1991 Isuzu Rodeo Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1991 Isuzu Rodeo, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Transmission1016.7%
- Engine813.3%
- Brakes711.7%
- Electrical711.7%
- Powertrain (other)58.3%
- Fuel system46.7%
- Body & structure46.7%
- Seat belts46.7%
- Visibility35.0%
- Driver assistance35.0%
- Suspension23.3%
- Steering11.7%
- Other / unspecified11.7%
- Exterior lighting11.7%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
DT: VEHICLE WAS DESTROYED IN A FIRE. TRANSMISSION INDICATOR LIGHT CAME ON, AND DRIVER PULLED OVER AND SAW FLAMES COMING FROM UNDER THE HOOD. VEHICLE HAD A RECALL BUT CALLERS VEHICLE WAS NOT INVOLVED IN THE RECALL DUE TO VIN. ATTEMPTS WERE MADE TO CONTACT MANUFACTURER, BUT CALLER COULDN'T REACH ANYONE.*AK
WHILE DRIVING AT 55 MPH ON HIGHWAY NOTICED SMOKE COMING THROUGH THE DRIVER'S SIDE. VEHICLE CAUGHT ON FIRE DUE TO TRANSMISSION FAILURE AFTER RECALL REPAIRS. RECALL 91V118000. *AK
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
COMING OFF OF THE INTWERSTATE, THE EMGINE COUGHT ON FIRE FOR NO APPARENT REASON. A FIRE TRUCK HAD TO PUT THE FLAMES OUT. THE CAR WAS TOTALED.
POSSIBLE ENGINE FAILURE RESULTED IN VEHICLE FIRE. (OHIO TRAFFIC CRASH REPORT) *MJS
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
AT LEAST SIX (6) TIMES THE ANTI-LOCK AND BRAKE LIGHTS STAYS ON. IT GIVES A FALSE INDICATION THAT THERE IS A BRAKE PROBLEM, WHEN IN FACT THE BRAKES ARE FINE. IN EVERY CASE THE PROBLEM IS THE SPEED SENSOR MUST BE REPLACED BECAUSE IT SHORTED OUT. IT BECOMES A VERY COSTLY BILL TO REPLACE THIS SENSOR EVERY OTHER YEAR. *JB
ABS BRAKES FAILED 3 TIMES; ALSO ABS LIGHT GOES ON/OFF. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
COMING OFF OF THE INTWERSTATE, THE EMGINE COUGHT ON FIRE FOR NO APPARENT REASON. A FIRE TRUCK HAD TO PUT THE FLAMES OUT. THE CAR WAS TOTALED.
WHILE DRIVING AT 30 MPH SMOKE STARTED COMING FROM LEFT FRONT WHEEL WELL. DRIVER PULLED OVER, AND WITHIN MINUTES VEHICLE WAS ENGULFED BY FLAMES. VEHICLE WAS TOTALED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
LEFT LATCH ON THE CONVERTIBLE TOP HAD SNAPPED LOOSE.
REPLACED LEAKING REAR AXLE SEALS/BEARINGS. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
COMING OFF OF THE INTWERSTATE, THE EMGINE COUGHT ON FIRE FOR NO APPARENT REASON. A FIRE TRUCK HAD TO PUT THE FLAMES OUT. THE CAR WAS TOTALED.
POSSIBLE LEAKING FUEL LINE RESULTING IN VEHICLE FIRE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
TL*THE CONTACT OWNS A 1991 ISUZU RODEO. THE CONTACT WENT TO GET AN EXHAUST AT A MUFFLER SHOP AND WAS INFORMED THAT THE VEHICLE'S FRAME WAS RUSTED. SHE NOTICED THAT THE TUBULAR STEP USED TO ENTER THE VEHICLE WAS RUSTED AND FELL OFF. THE MANUFACTURER HAS NOT YET BEEN NOTIFIED. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS APPROXIMATELY 110,000 AND FAILURE MILEAGE WAS APPROXIMATELY 109,000.
LEFT LATCH ON THE CONVERTIBLE TOP HAD SNAPPED LOOSE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
DRIVERS SEAT BELT POPS OUT OF LOCKING MECHANISM AT WILL. ALSO,SEAT BELT HAS BEEN RELEASED FROM LOCKING MECHANISM BY DRIVER'S ELBOW UNINTENTIONALLY WHILE DRIVING. *AK
CONSUMER RECEIVED RECALL 95V103009 NOTICE CONCERNING SEAT BELT BUCKLE ASSEMBLY FAILURE. AFTER RECALL REPAIRS WERE DONE SEAT BELT BECAME UNDONE WHILE DRIVING ON BOTH PASSENGER AND DRIVER SIDES. VEHICLE WAS TAKEN BACK TO THE DEALER, WHO INSTALLED A GUIDE KIT, BUT PROBLEM RECURRED. *AK DEALER ONLY INSTALLED A GUIDE KIT INSTEAD OF REPLACING THE SEAT BELT BUCKLE ASSEMBLY, WHICH LED TO THE SEAT BELT CONTINUE TO UNBUCKLE BY THEMSELVES. *LA
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
THE "RUSTED SHUT" REAR DOOR LOCKS AND REAR DOOR WINDOW ASSEMBLIES ARE/WERE A PROBLEM KNOWN TO AND ACKNOWLEDGED BY A SERVICE TECHNICIAN AT AN ISUZU DEALER YET THE NATIONAL CUSTOMER RELATIONS/SERVICE MANAGER DENIED THE PROBLEM EXISTED AND "BLAMED THE MESSENGER" SAYING THAT I SHOULD HAVE KNOWN ENOUGH TO HAVE THE CRANK AND LOCK ASSEMBLIES REMOVED AND LUBRICATED ONCE EVERY YEAR OR TWO BECAUSE I LIVE IN A COLD, WET STATE. ADDITIONALLY, THE FAILURES TO BOTH DOORS FOR BOTH THE LOCK AND THE WINDOW CRANK ASSEMBLIES OCCURRED NOT JUST ONCE BUT TWICE. I DON'T KNOW IF THIS AGENCY CAN DO ANYTHING ABOUT THIS DEFECT BUT I FEEL BETTER HAVING REPORTED IT AND THE INCREDIBLY OFFENSIVE AND BAD FAITH BEHAVIOR OF ISUZU MOTORS. *AK
LEFT LATCH ON THE CONVERTIBLE TOP HAD SNAPPED LOOSE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
WHILE DRIVING AT 60 MPH GAS PEDAL GOT STUCK DUE TO THE RUBBER THAT IS AROUND THE GAS PEDAL. *AK
LEFT LATCH ON THE CONVERTIBLE TOP HAD SNAPPED LOOSE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
WHILE DODGOING AN OBSTICLEIN THE ROAD, HIT BRAKES/TURNED WHEELS AND VEHICLE ROLLED OVER. *AK
WARNING LABEL STATING "SUDDEN TURNS MAY CAUSE VEHICLE TO FLIP OVER "IS VERY SMALL/HIDDEN AS A RESULT DRIVER MADE A SUDDEN TURN AND VEHICLE FLIPPED OVER, RESULTING IN TWO INJURIES.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
LEFT LATCH ON THE CONVERTIBLE TOP HAD SNAPPED LOOSE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
LEFT LATCH ON THE CONVERTIBLE TOP HAD SNAPPED LOOSE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
TACHOMETER WIRING SHORTED. *SD
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .