RoadVitals

2004 Itasca Spirit Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
5
Newest Nov 28, 2006
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

5 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

06V456000

EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

Nov 28, 2006
1,491 units potentially affected
The defect: ON CERTAIN MOTOR HOMES EQUIPPED WITH FRONT OVERHEAD TELEVISIONS, INCORRECT FASTENERS WERE USED TO SECURE THE TELEVISION LOCATED IN THE FRONT OVERHEAD AREA OF THE MOTOR HOME.
The risk: THE TELEVISION MAY BECOME LOOSE AND POSSIBLY FALL FROM ITS POSITION WHICH HAS THE POTENTIAL TO IMPACT THE DRIVER OR PASSENGERS, RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.
The remedy: DEALERS WILL INSPECT THE VEHICLE TO ASSURE THE CORRECT FASTENERS (BOLTS) WERE USED IN THE TV RETENTION STRAP. THE RECALL BEGAN ON DECEMBER 15, 2006. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.
WINNEBAGO INDUSTRIES, INC.Manufacturer number 103View on NHTSA.gov
04V516000

ENGINE AND ENGINE COOLING

Oct 20, 2004
5,125 units potentially affected
The defect: ON MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.
The risk: THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.
The remedy: FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR WINNEBAGO AT 641-585-3535.
WINNEBAGO INDUSTRIES, INC.Manufacturer number 04S23View on NHTSA.gov
04V512000

ELECTRICAL SYSTEM:WIRING

Oct 20, 2004
3,950 units potentially affected
The defect: ON MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS AND EQUIPPED WITH GAS ENGINES, A DIODE IN THE ANTI-LOCK BRAKING SYSTEM (ABS) MODULE MAY EXPERIENCE AN ELECTRICAL SHORT.
The risk: THE ELECTRICAL SHORT MAY CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, OR THE MODULE MAY OVERHEAT RESULTING IN A BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS BEING DRIVEN OR UNATTENDED.
The remedy: FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSTALL A NEW FUSE IN THE ABS CIRCUIT AND INSTALL A HEAT SHIELD OVER THE ABS MODULE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR WINNEBAGO AT 641-585-3535.
WINNEBAGO INDUSTRIES, INC.Manufacturer number 04S22View on NHTSA.gov
04V358000

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Jul 19, 2004
5,645 units potentially affected
The defect: ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, MODELS MR1031WB, MR1032BB, MR1033SB, MR1351WB, AND MR1352BB, THE MICROWAVES WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.
The risk: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.
The remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 1-800-932-3837 OR WINNEBAGO AT 1-641-585-3535.
WINNEBAGO INDUSTRIES, INC.View on NHTSA.gov
03V405000

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Oct 16, 2003
15,337 units potentially affected
The defect: ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.
The risk: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.
The remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR WINNEBAGO AT 641-585-3535.
WINNEBAGO INDUSTRIES, INC.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .