2002 Isuzu N-Series Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2002 Isuzu N-Series, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine266.7%
- Powertrain (other)133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
I PURCHASED A NEW 2002 ISUZU RODEO FROM FOX CHEVROLET ISUZU LOCATED AT 501 WASHINGTON BOULEVARD LAUREL, MARYLAND. IN 2004 THE DEALERSHIP CHANGED THEIR BUSINESS AND NAME TO FOX OF LAUREL BECAUSE I PURCHASED THE VEHICLE FROM THIS LOCATION I CONTINUED TAKING MY VEHICLE TO THEM FOR SERVICE. I QUESTIONED WHETHER THEY WOULD BE ABLE TO CONTINUE TO SERVICE MY VEHICLE ,AND WAS ASSURED THAT THEY COULD CONTINUE TO PROVIDE SERVICE TO MY VEHICLE, EVEN THOUGH THEY NO LONGER SOLD ISUZU CARS. ON JANUARY 23, 2007 I TOOK THE VEHICLE TO FOX OF LAUREL BECAUSE I SMELLED SOMETHING BURNING FROM THE ENGINE, AND THE HEAT WAS NOT FUNCTIONING PROPERLY. THE COST OF THE REPAIR WAS $872.71. I EXPERIENCED THE SAME HEAT PROBLEM AND RETURNED ON FEBRUARY 22, 2007 TO FOX OF LAUREL FOR REPAIRS AGAIN, THE PROBLEM WAS NOT REPAIRED, AND RETURNED THE VEHICLE ON MARCH 72007 . AT THIS TIME I WAS INFORMED AND GIVEN A COPY OF THE WARRANTY BY THE SERVICE DEPARTMENT OF FOX LAUREL THAT I NEED TO TAKE THE VEHICLE TO AN ISUZU DEALER BECAUSE THEY BELIEVED THE PROBLEM WAS COMING FROM THE ENGINE AND IT WAS UNDER WARRANTY. THE VEHICLE WAS TAKEN TO AN ISUZU DEALER , CASTLE ISUZU, AND IT WAS DETERMINED THAT THE VEHICLE HAD A CRACKED HEAD ENGINE. THE VEHICLE WAS STILL UNDER WARRANTY. SINCE THE VEHICLE WAS UNDER WARRANTY THE AMOUNT THAT I WAS CHARGED BY FOX OF LAUREL SHOULD BE REFUNDED. I HAVE MADE NUMEROUS CALLS TO THE PRESIDENT OF FOX OF LALIN GALLART, WHO WILL NOT RESPOND OR RETURN MY CALLS. I BELIEVE I WAS TAKEN ADVANTAGE OFF AND DISCRIMINATED AGAINST BECAUSE I AM SENIOR CITIZEN AND A FEMALE. HARD COPIES OF THE REPAIRS AND WORK ORDERS WERE GIVEN TO NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION, OFFICE OF DEFECTIVE INVESTIGATION . *AK
FAN BLADE FAILURE ON NPR ISUZU TK YR. 2000-2003 WE HAD 5 BLADES EXPLODE IN TKS. THE BLADE CRACKS THEN FLIES APART THIS IS VERY BAD SOMEBOBY WILL GET KILLED IF WORKING AROUND BLADE WHEN THEY COME APART.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
WE HAVE 6 ISUZU NPR LIGHT TRUCKS IN OUR FLEET. WE HAVE HAD THE SPIDER AND RING GEAR FAIL ON MULTIPLE OCCASIONS ON EACH VEHICLE. THIS IS DANGEROUS BECAUSE THE FAILURES COME COMPLETELY UNEXPECTEDLY ( NO WARNING) AND THE VEHICLE IS IMMEDIATELYU DISABLED WHEREEVER IT MIGHT BE-EVEN IN THE FAST LANE ON THE EXPRESSWAY. THE VEHICLE IMMEDIATELY LOOSES ALL POWER TO THE REAR AND CANNOT BE MOVED . THE COULD IMPEDE TRAFFIC ON THE EXPRESSWAY AND POTENTIALLY DISABLE THE VEHICLE IN THE MIDDLE OF THE HIGH SPEED TRAFFIC. WE HAVE HAD OVER 8 FAILURES OF EXACTLY THE SAME PART ON SEVERAL DIFFERENT IDENTICAL VEHICLES. THE VEHICLE WERE PURCHASES AT THE SAME TIME, HOWEVER IDENTICAL VEHICLE PURCHASES AT ANOTHER TIME DO NOT HAVE THIS FAULT. WE HAVE REPLACED EACH OF THESE PARTS AND THEY CONTINUE TO FAIL.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .