2020 Keystone Fuzion Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2020 Keystone Fuzion, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure150.0%
- Suspension150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
The Keystone Fuzion RV has a structural issue. I have been following other owners and there seems to be many RV’s with the same crack under the Master Bedroom. The crack appeared after transport I would not want to be the cause of an accident if the crack continued across the body and it detaching from the RV while being transporting and causing serious injury or death. I would like this investigated for not only my safety but the safety of other on the road.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
Originally, the rear axle on our trailer failed last year in July of 2020. We had an axle that was cambered in and that resulted in abnormal wear on our rear tires. Because of the abnormal wear, we had a blowout of our left tire on the rear axle while traveling on Interstate 84 in Oregon. After eight months, the dealer, Camping World/Keystone, replaced the axle. Upon receiving the trailer back in April from the dealer, we noticed it was leaning to the right about three inches. Since we were unaware of the real issue, we went on our trip. We have had to level the trailer with leveling blocks at our campsite each time on the right side. We haven't had to do that in the past. Our safety and the safety of others were put at risk because the leaf spring could have broken, pulled the rear axle back, and steered us in an unexpected direction. This could result in us going into other vehicles on the road. Today, we had it inspected by two companies: The Spring Works as well as Bob Scott RV respectively in Grand Junction, Colorado. They both confirmed that we had a bad leaf spring on the right rear axle. Additionally, Bryan Dubose, at The Spring Works stated that the left rear leaf spring has been compromised because of the other faulty one. There were no warning signs other than the trailer leaning to the right when viewed from the rear. The symptom of the trailer leaning to the right first appeared when Camping World had replaced the defective rear axle and returned it to us in April of 2021.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .