RoadVitals

2008 International 4200 Owner Complaints

Reports submitted to NHTSA by owners and drivers, shown in full

Data refreshed

Complaints on fileComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest May 29, 2014
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0
Filed in the last 12 monthsReports filed with NHTSA in the trailing 365 days. Recent volume reflects attention and vehicle age as much as anything else.
0
Reports on file since May 29, 2014

What this page shows

Our database holds 1 NHTSA owner-reported complaint for the 2008 International 4200. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Complaints, most recent first

Showing 1–1 of 1

ElectricalEngine
Filed May 29, 2014

ENGINE START HARNESS HAS A 40 AMP FUSE INSTALLED IN A 30 AMP RATED FUSE HOLDER. HOLDER WILL OVER HEAT (MELT) WITHOUT BLOWING FUSE, CAUSING THE METAL CONTACTS TO CHAR / LOOSEN,CAUSING AN OPEN RUN CIRCUIT, WHICH CAUSES THE ENGINE TO STALL. THIS CAN HAPPEN AT ANY TIME, IDLE, RUNNING IN STOP AND GO TRAFFIC AND AT FREEWAY SPEEDS. WHEN THIS OCCURS YOU LOOSE ALL ENGINE BASED ASSIST, ELECTRICAL, POWER STEERING,LIGHTING. NAVSTAR (INTERNATIONAL) HAS ADDRESSED THIS ISSUE ON SCHOOL BUS CHASSIS, BUT SAYS THE PROBLEM DOESN'T EXIST ON APPROXIMATELY 250 CHASSIS SOLD TO GULF STREAM MOTORHOMES FOR FITTING OF THE COACH. THE DEALER FIX IS TO REPLACE THE FAILING FUSE HOLDER WITH THE SAME FAILING PART UNTIL WARRANTY EXPIRES,THEN THEY RECOMMEND THE REPLACEMENT WIRING HARNESS PROVIDED TO SCHOOL BUS OWNERS AT NO COST, FOR A COST OF APPROX. $600 PARTS AND LABOR.THIS FUSE ASSEMBLY HAS BEEN REPLACED BY INTERNATIONAL 2 TIMES AND I HAVE REPLACED IT TWICE MYSELF. I ALWAYS CARRY SPARES AS I HAVE EXPERIENCED A FAILURE LAST JULY IN SOUTHERN ARIZONA IN 107 DEGREE HEAT. *TR

NHTSA ID
10594727
Incident
Jul 13, 2009

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Data sources

Data on this page last refreshed .