2008 International 4200 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2008 International 4200, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical150.0%
- Engine150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
ENGINE START HARNESS HAS A 40 AMP FUSE INSTALLED IN A 30 AMP RATED FUSE HOLDER. HOLDER WILL OVER HEAT (MELT) WITHOUT BLOWING FUSE, CAUSING THE METAL CONTACTS TO CHAR / LOOSEN,CAUSING AN OPEN RUN CIRCUIT, WHICH CAUSES THE ENGINE TO STALL. THIS CAN HAPPEN AT ANY TIME, IDLE, RUNNING IN STOP AND GO TRAFFIC AND AT FREEWAY SPEEDS. WHEN THIS OCCURS YOU LOOSE ALL ENGINE BASED ASSIST, ELECTRICAL, POWER STEERING,LIGHTING. NAVSTAR (INTERNATIONAL) HAS ADDRESSED THIS ISSUE ON SCHOOL BUS CHASSIS, BUT SAYS THE PROBLEM DOESN'T EXIST ON APPROXIMATELY 250 CHASSIS SOLD TO GULF STREAM MOTORHOMES FOR FITTING OF THE COACH. THE DEALER FIX IS TO REPLACE THE FAILING FUSE HOLDER WITH THE SAME FAILING PART UNTIL WARRANTY EXPIRES,THEN THEY RECOMMEND THE REPLACEMENT WIRING HARNESS PROVIDED TO SCHOOL BUS OWNERS AT NO COST, FOR A COST OF APPROX. $600 PARTS AND LABOR.THIS FUSE ASSEMBLY HAS BEEN REPLACED BY INTERNATIONAL 2 TIMES AND I HAVE REPLACED IT TWICE MYSELF. I ALWAYS CARRY SPARES AS I HAVE EXPERIENCED A FAILURE LAST JULY IN SOUTHERN ARIZONA IN 107 DEGREE HEAT. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
ENGINE START HARNESS HAS A 40 AMP FUSE INSTALLED IN A 30 AMP RATED FUSE HOLDER. HOLDER WILL OVER HEAT (MELT) WITHOUT BLOWING FUSE, CAUSING THE METAL CONTACTS TO CHAR / LOOSEN,CAUSING AN OPEN RUN CIRCUIT, WHICH CAUSES THE ENGINE TO STALL. THIS CAN HAPPEN AT ANY TIME, IDLE, RUNNING IN STOP AND GO TRAFFIC AND AT FREEWAY SPEEDS. WHEN THIS OCCURS YOU LOOSE ALL ENGINE BASED ASSIST, ELECTRICAL, POWER STEERING,LIGHTING. NAVSTAR (INTERNATIONAL) HAS ADDRESSED THIS ISSUE ON SCHOOL BUS CHASSIS, BUT SAYS THE PROBLEM DOESN'T EXIST ON APPROXIMATELY 250 CHASSIS SOLD TO GULF STREAM MOTORHOMES FOR FITTING OF THE COACH. THE DEALER FIX IS TO REPLACE THE FAILING FUSE HOLDER WITH THE SAME FAILING PART UNTIL WARRANTY EXPIRES,THEN THEY RECOMMEND THE REPLACEMENT WIRING HARNESS PROVIDED TO SCHOOL BUS OWNERS AT NO COST, FOR A COST OF APPROX. $600 PARTS AND LABOR.THIS FUSE ASSEMBLY HAS BEEN REPLACED BY INTERNATIONAL 2 TIMES AND I HAVE REPLACED IT TWICE MYSELF. I ALWAYS CARRY SPARES AS I HAVE EXPERIENCED A FAILURE LAST JULY IN SOUTHERN ARIZONA IN 107 DEGREE HEAT. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .