaced. When I picked up the vehicle, notes stated “ GDI FUEL INJCTR REPL (ALL4)”. I picked up the vehicle after the repair. In August 2026 (30,923 miles), with less than 1,000 miles driven since repair, I started the vehicle and it immediately “died”. I restarted it and the check engine light came on and it began lunging out of my driveway. I also had difficulty getting the vehicle to brake and almost hit our community entrance/exit gate. A notification appeared on my infotainment system stating: “A possible condition with your Engine Control System has been detected. A full system check is recommended to be done soon. Please contact your local dealership to schedule an appointment”. The DTC codes listed on the Hyundai app were: PO30020, PO30040, PO30010, PO30000, and PO19185, P217700. (DTC system powertrain and subsystem EMS). I had the vehicle towed to the dealership. They didn’t have a loaner vehicle and I canceled my trip. Later, I was notified that “a hose was disconnected and was allowing air to enter the engine”. He stated, “we flushed it out and everything is working now”. I was told I could come pick it up before they closed.

My 2022 Hyundai Tucson Experience, a sudden transmission failure at approximately 92,520 miles. The vehicle develop shifting issues and abnormal noises before losing propulsión. While driving. Hyundai diagnosed and internal Transmission failure and approved transmission replacement. I’m concerned about the sudden loss of proportion and the safety risk this creates. Hyundai proposed repair is to replace the transmission with a rebuild remanufacture transmission rather than a new transmission. I am concerned about the reliability of the repair following a complete transmission failure.

I had just started accelerating from a stop light at 715 am on a clear morning. I was not close to any other cars and there was no traffic entering. Without warning my collision warning came on and brought the car to a sudden stop. This is damgerous and I am lucky I was not rear ended

The car was shaking, idling and accelerating and engine lights on.

The contact owns a 2022 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the right turn signal indicator light failed to illuminate on the instrument panel upon depressing the turn signal lever to make a right turn. No warning lights illuminated. Additionally, upon depressing the turn signal lever to make a left turn, the left turn signal indicator light failed to illuminate. The contact stated that the failure progressed. While driving at various speeds, the brake lights failed to illuminate when the brake pedal was depressed. The vehicle was taken to an independent mechanic, where it was diagnosed that the wiring harness needed to be replaced. The vehicle was repaired. The contact associated the failure with NHTSA Campaign Number: 25V893000 (Trailer Hitches); however, the VIN was not included in the recall. The dealer and the manufacturer were notified of the failure, and a case was filed. The failure mileage was approximately 69,000.

The contact owns a 2022 Hyundai Tucson. The contact stated while driving at an undisclosed speed, several unknown warning lights illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with ECU software error. The contact was advised to contact the dealer. The dealer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 108,565.

My wife was driving my SUV while I was a passenger. We were in the left lane, and put the left turn signal on while traveling south bound approaching an intersection to take a left turn (traveling approximately 3-5 Miles Per Hour and slowing) at the traffic light (traffic light was green). There was a car in front of us that had stopped waiting for oncoming traffic to clear and make the same left turn onto the same road as us. While traveling in this lane we hit a deep pot hole (not very visible while driving), just as we were approaching the vehicle stopped in front of us. When hitting the pot hole, our SUV seemed to leap forward a bit and when the brakes were applied to slow and stop, the braking system failed (appeared to freeze) and the brakes did not work, and because the braking didn’t work, our vehicle hit the car in front of us. Prior to and after hitting the pothole, no audible warning sounds or visible alerts appeared and no emergency braking was activated. The airbags in our vehicle never deployed. Our safety (my wife and I) as well as the safety of the 2 passengers in the other vehicle were at risk as we all could have been injured in the accident. As we needed the vehicle for transportation, we immediately began filing all the necessary police and insurance reports and brought our vehicle into an Auto Body Repair Shop to be repaired the next day. During the repair work, some of the responsible components may or may not have been replaced and the Auto Body Repair Shop also had all the car sensors recalibrated by a 3rd party, which is why we did not bring the car to a dealership to evaluate. To the best of our knowledge, the manufacturer, the police and the insurance company did not inspect the vehicle. We are not experts, but hitting a pothole might be considered an edge case, so I’m not sure that a dealership would have tried or been able to replicate the issue.

Front brake rotors warped causing violent brake pedal pulsating and steering wheel vibration. My vehicle has only 18000 miles. The dealership Hyundai reported problem as a service bulletin TSB 23-BR-004H. I believe this a safety issue and a recall should be annouced.

The contact owned a 2022 Hyundai Tucson. The contact stated that while her husband was driving at 25-30 MPH, another vehicle struck the front driver side, flinging the vehicle to the right side before another vehicle crashed into the front passenger side. The air bags failed to deploy. No warning light was illuminated. The contact's husband sustained back injuries, while the contact suffered a concussion. Medical attention was received for both. A police report was filed. The vehicle was towed to a tow yard, where it was deemed totaled by the insurance company. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 46,000.

Airbag indicator came on around 62000 miles. Was told by Hyundai technician that it cost $2100 plus to replace part. Hyundai has known problems with airbags. Did this extend to my model? Have others had similar problems?

While driving my 2022 Hyundai Tucson at highway speed, the panoramic sunroof spontaneously shattered with a loud “explosion” sound. There was no road debris, overhead structure, or external cause, and no warning lights or prior symptoms. The glass shows a central hole with spiderweb cracking radiating outward, which is consistent with a manufacturing defect in tempered glass panels, not an impact. The sunroof shade was closed, preventing glass from entering the cabin, but this failure created a serious safety risk to occupants and nearby drivers. This matches numerous reports of Hyundai panoramic sunroof failures and is similar to the pattern documented in NHTSA Investigation PE13-017. The vehicle has not yet been inspected by Hyundai but is available for inspection. Incident occurred on [XXX], while driving from Monroe, Louisiana, to Atlanta, GA, shortly after departure. The failure created a serious safety issue, forcing us to stop at a Home Depot and perform emergency repairs using tarp and Gorilla tape to secure the roof and continue our trip safely. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The component that failed are the visibility with headlights being completely snow packed and covered in a snow storm. The lights themselves did not fail, but the design causes snow to get stuck over all the headlights, which continues building to a point where 99%+ of light blocked. This has occurred numerous times since owning the car, easily 20+ times. VERY dangerous, oncoming cars will flash their headlights because the Tucson headlights are completely covered. Visibility is greatly decreased. Have to pull over multiple times driving in snow storms to break the snow and ice free from the headlights, only to build up again once driving. This puts not only our lives, but other drivers lives at risk. Just imagine driving in winter conditions, at night, with no headlights. Mentioned to dealer, but not documented anywhere and was not given any serious consideration. At that point we were focused on trying to get the power loss/hesitation and extremely rough shifting fixed. Big design flaw with the combination of headlights built into the grill, and with new technology, the lights must not get hot enough to melt the snow. Anyone who thinks that driving in a snow storm, at night, and no headlights isn't a huge safety issue or that this is exaggerated, I invite you to come take a ride with us this winter.

While driving at night, the headlights on my 2022 Hyundai Tucson Hybrid shut off randomly, including when using the turn signal. The lights will turn off without warning at highway speeds, creating a serious safety hazard. Using the turn signal can cause the headlights to turn off, and sometimes using the turn signal will temporarily turn them back on. The headlight mode also changes by itself while driving (AUTO to OFF to ON to OFF). Additionally, when the vehicle is turned off, the headlights often stay on no matter what mode the switch is in. I have to restart the vehicle and manipulate the turn signal/headlight stalk multiple times to get the lights to turn off. This is a recurring and dangerous failure that affects nighttime visibility and safety for me and my family. No other electrical issues are present. This is available for inspection. Safety for my family and all others on the road put at risk as the headlights randomly shut off at night. The problem was reproduced by the dealer. The dealer quoted a $1,500 repair, but this a safety‑critical defect in the lighting control system.

The contact owns a 2022 Hyundai Tucson. The contact stated that while his wife was operating the vehicle, the vehicle lost headlight functionality without warning. In addition, the contact stated that the radio intermittently failed to operate while driving the vehicle. The contact stated that the headlight became operable when his wife was near to her destination. The vehicle was not diagnosed or repaired. Upon investigation, the contact discovered NHTSA Campaign Number: 21V938000 (Electrical System, Exterior Lighting); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was approximately 25,800.

The contact owns a 2022 Hyundai Tucson. The contact stated that while driving 15 MPH, the vehicle jerked right and inadvertently drove into a snowbank. The vehicle was taken to the residence and then towed to a dealer, where the failure could not be duplicated. The contact had not sustained injuries, and a Police Report was not filed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 30,200.

The contact owns a 2022 Hyundai Tucson. The contact stated while driving approximately 20 MPH and depressing the brake pedal, the brakes and power steering malfunctioned, causing the contact to momentarily lose control of the vehicle and the vehicle drove into the middle of a busy intersection. The contact stated that the failure had occurred on two previous occasions and the vehicle was taken to the local dealer, but no cause for the failure was found. The manufacturer was not notified of the failure. The failure mileage was 300.

After inspection by a few people it was determined that the front passenger side lower frame cracked which then cracked the body oozing rusty water out of it. I was told that if the car was hit on the passenger side that it would not retain its ability to be stable and would crumple. It has been inspected by the Hyundai dealership, A general manager from another dealership and 3 auto body welders. This first appeared in December of 2025 after I had washed my car and was drying it off.

While driving my 2022 Hyundai Tucson at highway speed, the panoramic sunroof spontaneously shattered with a loud “explosion” sound. There was no road debris, overhead structure, or external cause, and no warning lights or prior symptoms. The glass shows a central hole with spiderweb cracking radiating outward, which is consistent with a manufacturing defect in tempered glass panels, not an impact. The sunroof shade was closed, preventing glass from entering the cabin, but this failure created a serious safety risk to occupants and nearby drivers. This matches numerous reports of Hyundai panoramic sunroof failures and is similar to the pattern documented in NHTSA Investigation PE13-017. The vehicle has not yet been inspected by Hyundai but is available for inspection. Incident occurred on [XXX], while driving from Monroe, Louisiana, to Atlanta, GA, shortly after departure. The failure created a serious safety issue, forcing us to stop at a Home Depot and perform emergency repairs using tarp and Gorilla tape to secure the roof and continue our trip safely. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Brand/Model: Bridgestone Alenza AS Ultra Size: 235/60R17 DOT Code: 1W281AAU11925, W281AAU1025, W281AAU14124, W281AAU10525 Purchase Date: July 28, 2025 I am reporting a catastrophic and unpredictable treadwear failure on a set of four (4) Bridgestone Alenza AS Ultra tires (80,000-mile warranty / 800 UTQG). Despite professional maintenance, these tires have degraded to a legally bald and unsafe state (2/32") in less than 8,000 total miles. The tires exhibited a sudden "melting" effect. On October 31, 2025 (Odo: 28,330), a third-party inspection verified a safe tread depth of 9/32" with even wear. However, by February 20, 2026, the tires had dropped to 3/32", and by March 20, they reached 2/32". This represents a loss of 7/32" (70% of usable tread) in only ~3,800 miles. This rapid, non-linear degradation creates an emergency safety hazard, as the tires lost wet-weather traction and hydroplaning resistance in less than 30 days between service checks. Maintenance History: The vehicle (2022 Hyundai Tucson) has a documented history of proper care: Professional Alignment: September, 2025 (Insurance-certified). Tread Verification: October 31, 2025 (Confirmed 9/32" and even wear). Rotation Service: February 20, 2026 (Performed at 7,500-mile interval). The failure is global across all four tires, including the non-driven rear axle, indicating a fundamental rubber compound defect. Retailer (Costco)has denied warranty support, citing "rapid wear" as a non-covered issue, despite the tires failing 72,000 miles before their engineered lifespan. This defect leaves the consumer on the road with unsafe, bald tires that failed without warning.

POSSIBLE RECALL SITUATION Kumho Crugen HP 71 101H 235 55 R19 Warranted Tire Life: 65,000 Miles Failed at: 32,000 Miles (estimated) 3 out of the 4 original tires failed on vehicle under 50% through normal life of tire. I DO Have Tires in my possession. • According to 2 different tire departments including Dealership in which car was purchased, 3 out of 4 original tires failed due to BROKEN BELTS. • A blowout can cause loss of control of vehicle, leading to possible injury or death not only for vehicle inhabitants, but for other vehicles and/or pedestrians as well. • Problem reported to 2 different facilities including Lithia Hyundai New Port Richey, Florida where vehicle was purchased with these tires as OE Original Equipment. • Issue was reported to: Place of purchase: Lithia Hyundai New Port Richey, Florida (OE Original Equipment) • Issue was reported to: Lithia Corporate Office including Legal Department and Chief Operating Officer. Legal Customer Relations Representative stated: "Corporate will not be able to assist you further at this time. Corporate found your warranty has expired for your tires..." • Issue was reported to: Kumho Tire USA Warranty Department • Kumho Warranty Representative stated "that the process MUST be started with the Dealership selling the tires." • Issue was diagnosed by Original Dealer, Lithia Hyundai of New Port Richey as Broken Belts on 3 out of 4 tires. • Issue was diagnosed by Sam's Club New Port Richey as Broken Belts on 3 out of 4 tires. Diagnosis was completed through a "Run-Out Test". 4 new tires of different brand installed. oNo Warning Lights or Messages oVery small vibration occurred around 32,000 miles. oAround 33,000 miles estimated, took vehicle in for Oil Change and Rotate & Balance. At this time, the vibration had progressed to a more severe vibration with pulling to the right. oAround 33,700 miles took vehicle back in to inform them of very severe vibration.

The contact owns a 2022 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the right turn signal indicator light failed to illuminate on the instrument panel upon depressing the turn signal lever to make a right turn. No warning lights illuminated. Additionally, upon depressing the turn signal lever to make a left turn, the left turn signal indicator light failed to illuminate. The contact stated that the failure progressed. While driving at various speeds, the brake lights failed to illuminate when the brake pedal was depressed. The vehicle was taken to an independent mechanic, where it was diagnosed that the wiring harness needed to be replaced. The vehicle was repaired. The contact associated the failure with NHTSA Campaign Number: 25V893000 (Trailer Hitches); however, the VIN was not included in the recall. The dealer and the manufacturer were notified of the failure, and a case was filed. The failure mileage was approximately 69,000.

The contact owns a 2022 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 25V893000(TRAILER HITCHES); however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer and local dealer was not contact made aware of the issue. The contact had not experienced the failure.

Trailing arm bushings on both sides appear to generate considerable noise indicating wear (has been since delivery but getting much worse over this year). Dealer's solution was to simply lubricate them. The owner manual says nothing of this, and I think this is a simple "go away" band-aid solution. Attempted to reach Hyundai corporate, who asked me to confirm with the dealer if that is proper. That seems like a question for engineering, not the dealer who applied the band-aid fix. It is apparent that the bushings they affixed to the vehicle are defective and could possibly cause larger issues down the line -- far enough down the road when Hyundai can claim they are a wear item and need to be replaced.

The car has been erratic in its performance since purchase. The car has a continuous issue with the suspension, electronic system, and brakes. I have reached out to Hyundai manufacturer on numerous occasion regarding the car and no one is addressing my concerns. The car drives so erratic and unpredictable that I am fearful that someone will be injured or worst. Attached is a photo of the entire system going offline, which occurs all the time, and because the whole care is computerized this poses a safety risk for me and others on the road. When the car goes offline, I no longer have control of the vehicle and all mechanical systems are down. Please help me to get this issue resolved before someone gets hurt. This is the second submission in regard to this car. 5nmjfcae4nh015882

Yesterday used front passenger side seatbelt and it worked fine. Today it did not work at all, seatbelt does not latch.

Had my car scanned it said air control unit. With that light on if I have a collision my ai bags won't deploy and my safety belts will not lock.

The contact owns a 2022 Hyundai Tucson. The contact stated that while parked for approximately an hour and the front driver seat unoccupied, the contact's granddaughter climbed into the front seat from the rear to sit with the front passenger occupant and accidentally depressed the drive (D) button and the vehicle began rolling forward. The vehicle crashed into another parked vehicle. There were no injuries and no police report filed. Additionally, the contact stated that she attempted to switch to each gear and the vehicle's brake did not need to be applied to shift gears. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 28,000.

Purchased a new 2022 SUV Tucson on 5/22/21. While driving on a busy street 6/7/21 during work traffic the vehicle just cut off without warning. With horns blaring I managed to coast to the right blocking traffic leaving one lane open for moving traffic. Vehicle after a couple of tries would start but would not move when gear was placed in Drive or Reverse. Hyundai Roadside Assistance notified vehicle towed to closest Hyundai Dealership. This was dangerous vehicles were almost running into the back of my SUV while abruptly stopping. I exited the vehicle while waiting for the tow truck in fear of vehicle being hit placing myself and others at risk of an accident. Informed by Asst. Service Manager at Hyundai Dealership that no one was trained to work on the 2022 TUCSONs at the Dealership. As a Public Safety measure at least some employees at each dealership should be trained to work on all newly released vehicles before they are placed on the market. Notified on June 15, 2021 that the vehicle has a limp mode/ limp node problem. June 16, 2021 I was informed by Hyundai dealership that the 22 TUCSON has a mechanical defect, transmission fluid was leaking which now the Transmission needs to be replaced. The newly purchased vehicle currently has only around 370 miles on it. I thought vehicles go through an inspection before leaving factory and after they reach the dealership before being sold. This I consider to be another safety issue anything can happen during transport. A repurchase/buyback from Hyundai wasn't approved. The vehicle is available for inspection upon request. Vehicle is ready and will be picked up from the dealership requesting an invoice of the repair work completed for viewing. This vehicle could have caused a catastrophic deadly occurrence

2022 HYUNDAI TUCSON. CONSUMER WRITES IN REGARD TO DEFECTIVE POWERLIFT GATE. THE CONSUMER STATED THE IT WOULD BE TOO DIFFICULT TO OPEN THE LIFT GATE IF TRAPPED INSIDE DURING AN EMERGENCY. THE CONSUMER STATED THE OCCUPANT SHOULD NOT NEED A "TOOL" TO RELEASE THE LIFT GATE.