2021 Jeep Gladiator Fuel system Problems

Truck failed to find gear shuddered lost speed in traffic while going up a hill. Limp mode was initiated. This is a known manufacturers defect with a tsb applied against the known issue. Issue is widespread when researched but not made known by the manufacturer of the truck. Dealership refusing repair under goodwill due to truck being out of mileage by 5000miles. Symptoms started prior to exiting warranty but due to no communication by dealership or manufacturer unit was not brought in for repair prior. Repeat this is a known defect that is being ignored by manufacturer.

NHTSA ID

11756306

Incident

Aug 4, 2026

The vehicle was bought in CA and hasn't had any issues till about after 3-4 yrs later. 1) Adaptive cruise control / emergency braking system / forward collision notification will occassionally state "not availble/unavailable" or "visibility" is not available and to clean windshield, but the windshield is not dirty or obstructing the camera. 2) The fuel emission system has had several diagnostic codes referring to the gas gap or fuel sensors. Vehicle is boggs down/loses power and starts ideling roughly and acts like it wants to shutdown and has shutdown. I've had to get vehicle towed twice for this issue. Replaced gas gap and still had issues. Then they went away for a few months, but now I am getting a diagnotic code stating that the fuel tank gas sensor is causing the check engine light.

NHTSA ID

11749747

Incident

Jun 8, 2026

7/5/2026. Driving home on the highway the Jeep went into limp mode and shut down. The Fault flashed on the screen for about 15 seconds (Throttle Body Falut) Problem is there is no warning when it happens. It just shuts down. This creates a "REALLY SERIOUS HAZZARD" This time it did register a fault on the computer and we were able to pull it off the reader. The Fault reads as follows: POOAF In looking it up on this is a manufacuring problem that can be caused by a little dirt, Can be caused by hot weather. THIS IS NOT SAFE! MY I REPEAT, THIS IS NOT SAFE! This should be recalled and Fixed as I am sure this shutting down on the Hiways and Interstates have killed people that were not able to deal with a situation. Please force a recall befor lives are lost!

NHTSA ID

11748534

Incident

Jul 5, 2026

Every time I fill up my gas tank, the fuel doesn’t shut off in time from the pump and gas comes backward up the filler neck, onto the side of my jeep.

NHTSA ID

11742573

Incident

Jun 7, 2026

Bought this vehicle with 27,000 miles on it. While driving on the interstate with heavy traffic. (Doing Highway speeds) All the sudden the power plant shuts down. It happend at 27,500 miles and happened again at 37,000 miles. It has done it to me four times now. Twice with heavy semi trucks bearing down on me and my family. This was a very UNSAFE situation. The Fault on the screen comes up momentarily and states "Capture Throttle Body Fault." and all power is lost to the throttle. SERIOUS SAFTETY ISSUE. as loosing power on the interstate at 75 miles an hour. I believe JEEP the company should fix this issue as I know for a fact I am not the only individual experincing this problem! Please feel free to reach out to me if you need further information. There was not a crash,fire or injury due to the ability to get off the road and into the apron of the interstate. In a higher traffic location this could be catistrophic. PLEASE PLEASE PLEASE talk this issue seriously as I am convinced this has caused others to wreak. Thanks and have a great day

NHTSA ID

11725933

Incident

Mar 20, 2026

The contact owns a 2021 Jeep Gladiator. The contact stated that while attempting to start the vehicle, the vehicle would hesitate to start. There were no warning lights illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the fuel pump, the fuel injectors, and the fuel filter, were faulty and needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number : 23V263000 (Fuel System, Diesel). The manufacturer was notified of the failure. The failure mileage was approximately 40,000.

NHTSA ID

11662417

Incident

Apr 14, 2025

Mileage

40,000 mi

Multiple cylinders miss fire, Camshaft 1 position slow responding. cylinder2, 4, and 6 repeatedly misfire. Passenger side engine is making excessive noise. This is the information given to me by Van Horn jeep mechanic. also confirmed by advanced auto. Advanced auto stated this is the 3rd jeep they have had in their shop recently to replace a faulty Camshaft. My Jeep only has 66024 hwy miles. Vin [XXX] (2021Jeep Gladiator) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11660862

Incident

May 12, 2025

The contact owns a 2021 Jeep Gladiator. The contact stated while driving 65 MPH, the DEF tank message was displayed, notifying the contact to “See the Dealer”. Additionally, there was a message indicating 200 miles were remaining before the vehicle would fail to start. The vehicle was taken to the local dealer, where it was diagnosed and determined that the tank and sensor needed to be replaced; however, the parts were on backorder. The vehicle was not repaired. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 165.

NHTSA ID

11626150

Incident

Nov 15, 2024

Mileage

165 mi

Mopar recall Z96 posted October, 13th 2022 for high pressure fuel pump. My local dealership stated parts for replacement of the high pressure fuel pump did not become available until November of 2023. They inspected my vehicle November 21st, 2023 and determined the high pressure fuel pump was to be replaced under mopar recall Z96. Dealership ordered parts at that time. On to March 4th, 2024. I reach out to local dealerships service and parts departments. Not all parts had been received and there was no understanding of when the rest of the necessary parts would arrive. May 7th, 2024. It is now nearly 1 year and 7 months since this recall was released and nearing 6 months since my local dealership stated they ordered parts to replace the fuel pump. My local dealership continues to have no understanding or intention of securing the remaining parts necessary to complete this recall. This amount of time is unreasonable for a part that if it fails will cause loss of engine power and may cause a fatal crash.

NHTSA ID

11587465

Incident

Nov 21, 2023

Jeep stoped running Towed to dealership Diagnostic shows recall fuel pump failure . Z 96/NHTSA-22V-767 I have dealership RO# 68945 Case # 88652766

NHTSA ID

11567731

Incident

Jan 16, 2024

The contact owns a 2021 Jeep Gladiator. The contact received notification of NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11559196

Incident

Dec 8, 2023

The contact owns a 2021 Jeep Gladiator. The contact received notification of NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11559195

Incident

Dec 8, 2023

The contact owns a 2021 Jeep Gladiator. The contact received notification of NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. While the contact was driving at approximately 35 MPH, the vehicle made an abnormal sound in the engine compartment and then stalled. The vehicle was towed to a dealer and diagnosed with fuel pump failure. The failure mileage was approximately 46,000. Parts distribution disconnect.

NHTSA ID

11551326

Incident

Aug 28, 2023

Mileage

46,000 mi

The contact owns a 2021 Jeep Gladiator. The contact received notification of NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was not yet available. An undisclosed dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that on two separate occasions while driving approximately 60-75 MPH, the vehicle inadvertently decelerated while the accelerator pedal was depressed. No warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed that the high-pressure fuel pump had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was offered to replace the failure part with a temporary repair however, the contact declined due to the concern for his safety. The failure mileage was approximately 14,000. VIN tool confirms parts not available.

NHTSA ID

11541409

Incident

Jul 19, 2023

Mileage

14,000 mi

The contact owns a 2021 Jeep Gladiator. The contact stated while driving approximately 55 MPH, the vehicle stalled. The contact depressed the accelerator pedal and the vehicle failed to respond. The contact stated that the power steering and brakes were still operational. The contact stated no warning light was illuminated. The contact coasted the vehicle off the roadway and attempted to restart the vehicle; however, the vehicle failed to restart. The contact had the vehicle towed to a local dealer, where it was diagnosed and determined that the fuel pump had failed and needed to be replaced. The vehicle had been repaired. The contact had researched online and related the failure to NHTSA Campaign Number: 23V263000 (Fuel System, Diesel). The failure mileage was approximately 50,000.

NHTSA ID

11540578

Incident

Aug 5, 2023

Mileage

50,000 mi

The contact owns a 2021 Jeep Gladiator. The contact received notification of NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11536139

Incident

Aug 2, 2023

I am not able to trade in my jeep because of this recall.

NHTSA ID

11529006

Incident

Jun 26, 2023

Fuel pump is on safety recall with no fix in over a year

NHTSA ID

11527104

Incident

Jun 14, 2023

The contact owns a 2021 Jeep Gladiator. The contact received notification of NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11525012

Incident

Oct 13, 2022

The contact owns a 2021 Jeep Gladiator. The contact received notification of NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that parts were not available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11516047

Incident

Oct 13, 2022

The contact owns a 2021 Jeep Gladiator. The contact received notification of NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11503760

Incident

Oct 13, 2022

The contact owns a 2021 Jeep Gladiator. The contact stated while driving at various speeds, she noticed an abnormal clicking sound coming from the rear of the vehicle and the vehicle failed to accelerate as needed. The contact also stated that she had received several messages from Uconnect indicating a Power System failure. The vehicle was taken to the dealer where it was diagnosed that the failure was associated with the parking brake due to unknown components being detached and hanging underneath the vehicle. The dealer repaired the parking brake; however, the failure persisted. The vehicle was not repaired. Additionally, the contact received notification of NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine). The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure. The failure mileage was approximately 26,000. VIN tool confirms parts not available.

NHTSA ID

11496144

Incident

Mar 5, 2022

Mileage

26,000 mi

The contact owns a 2021 Jeep Gladiator. The contact received notification of NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was unavailable. The contact stated while driving approximately 60 MPH, the vehicle started losing motive power, and then after a minute the vehicle functioned normally. The contact stated that there was no warning light illuminated. The contact stated that the failure was intermittent. The dealer was contacted to have the vehicle diagnosed and repaired; however, the dealer advised that the failure could be related to NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part was not yet available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 21,000. VIN tool confirms parts not available.

NHTSA ID

11490313

Incident

Oct 13, 2022

Mileage

21,000 mi

Vehicle derates power when ambient temps are 85* F and up while towing my camp (which is far below the max tow rating) During a couple of these derates I was in areas where the speed limit was 65 and 75 mph, my max obtainable speed was 35mph. I heavy truck traffic i feel that was in danger and a hazard in the road. This vehicle is rated to tow far more than the loads it is actually capable of towing in higher temperatures. I have seen my oil temps rise to 265* F on multiple occasions and it seems this is around the temperature that the vehicle starts to derate. It has been my observation that the cooling system is under sized and in turn puts occupants of the vehicle at risk.

NHTSA ID

11467416

Incident

May 30, 2022

When operating the vehicle under heavier loads (5%+ grades, towing even light trailers, higher highway speeds) vehicle loses power limiting speed to 15-50mph depending on how hot the water or oil temperature is. I have had this issue in ambient temperatures as low as 31°F while towing 4000lb up a steep incline, but will absolutely overheat if ambient temp is over 100°F. Vehicle must be left running during a fuel stop or heat soak caused by the vehicle is not running will prevent me from merging back on the highway at a safe speed....max speed is 50mph until the engine oil cools off. Air conditioner use as expected makes the problem worse. There are many threads going on the Jeep internet forums with many diesel equipped Jeep Wranglers and Gladiators having the same issues, so I know these aren't isolated incidents from my vehicle alone. If you were to search "Ecodiesel power derating as temps rise" on Google, you would see some discussion. Engine fan runs at full speed, coolant is full, and radiator/grill is clean/free of debris. I have owned this vehicle since new and have operated in many types of conditions/loads over the past 14 months 23,000 miles from 9°-126°F. The first time I had the issue was late May of 2021 (At approx 5,000 miles) and it has happened no less than 20 times since then. The only visual alarm is when coolant temp reaches 248° and the vehicle speed drops to 10mph. The gauge does not read linear........Meaning the vehicle is almost already overheated by the gauge shows the temp is rising. I can only assume the is intentionally programmed into the code by the vehicle manufacturer to make the operator feel like the high temps are normal. I have not had the vehicle inspected by the local dealer because in the past they were never able to duplicate the conditions in my opinion due to laziness or incompetence. I own an auto repair shop and know the problem to be an undersized cooling system which Chrysler does not have an approved fix for.

NHTSA ID

11462120

Incident

Apr 24, 2022