2011 Jeep Patriot Fuel system Problems

The contact owns a 2011 Jeep Patriot. The contact stated that while driving at an undisclosed speed, the vehicle stalled. While refueling, the fuel tank failed to allow all with fuel. The contact had to restart the vehicle and add more fuel several times. There were no warning lights illuminated. The contact called the local dealer where a service appointment was scheduled. The vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic who informed the contact that the failure was due to a faulty rollover valve and the fuel tank needed to be replaced. The manufacturer was contacted but provided no assistance. The approximate failure mileage was 115,000.

NHTSA ID

11488352

Incident

Sep 1, 2022

Mileage

115,000 mi

While driving in heavy traffic, there was a Red light and attempted to slow the vehicle. The engine started to jerk forward and the RPMs were increasing without my foot on the accelerator! My foot was on the brake! I was able to turn into a gas station to get to a safer place to park the vehicle. While attempting to park in a parking space the vehicle continued to accelerate by itself, again my foot was applied to the brake pedal. I was literally fighting to stop the vehicle and almost ran into the barrier where customers were walking. Once turning off the vehicle and restarting the engine, it was operating correctly while I’m reverse. I then shifted into drive, and the vehicle lunged forward and the engine accelerated by itself. It drove up to 45 miles per hour without my foot on the accelerator and foot resting on the brake pedal. A complete stop was a fight, as soon as there was any brake pedal release the engine lunged forward.

NHTSA ID

11476448

Incident

Jul 27, 2022

After filling up with gas, the vehicle sputtered, stalled and the steering locked up.

NHTSA ID

11455281

Incident

Mar 4, 2022

After filling up the gas tank, when I drive away, the car jerks and loses power for a minute with in a mile of leaving the gas station. Nj pumps gas for me so the tank is not overfilled. My power steering goes down for a moment as my car sputters. Then after a minute it drives great until the next time I fill up my tank. Forums have stated it is a bad charcoal cannister. Many jeep patriot owners have complained about this. It is very unsafe when this happens on the road. I fear driving my toddler now.

NHTSA ID

11453145

Incident

Feb 20, 2022

Every single time after putting gas, my car wont go further than 10 feet without turning off/stalling. Some times it wont turn back on and takes several tries to get it back up and running. I feel at risk for my life and those in the car with me because not only does it stall but my steering wheel locks everytime and I am unable to move or do anything. God forbid one day it stops and a car is headed in my direction I will be stuck in place. I have read online multiple people have had this issue but no one can seem to find a definitive solution. This started to happen around winter of 2019/spring 2020 and has been happening ever since. The date I recorded below is the most recent time it's occurred.

NHTSA ID

11433149

Incident

Sep 14, 2021

Filled gas tank and restarted Jeep. Pulled away from gas station into traffic and the jeep sputtered and died. Restarted and spit and sputtered and died again. After several tries and waiting, car started. Idled roughly for a few minutes then cleared up. No problems or indication of any problems until had to get gas again. Another incident while filling gas tank, pump continuously cut off and had to pump extremely slow to fill tank. Again, sputter and spat after starting. At times as the gas is going in it sounds like a gulping sound after I stop pumping gas. These problems happen every time have to get gas. It is dangerous and very frustrating. This has been going on way too long. I took it to the shop and the mechanic says the roll over valve inside the gas tank is stuck and I must have a new gas tank installed at $1500. I would welcome you to inspect this vehicle. There have been no warning lamps, signals, messages, or other indicator of a problem with the vehicle.

NHTSA ID

11419585

Incident

Dec 8, 2020

WHEN FUELING AT A GAS STATION AND THE VEHICLE IS OFF I CAN ONLY PUT ROUGHLY 25 CENTS OF FUEL IN AT A TIME.

NHTSA ID

11395608

Incident

Feb 10, 2021

Mileage

175,000 mi

WHEN FILLING THE FUEL TANK TO NORMAL FULL LEVEL, THE VEHICLE WILL STALL AND RUN AT VERY LOW RAM. THIS ONLY HAPPENS RIGHT AFTER FILLING THE TANK TO FULL AND STARTING TO ACCELERATE AT A NORMAL RATE. AFTER DOING RESEARCH, THIS SEEMS TO BE A VERY COMMON ISSUE ACROSS MANY JEEP VEHICLES.

NHTSA ID

11387777

Incident

Jan 2, 2021

Mileage

128,000 mi

JEEP STALLS AFTER REFUELING. ANYTIME YOU FULLY FILL THE TANK THIS IS AN ISSUE. WAS VERY STARTLING THE FIRST COUPLE OF TIMES IT HAPPENED. I NOW EXPECT THIS TO HAPPEN, BUT FOR OTHER PEOPLE IT COULD BE AN EXTREME HAZARD. IT HAPPENS WITH THE VEHICLE STATIONARY OR IN MOTION. SUBSIDES AFTER SECOND OR THIRD RESTART...OR IF YOU LET IT SIT WITH THE GAS CAP OPEN FOR A MINUTE OR SO, THESE SEEMS TO HELP.

NHTSA ID

11384394

Incident

Sep 15, 2020

Mileage

105,000 mi

THE PROBLEM I AM HAVING IS WITH THE ROLLOVER VALVE WHICH IS LOCATED IN THE GAS TANK. WHEN I PUT FUEL IN, IT ACTS LIKE IT IS FULL, EVEN THOUGH THE GAS GAUGE IS TELLING ME THAT I HAVE TANK OF GAS. IT WILL ONLY TAKE THE GAS IF I PUT IN GALLON AT A TIME. THEN WHEN I START TO DRIVE IT, IT WANTS TO STALL, AND I HAVE TO GIVE IT THE GAS AND THEN IT RUNS. I HAVE DONE RESEARCH ONLINE AND THIS IS A PROBLEM IN ALL JEEPS. IF I AM IN AN ACCIDENT THE ROLLOVER VALVE COULD REMAIN OPEN INSTEAD OF CLOSING. THE VALVE IS STICKING AND UNRELIABLE. THIS VALVE DOES IT EVERY TIME YOU PUT GAS IN IT.

NHTSA ID

11360562

Incident

Sep 1, 2020

EVERY TIME GAS TANK IS FILLED THE CAR BUCKS THEN STALLS AND THE STEERING WHEEL LOCKS. THIS HAPPENS RIGHT AFTER FILLING THE TANK AND PULLING OUT OF THE GAS STATION. I HAVE READ ON FORUMS THAT THIS HAS BEEN A PROBLEM IN JEEPS FOR YEARS BUT HAS YET TO BE ADDRESSED. ACCORDING TO THE POST THE ISSUE HAS TO DEAL WITH THE VAPOR/LIQUID SEPARATOR VALVE. ADDITIONALLY, I HAVE ALSO EXPERIENCED ISSUES WITH GAS PUMPS SHUTTING OFF WHEN ATTEMPTING TO FILL THE TANK. I ATTEMPTED TO TAKE IT TO THE JEEP DEALERSHIP WHERE I WAS TOLD I NEEDED A NEW GAS CAP. $100 LATER AND STILL THE SAME ISSUE.

NHTSA ID

11316410

Incident

Dec 1, 2019

Mileage

95,000 mi

MY JEEP STARTED THROWING CODES P0420, WHICH IS SAYING THE CATALYST EFFICIENCY IS BELOW THRESHOLD, AKA CATALYTIC CONVERTER. THERE HAVE BEEN RECALLS FOR THIS MAKE, MODEL, AND YEAR ALREADY. I FIND IT HARD TO BELIEVE MY CAR JUST SO HAPPENS TO NOT BE ONE OF THE VEHICLES TO BE RECALLED. ITS EFFECTING DRIVE PERFORMANCE AND THE EMISSIONS ITS PRODUCING IN THE AIR COULD BE UNSAFE.

NHTSA ID

11302941

Incident

Jan 22, 2020

Mileage

112,000 mi

VEHICLE STALLS AND POWER STEERING FAILS AFTER FILLING GAS TANK. THIS HAPPENS EITHER IMMEDIATELY, OR A FEW MILES AWAY REGARDLESS OF SPEED. VEHICLE WILL ABRUPTLY AND VIOLENTLY BUCK, THEN STALL MINIMUM OF TWO TIMES.

NHTSA ID

11291006

Incident

Dec 23, 2019

Mileage

85,000 mi

SINCE I BOUGHT THIS IN 2011 IT HAS ALWAYS IDLED ROUGH AND STALLED RANDOMLY. APPARENTLY THERE IS NO FIX FOR THIS RANDOM STALLING AND IT HAS ALMOST CAUSED ME TO GET IN SEVERAL CAR ACCIDENTS AND ONE TIME TO CRASH ON THE SIDEWALK AND ALMOST HARM PEDESTRIANS. UNFORTUNATELY I THINK I WILL BE FORCED TO SELL THIS VEHICLE.

NHTSA ID

11252669

Incident

Sep 1, 2019

Mileage

55,000 mi

5 OR SO MINUTES AFTER FILLING UP MY CAR IT COMPLETELY SHUT OFF WHILE I WAS IN THE MIDDLE OF MAKING A LEFT HAND TURN IN THE RIGHT LANE I WAS ALMOST HIT RIGHT ON. THIS MAKES THE 5TH TIME THIS HAS HAPPEN.

NHTSA ID

11234660

Incident

Jul 24, 2019

Mileage

96,000 mi

CAR SHUTS OFF QND STOPS WITHOUT WARNING EVERYTIME AFTER FILLING TANK WITH FUEL... VERY DANGEROUS ON HIGHWAY...

NHTSA ID

11228449

Incident

Jun 21, 2019

Mileage

104,535 mi

MY CATALYTIC CONVERTER IS FAILING AND THE SENSORS ARE COMING ON. IT NEEDS TO BE REPLACED ,I AM LOSING POWER IN MY VEHICLE WHICH IS DANGEROUS ON THE HIGHWAY. I SAW ON THE NEWS THAT THERE IS A RECALL FOR 2011 JEEP PATRIOT WHICH I HAVE BUT MY VIN NUMBER SHOWS ITS NOT ON THE LIST. HOW IS THIS POSSIBLE?

NHTSA ID

11209024

Incident

May 2, 2019

Mileage

2 mi

HI THERE, I AM EXPERIENCING A STRANGE ISSUE, WHERE MY PATRIOT WILL SHAKE/VIBRATE REALLY BAD WHEN IN DRIVE AND SITTING IDLE (LIKE AT A RED LIGHT WITH THE FOOT ON THE BRAKE). IF I PLACE IT IN PARK, NEUTRAL OR START DRIVING THE HEAVY VIBRATION GOES AWAY.MOTOR MOUNTS OK, I HAVE A PROBLEM WITH THE CRANKSHAFT SENSOR BEFORE BUT IS BEEN REPLACED. ANYONE ELSE HAVING A SIMILAR ISSUE, OR HAVE ANY INSIGHT? I HAVE A 2007 JEEP PATRIOT LIMITED WITH ABOUT 80K

NHTSA ID

11128819

Incident

Jul 2, 2018

I HAVE BEEN EXPERIENCING THE CAR WANTING TO STALL OUT. IT IS AS IF THE GAS IS NOT GETTING TO THE ENGINE. I BEGIN TO LOSE POWER AND STEERING. I GUN THE GAS, BUT IT HESTITATES. THIS IS HUGELY DANGEROUS. I AM THE ORIGINAL OWNER AND HAVE SERVICED IT REGULARLY, AND TO THIS DAY ONLY ABOUT 44K ON IT. THIS IS SCARING ME. MY MECHANIC JUST PUT DRY GAS IN TO PERHAPS ALLEVIATE ANY POSSIBLE WATER IN THE TANK AFTER A RECENT FILL-UP. I HAVE BEEN READING OF MANY OTHERS HAVING THE SAME PROBLEM. THIS IS TIME FOR A RECALL, FOLKS. HAD I NOT BEEN ON BACK ROADS, I COULD BE DEAD, AS COULD OTHERS. I WILL NOT DRIVE THIS ON THE HIGHWAY AND I NEED ACTIONS, AS DO MANY OTHERS WHO HAVE COMPLAINED. WE HAVE WAY TOO MANY JEEPS WITH THIS PROBLEM. STEP UP, PLEASE.

NHTSA ID

11113867

Incident

Jul 25, 2018

Mileage

44,000 mi

WHEN FILLING THE GAS TANK FULL, THE ENGINE STALLS AND HESITATES FOR ABOUT 30 SECONDS AFTER FIRST STARTING THE ENGINE BACK UP AFTER THE FILLING OF THE TANK. IT CAUSES MY ENGINE TO COMPLETELY STOP WORKING AND I HAVE TO TURN THE KEY OFF AND RESTART THE ENGINE. I HAVE STALLED OUT IN TRAFFIC CAUSING THE CHANCE FOR AN ACCIDENT. THIS HAPPENS AS I TURN THE CAR BACK ON AND BEGIN DRIVING RIGHT AFTER FILLING THE TANK FULL OF GAS.

NHTSA ID

11099381

Incident

Apr 10, 2018

Mileage

73,000 mi

I FILLED MY GAS TANK UP TODAY. AS I GOT ABOUT 3 MILES FROM THE GAS STATION THE CAR BEGAN TO SPUTTER AND LOSE ITS ABILITY TO ACCELERATE EFFICIENTLY THROUGH ALL THE GEARS. THE CAR WAS RUNNING ROUGH FOR ABOUT 15 MILES UNTIL I PULLED INTO MY DRIVEWAY, AND BEGAN MAKING A WEIRD SOUND OUT OF THE EXHAUST, STILL IDLING ROUGH WHEN PARKED. I LOOKED INTO IT ONLINE AND MANY JEEP PATRIOT OWNERS ARE COMPLAINING OF SIMILAR ISSUES AFTER FILLING UP WITH GAS. THEY;RE SAYING IT'S AN ISSUE WITH A "FUEL TANK ROLLOVER VALVE" OR A "VAPOR LIQUID SEPARATING VALVE." EITHER WAY THIS ISSUE IS DANGEROUS AND NEEDS TO BE ADDRESSED WITH A RECALL OF THE VEHICLES TO ENSURE THE SAFETY OF THEIR OPERATORS IN THE FUTURE.

NHTSA ID

11091244

Incident

May 1, 2018

Mileage

115,000 mi

TAKATA RECALL- I AM HAVING PROBLEMS WITH MY ELECTRONIC THROTTLE CONTROL FLASHING ON WHILE I'M DRIVING. IT HAPPENED INTERMITTENTLY FOR A FEW WEEKS, AND NOW IT WON'T GO AWAY. IT CAUSES ME TO LOSE THE ABILITY TO SHIFT MY VEHICLE HIGHER THAN 3RD GEAR, AND I CAN'T ACCELERATE AT AN APPROPRIATE SPEED. THIS PROBLEM OCCURS WHEN I START MY VEHICLE MORE OFTEN THAN NOT, ALTHOUGH IT HAS HAPPENED A FEW TIMES WHILE I WAS DRIVING. THE FIRST TIME IT OCCURRED, I WAS DRIVING ON THE FREEWAY, AND IT CAUSED MY VEHICLE TO LOSE POWER FOR ACCELERATION, PUTTING MY SON AND I IN A POTENTIAL SITUATION FOR A HIGH SPEED ACCIDENT.

NHTSA ID

11046556

Incident

Oct 17, 2017

Mileage

110,000 mi

I WILL BE DRIVING MY JEEP PATRIOT AND IT WILL JUST STALL OUT. I HAVE TO WAIT FOR A WHILE AND IT STARTS UP. IT WILL AGAIN STALL OR RUN FINE FOR AWHILE. THE LAST TIME I WAS ENTERING THE 10FWY IN LOS ANGELES AND IT STALLED NEARLY CAUSING A MAJOR ACCIDENT. I HAD MY 3 YOUNG KIDS WITH ME. NOW IT SITS IN MY GARAGE AS I MAKE MONTHLY PAYMENTS. HELP ME

NHTSA ID

11019809

Incident

Apr 10, 2016

Mileage

88,000 mi

I PURCHASED THIS VEHICLE LAST FALL IN A PRIVATE SALE. THE VEHICLE APPEARED TO BE IN GOOD CONDITION AND WELL TAKEN CARE OF. ABOUT TWO WEEKS AFTER ACQUIRING THIS VEHICLE, I WAS DRIVING ALONG THE INTERSTATE ON A 50 MINUTE TRIP AND THE VEHICLE BEGAN TO SLOW DOWN DESPITE BEING ON CRUISE CONTROL. THE TRANSMISSION LIGHT CAME ON AND I PULLED TO THE SIDE OF THE ROAD WHERE I WAITED FOR 10 MINUTES AND BEGAIN DRIVING AGAIN. SINCE THIS INCIDENT IN THE FALL OF 2016, THE SAME THING HAS HAPPENED ABOUT 10-15 TIMES-INCLUDING TODAY, A RAINY 70 DEGREE DAY DRIVING THE NEARLY FLAT ROUTE FROM LINCOLN TO OMAHA NEBRASKA. I UNDERSTAND JEEP HAS COME FORWARD TO SAY THIS IS NOT A MOUNTAIN TRAVELING VEHICLE (VERY STRANGE JEEP BECAUSE, WELL IT'S A TRAIL RATED JEEP AFTER ALL). NOT ONLY IS THIS A NUISANCE THAT I CANNOT DRIVE MY WORK ROUTE FOR 45 MINUTES WITHOUT HAVING TO PULL OFF OF THE ROAD AT LEAST ONCE BUT EVERYTIME I DO, IT PUTS ME IN A LIFE JEOPARDIZING SITUATION ON THE SIDE OF THE INTERSTATE WHERE THE SPEED LIMIT IS 75MPH. THIS ISSUE NEEDS TO BE RESOLVED BY JEEP. I KNOW OTHERS ARE HAVING SIMILAR ISSUES BECAUSE GOOGLE WAS ABLE TO GUESS THE PROBLEM AFTER TYPING ONLY THE WORDS "2011 JEEP PATRIOT." PLEASE ADDRESS THE PROBLEM, JEEP, AND MAKE THIS RIGHT FOR EVERYONE WHO CONTINUES TO INVEST AND SUPPORT YOUR (TYPICALLY) WONDERFUL PRODUCTS.

NHTSA ID

10979385

Incident

Apr 19, 2017

Mileage

68,000 mi

TL* THE CONTACT OWNS A 2011 JEEP PATRIOT. AFTER REFUELING THE VEHICLE, IT RANDOMLY STALLED. THE VEHICLE WAS TO BE INSPECTED AND DIAGNOSED BY A DEALER. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V120000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,200.

NHTSA ID

10899169

Incident

Aug 1, 2016

Mileage

65,200 mi