2024 Ic Bus PB105 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2024 Ic Bus PB105, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Fuel system2100.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
The contact operates a 2024 IC BUS PB105. The contact stated that while attempting to refuel the vehicle, gasoline started spilling from the fuel filler neck, leaking fuel down the side of the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to determine the cause of the failure. The contact was informed that all the parts in the refueling system had been replaced except the fuel tank; however, the failure persisted. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure. The failure mileage was 1,100.
FUEL SPLASH BACK WHEN FILLING AND MULTIPLE EVAP CODES. IT IS THE FUEL CAP AND DRIVER NEEDS TO PUSH DOWN ON CAP TO SEAT IT, BUT IT CLICKS FOR BEING TIGHT BEFORE IT IS SEATED. IT WILL GIVE A FUEL SMELL ON THE BUS WHEN IT RUNS THE EVAP TEST THEN THE KIDS REPORT IT TO THE DRIVER AND THE CHECK ENGINE LIGHT COMES ON. WE HAVE MULTIPLE OTHERS THAT WILL SPLASH BACK FUEL WHEN FILLING. THESE ARE ALL GAS POWERED BUSES.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .