2017 Kia Sedona Owner Complaints

White Pearl paint is flaking/peeling of for no apparent reason.

NHTSA ID

11743793

Incident

Nov 14, 2025

The contact owns a 2017 Kia Sedona. The contact stated that while driving at 55 MPH, the contact the oil light illuminated, and the vehicle decelerated independently. The contact mention he pulled over to the right side of the road, exited the vehicle and when he lifted the hood of the vehicle, he noticed flames coming from the engine. No injuries were sustained. No medical attention. There was no police report filed. The fire department did not show at the scene to extinguish the fire. The vehicle was not destroyed. The vehicle is currently still at the scene. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 146,658.

NHTSA ID

11736979

Incident

May 11, 2026

Mileage

146,658 mi

Same defect on NHTSA (Investigation PE23-019) my vehicle is 1 month outside of the manufacturing date listed, having the same issues, but they will not cover it-even though the same engine is in it. KIA bulletin WTY039 Vehicle is overheating, coolant is bubbling

NHTSA ID

11731432

Incident

Jun 5, 2025

There was an unusual amount of oil "slug" created by the engine which caused the engine to be inoperable. Therefore, we had to replace the engine.

NHTSA ID

11731057

Incident

Apr 4, 2022

The sliding door located on the driver's side / left side behind the driver's seat will not close completely which causes an alert/warning to be displayed that the door is still open. The door slides on the track but will not close completely. You must apply pressure as it closes to turn of the warning light.

NHTSA ID

11731053

Incident

Jan 8, 2024

My vehicle would not start, after jumping and idling for a few moments, all dash lights started flashing and vehicle wouldnt go into gear. I shut it off as it started making a hum and smelled like something wasnt right. A mobile mechanic who came to my rescue after breaking down did a diagnostic of my engine. I was told I had low to no oil. I asked how was this possible as I had only driven around 2,000 miles since my recent oil change at the KIA dealer ( Wesley Chapel, FL). He said the tech may not have put recommended oil amount or the engine is consuming the oil. I told him I would contact the dealer regarding this matter. Long story, short I broke down to needing a new battery and alternator. I don't know if this was the exact cause of the latter 2 needing to be repaired. However, since speaking to others this is common with some models. I even had 1 individual state there were recalls and engines were being replaced as the engine could potentially lock up or fail. I am not finding a recall. Is this an issue that has been reported and I am missing something. Also, there was a recall on the sliding doors at 1 point. I am still having issues with the drivers side yet tge dealerships want to charge me a diagnostic fee. How do I go about seeing if this is an ongoing issue.

NHTSA ID

11730765

Incident

Feb 26, 2026

137,000 Miles, regular oil changes every 4,000 miles,even adding 2 quarts during the 4,000 miles it would still come up short by 1 quart. Started throwing p0018 timing code,high pressure fuel pump on front blew off the valve cover,Im assuming due to jumping out of timing,as the high pressure pump sits ontop of one of the Camshaft rollers. Engine started knocking and is now useless.

NHTSA ID

11729795

Incident

Mar 29, 2026

Vehicle Information: 2017 Kia Sedona VIN: [XXX] Engine: 3.3L GDI Mileage at failure: 186,000 miles Complaint: I am filing this complaint regarding sudden engine failure in my 2017 Kia Sedona equipped with the 3.3L GDI engine. The vehicle had approximately 186,000 miles at the time of failure and had just undergone a routine oil change prior to the incident. While driving on the highway, a warning light illuminated on the dashboard. Shortly after the warning light appeared, the engine began making a loud knocking sound. The knocking rapidly worsened, indicating internal engine damage. The failure occurred while the vehicle was in motion at highway speed, creating a serious safety risk due to potential loss of power and reduced ability to accelerate or maneuver safely. The vehicle was diagnosed as requiring a full engine replacement. The estimated cost provided was $5,758.05 for the engine, plus an additional $1,800 core charge, not including labor costs. This represents a substantial financial burden. It is my understanding that Kia has prior knowledge of widespread issues involving GDI engines, including premature internal bearing failure and engine seizure in multiple models. Despite this knowledge, the 2017 Kia Sedona with the 3.3L GDI engine has not been adequately addressed. Sudden engine failure at highway speeds poses a significant safety hazard and increases the risk of collision. I am requesting that NHTSA investigate the 3.3L GDI engine used in the 2017 Kia Sedona for potential manufacturing defects related to premature engine failure and internal component damage. Thanks, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11721656

Incident

Feb 8, 2026

My husband and I originally bought our White 2017 Kia Sedona LX on 9/12/18 from Hertz automotive sales. Since that time we had had no engine issues. We maintained our brakes, and standard upkeeps on the car. Eight years in and still our car had given us no issues. Our most recent oil change was on 9/13/25 and it was inspected during that oil change and no issues were noted. The car had since that time been driven as expected to school for kids and work for myself and activities on the weekend for family time. There was no weird smells, discolored smoke from the tail piper or anything. The car was running fine. At no time were any warning signals on, flashing or intermittently coming on and off. Then on Thursday, 1/22/26 evening I stopped by the gas station to get gas before turning into my neighborhood for home. Upon leaving the gas station, I noticed and felt the engine seemed off and vibrating with soft tremor like shaking and as I pressed on the gas for power it was soft power, and at that moment only did I see the check engine light on solid (not flashing). I called my husband and a few mins later we made it home, he came out to check the car, and saw now that the engine light was flashing over and over. We read up on what this meant and new we had a problem. We dropped the car off on Saturday to the mechanic and on Monday, 1/26/26 a diagnostic was made and was given the bad news that the engine had complete failure. $18,000 bill to fix all the issues. But here is a short synopsis: Multiple codes found in ECM Metal found in oil, oil is also 1 or more quarts low P0300 (Random misfire), P0302 (CYL #2 misfire), p0304, (CYL#4 misfire) p0306. (CYL#6 misfire) p0175, (bank 2 rich) p0018 (crank - cam correlation) Engine has internal failure, failing piston rings allowing oil in combustion chamber, causing misfire, rich condition and engine shaking This was a shock and we had to sell it for nothing to a salvage company.

NHTSA ID

11716567

Incident

Jan 22, 2026

My 2017 Kia Sedona has has regular oil changes about every 3000 miles. I was not due for an oil change quite yet and a ticking noise coming from the engine started to occur. I made an appointment at the Kia dealership right away. Just a few days before my appointment there was no warning light for the oil or engine until the engine failed, went limp and I lost power steering control, the brakes went stiff and all of the lights came on at once. It was very scary for me and my two children to lose that control of the vehicle. It can be inspected at Berlin City Kia where it currently sits and is in need of a replacement engine. After much research I have seen that this is a known issue for Kia engines and for some reason the 2017 Sedona is not included in any extended warranty's. Please investigate this. I did ask Kia for help in covering the replacement engine but was denied by the woman who I spoke to on the phone. I still put in a claim online anyway. It has been inspected by Berlin City Kia and they said there was "significant rod knocking". They are quoting me $9880 to replace the engine. After regular oil changes for the time that I have owned this vehicle and especially after I has the oil pressure sensor leak addressed as well over the last few years, it should not have died prematurely as it did. I am worried that the oil leaking so badly at that time may have pooled in the back of the engine which could have led to the rods wearing which in turn led to them knocking in the future. What else could cause this to happen? And so many other customers have complained about this exact issue. Please investigate this.

NHTSA ID

11713242

Incident

Jan 8, 2026

Engine with around 107K miles has had regular maintenance done to it. Went out one morning to start my van and there was a knocking noise coming from under the hood. We then had it towed to an engine/transmission repair shop to have it looked at and was told that we needed a new/used engine and the price was thru the roof. this is a very trusted shop so took there advice. To have the engine replaced is going to cost more than what the vehicle is worth. This is a known issue with some kia engines as they with no signs of failure prior to the noise. We had not one warning light on the dash, it just went poof.

NHTSA ID

11710621

Incident

Sep 10, 2025

The contact owned a 2017 Kia Sedona. The contact stated that after parking in his driveway, there was white smoke coming from the front of the vehicle. The contact is handicapped and was assisted by his wife to exit the vehicle safely. The vehicle later caught on fire, and flames were visible in the front passenger side that spread to the rear of the vehicle. No warning lights illuminated before or after the failure. The contact stated that the front of the house was damaged, as well as the garage siding, along with an older truck parked in the driveway. The fire was extinguished by the fire department with water, and a police officer was on scene and tried to extinguish the rear with an extinguisher, but was unsuccessful. There was a fire report filed. The vehicle was towed a week after the fire to the insurance tow lot. The vehicle was deemed destroyed by the insurance company. No injuries were sustained. The manufacturer was notified of the failure. The failure mileage was 106,000.

NHTSA ID

11707879

Incident

Jul 30, 2025

Mileage

106,000 mi

Excessive oil consumption

NHTSA ID

11705212

Incident

Nov 20, 2025

Oil Control valve failed and oil leaking

NHTSA ID

11694305

Incident

Sep 19, 2025

Burning through oil faster than it should, needing to feel up oil every week, has been confirmed by an auto repair shop.⁸

NHTSA ID

11687085

Incident

Jun 1, 2025

seats break easily and dont lock in place as well as control modulae harness from door to rear tail lights burn up

NHTSA ID

11686395

Incident

Jul 8, 2025

On [XXX], while driving my 2017 Kia Sedona on a road trip through Killeen, Texas, the engine suddenly began making a loud knocking noise without any prior warning, leading to catastrophic engine failure and complete loss of motive power. The vehicle became inoperable and was towed to University Kia in Waco, Texas. The day prior, on [XXX], the vehicle underwent a thorough pre-trip inspection and full synthetic oil change at Sun Auto Tire & Service (5117 Golden Triangle Blvd., Keller, TX 76244), confirming it was roadworthy with no issues detected initially, though oil was found leaking afterward (maintenance records attached). University Kia confirmed the catastrophic engine failure, likely related to the 3.3L Lambda engine's known oil pressure switch (OPS) defects, as the OPS had been previously replaced under warranty. Kia Motors America (Case [XXX]) denied liability unless I pay $3,000 for a teardown inspection to prove the failure was due to the OPS, despite the vehicle's eligibility under the WTY026 extended warranty (15 years/150,000 miles). This failure aligns with similar complaints and NHTSA investigations into 3.3L Lambda engine issues, such as oil starvation and sudden seizures. Due to the failure, we missed a prepaid hotel stay in San Antonio, incurred additional hotel stay charges as our trip had to be extended, and incurred costs for a rental vehicle to complete the trip. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11685326

Incident

Jun 6, 2025

I was driving and my engine seized and my car is now undrivable. I immediately looked up recalls and see that there were several recalls and recalls surrounding the engine as well. I am told I now need a brand new engine and was referred to file a report as the issue experienced should not have been happening.

NHTSA ID

11678952

Incident

Aug 4, 2025

Engine stared clattering at the end of a 2 hour drive home. Engine died entering a round about 1-1/2 miles from home. It restarted and limped to my home. Arranged to have it towed to mechanic shop. They informed me there is issues with rod bearings and that Kia has a class action suite but Kia is telling me that my vin is not involved.

NHTSA ID

11678706

Incident

Aug 3, 2025

The Sedona is showing paint damage on the rear trunk door. The unit is white. It is starting to flake where the glass ends.

NHTSA ID

11676139

Incident

Jul 4, 2025

Without warning lights coming on my engine started knocking on May 15, 2025. Turns out the bearing between the top of the motor and the bottom of the motor is stripped. 5 months before this happened they replaced the 2 fuel pumps, cvvt, cam shaft sensor and assembly, timing chain and spark plugs. Again I had no warning about that work that the dealership said I needed. Now I need a new motor and they won’t do anything for me except charge over $10,000.

NHTSA ID

11675598

Incident

May 15, 2025

The contact owns a 2017 Kia Sedona. The contact stated that upon start of the vehicle, the air bag warning light illuminated on the instrument panel. The vehicle was taken to a dealer where a diagnostic test was performed, and the dealer discovered that the front passenger's side air bag module was defective and needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 22V031000 (Air Bags). The dealer acknowledged the recall but informed the contact that the repair would be an out-of-pocket expense. The manufacturer was notified of the failure. The failure mileage was unknown.

NHTSA ID

11675356

Incident

Feb 1, 2024

I heard a knocking sound in my car which I thought was coming from the engine towards the end of May. It was really bad on May 29, 2025, so I did not drive it again. I called my local dealership and scheduled an appointment for June 2, 2025. The vehicle had to be towed from my house to the dealership as it did not seem safe to drive. The battery had died when I tried to start it, so I called AAA for a tow. They were able to jump start the car, but I still did not feel safe driving it with the loud knocking noise. I had AAA tow my car to the dealership. This is what they found: LOWER ENGINE KNOCK, METAL IN THE OIL, LOWER ROD BEARING FAILURE. No lights were on at the time the severe knocking occurred. How and why was my VIN not included in the recall notice on the engines? This was clearly a safety hazard. This problem SHOULD BE COVERED by the engine recall. Now I have to get a new vehicle with extremely limited funds.

NHTSA ID

11664626

Incident

May 28, 2025

Catalytic converter system failure

NHTSA ID

11662481

Incident

May 20, 2025

The contact owns a 2017 Kia Sedona. The contact stated while starting the vehicle, the air bag warning light illuminated. The vehicle was taken to an independent mechanic who diagnosed that the front passenger's side air bag module needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 22V031000 (Air Bags). The failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 86,000.

NHTSA ID

11656748

Incident

Apr 25, 2022

Mileage

86,000 mi