2002 Isuzu Trooper

TL* THE CONTACT OWNS A 2002 ISUZU TROOPER EQUIPPED WITH BF GOODRICH MUD TERRAIN T/A KM2 TIRES, SIZE: LT265/75R16. WHILE DRIVING BETWEEN 55-65 MPH, THREE OF THE TIRES EXPERIENCED TREAD SEPARATION. THERE WERE MOMENTARY VIBRATIONS JUST BEFORE THE FAILURES. THE FAILURES OCCURRED ON THREE OCCASIONS. THE VEHICLE WAS TAKEN TO A TIRE DEALER WHERE THE FRONT DRIVER SIDE AND REAR DRIVER AND PASSENGER SIDE TIRES WERE DEEMED DEFECTIVE. THE TIRES WERE REPLACED. THE DEFECTIVE TIRES WERE REPLACEMENT TIRES WITH ONLY 12,000 MILES ON THEM PRIOR TO THE FAILURES. THE VEHICLE FAILURE MILEAGE WAS 49,000 AND THE TIRE FAILURE MILEAGE WAS 12,000. THE VIN AND DOT NUMBER WERE NOT AVAILABLE. *TR

NHTSA ID

10929461

Incident

Jun 12, 2012

Mileage

49,000 mi

I WAS DRIVING ABOUT 35 MPH ON A RURAL ROAD AND I NOTICED THAT UPON GIVING SOME GAS THE VEHICLE DID NOT RESPOND AT ALL. THEN I NOTICED THAT ALL MY INSTRUMENT PANEL LIGHTS WERE OUT....EVERYTHING GONE. I APPLIED THE BRAKES AND WITH DIFFICULTY IN STEERING (THERE WAS NO POWER), I PULLED TO STOP AT THE SIDE OF THE ROAD. I THEN PUT THE VEHICLE INTO PARK AND TURNED THE IGNITION KEY OFF, THEN RESTARTED THE VEHICLE AND DROVE AWAY. THIS IS THE ONLY TIME THIS HAPPENED (LAST WEEK).....A COMPLETE LOSS OF POWER. I KNOW ISUZU SHARES PARTS WITH GM (E.G. MY TRANSMISSION IS GM). I HOPE THIS IS NOT AN EXAMPLE OF THAT GM IGNITION SWITCH PROBLEM.....BUT CERTAINLY HAS THE EXACT SAME SYMPTOMS OF IT. BUT IT IS VERY SCARY LOOSING COMPLETE POWER LIKE THAT. *TR

NHTSA ID

10578533

Incident

Apr 4, 2014

Mileage

81,897 mi

ENGINE IN MY 2002 ISUZU TROOPER BURNED UP THE MAIN ROD BEARING IN PISTON ONE DUE TO INSUFFICIENT OIL PRESSURE. ENGINE HAD TO BE REPLACED. TRUCK HAS 79K MILES ON IT AND WAS OUT OF WARRANTY. ISUZU OF NORTH AMERICA STATED NOTHING WOULD BE DONE VIA THE MANUFACTURER. I REPLACED THE ENGINE MYSELF AT A COST OF $4800. *TR

NHTSA ID

10192928

Incident

May 18, 2007

Mileage

79,000 mi

EXCESSIVE OIL CONSUMPTION. 1 QT. EVERY 600 MILES OR SO. 5 QTS BETWEEN OIL CHANGES (3000 MILES!) *JB

NHTSA ID

10186275

Incident

Mar 23, 2007

I TOOK MY 2002 ISUZU TROOPER LTD. TO THE DEALER (FITZGERALD DODGE ISUZU, ROCKVILLE, MARYLAND, COMPLAINING OF A GROWLING NOISE. WHILE IT WAS MIS-DIAGNOSED, THE DEALER INDICATED THAT THE UNDERPLATING ON THE CAR WAS SUFFERING FROM FAULTY WELDS, AND THAT IF I DIDN'T HAVE IT REMOVED IT WOULD FALL OFF WHILE I WAS DRIVING. I HAD TO PAY SEVERAL HUNDRED DOLLARS FOR THIS TO BE PERFORMED. I NOW HAVE NO UNDERPLATING TO PROTECT THE CAR. IT SEEMS TO ME THIS IS A MANUFACTURERS DEFECT, AND THE OWNER SHOULD NOT BE OBLIGATED TO REMOVE PORTIONS OF HER AUTOMOBILE TO CORRECT FAULTY MANUFACTURE, AND BE SUBJECTED TO RISK OF POTENTIAL DEATH OR INJURY TO HERSELF OR OTHERS ON THE ROAD. THE TROOPER ONLY HAS 45,000 MILES ON IT AND IS JUST OVER 3 YEARS OLD. *JB

NHTSA ID

10152603

Incident

Mar 6, 2005

Mileage

45,000 mi

DT: CONSUMER OWNS A 2002 ISUZU TROOPER. CONSUMER SAYS THAT WHEN PUTTING THE VEHICLE IN PARK THE INDICATOR POSITION WILL READ PARK, BUT THE VEHICLE WILL BE IN A NEUTRAL POSITION. THE VEHICLE CAN ROLE FREELY FORWARD OR BACKWARDS. THIS PROBLEM HAS BEEN GOING ON FOR ABOUT A YEAR. VEHICLE HAD BEEN TO DEALER 3 TIMES, BUT COULD NOT DO ANYTHING TO FIX THE PROBLEM. SHE WAS TOLD THEY COULD NOT DUPLICATE THE PROBLEM. CALLED WHEN VEHICLE WAS AT CONSUMER'S HOUSE AND PROBLEM WAS RECURRING. DEALER SENT SOMEONE OUT BUT STILL NOTHING WAS DONE ABOUT PROBLEM, WHICH DID NOT HAPPEN ALL THE TIME, AND DID NOT SEEM TO FOLLOW ANY PATTERN. THE MANUFACTURER WAS CONTACTED TWICE, BUT PROBLEM RECURRED. THE MANUFACTURER WANTED VEHICLE TO BE TOWED TO A REPAIR SHOP FOR FURTHER INSPECTION. *AK

NHTSA ID

10133105

Incident

Jul 2, 2005

Mileage

38,000 mi

WHEN THE CONSUMER APPROACHED A TRAIN TRACK, ANOTHER VEHICLE BEGAN TO APPROACH FROM THE OTHER DIRECTION. THE CONSUMER STOPPED AND SHIFTED FROM DRIVE TO REVERSE TO CLEAR UP THE ROAD WAY. THE TRANSMISSION JUMPED TO PARK AND LOCKED PREVENTING THE VEHICLE FROM MOVING. A TRAIN APPROACHED AND STRUCK THE VEHICLE. PLEASE PROVIDE FURTHER INFORMATION. *JB

NHTSA ID

10082030

Incident

Jul 15, 2004

WHEN CHANGING GEARS AND WITHOUT WARNING VEHICLE WOULD ACCELERATE. DEALER HAS BEEN NOTIFIED. *AK

NHTSA ID

10033968

Incident

Aug 5, 2003

This bulletin outlines the procedures for using the Alpine Exchange Program (the "Exchange Program"). The Exchange Program must be used when any Alpine radio or other component covered by this bulletin is repaired under warranty and may also be used for radio and component repairs not covered under warranty. Contact Alpine directly for pricing and payment methods applicable to radio and component repairs not covered under warranty.

Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to improve dealer efficiency when submitting Parts Warranty claims. We strongly recommend dealers follow these procedures in order to avoid delays in Parts Warranty claim payments and/or claim chargeback. This bulletin was revised to add a Parts Warranty Form

Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to improve dealer efficiency when submitting Parts Warranty claims. We strongly recommend dealers follow these procedures in order to avoid delays in Parts Warranty claim payments and/or claim chargeback.

The Isuzu Commercial Truck of America (ICTA) Service Technical Assistance Center (TAC) provides diagnostic support to Isuzu dealer technicians repairing Isuzu vehicles in and out of vehicle warranty. A TAC case number will be issued solely for information tracking purposes and future contact reference.

The following is a list of the Isuzu-recommended Threebond product part numbers identified in the various Isuzu Workshop Manuals and bulletins. If a Threebond product is unavailable, we recommend that you utilize the chart below to find equivalent of similar products (when available) from Loctite and Permatex.

This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related components. That any of the listed DTC's may set with or without poor engine performance.