Owner-reported complaints naming the brake system, filed with NHTSA
Data refreshed
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake. Every record below is an owner-reported complaint about the 1996 Kia Sephia submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 39 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 39, in the owner's own words
ABS BRAKING LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. CONSUMER NOTICED WHILE APPLYING THE BRAKES THE PEDAL WENT TO THE FLOOR. CONSUMER DROVE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE PROBLEM COULD NOT BE DUPLICATED. *AK
ONLY 9 MONTH OLD BREAK, ROTORS HAS BECOME TOO THIN, NEEDS TO BE REPLACED. *AK
BRAKE PADS AND ROTORS NEED TO BE REPLACED EVERY 8000 MILES. *AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
EVERY TIME TAKEN IN FOR REG.CHECKUP,HAD NEW BRAKES PUT ON,PUTTING 99 BRAKES ON 96 CAR. *AK
EVERY 5000 MILES NEEDS BRAKES/ ROTORS, CONSUMER FEELS ROTORS ARE WARPING FAST, AND THIS IS A MANUFACTURER'S DEFECT.*AK
CONSUMER HAD THE BRAKE REPAIRED AND THEY FAILED AGAIN 6299 MILES LATER, THEY HAD THE BRAKES REMOVED AND TAKEN TO A SPECIALIST WHO INFORMED THEM THAT THE ROTORS WERE THE ORINGINALLY INSTALLED ROTORS AT THE TIME OF MANUFACTURING. CONSUMER FEELS THE THE BRAKE JOB DONE PRIOR WAS NEVER DONE OR THE NEW BRAKES INSTALLED WERE DEFECTIVE. NLM
I HAVE HAD THE BRAKES REPAIRED AT LEAST 10-12 TIMES AND THE PROBLEM STILL IS NOT FIXED. THE BRAKE PEDAL BECOMES HARD AND DOESNT DEPRESS, MAKING STOPPING SLOW. THE FRONT WHEELS OF THE CAR BECOME BLACK,COVERED WITH THE DUST FROM THE BRAKE PADS.. AND AT TIMES THE BRAKES STICK AND RESISTANCE IS FELT FROM THE VEHICLE AND THE FRONT TIRES BEGIN TO GIVE OFF SMOKE.*AK
BECAUSE OF THE MALFUNCTION OF BRAKE SYSTEM, I HAD AN ACCIDENT. BRAKE INSPECTION BY KIA AUTHORIZED MECHANIC REVEALED, THAT THE CAR HAD FACTORY DEFECT IN THE BRAKE SYSTEM. *AK
IN MARCH 24, 1998 BECAUSE OF THE MALFUNCTION OF BRAKE SYSTEM , I HAD AN ACCIDENT. THE BRAKE INSPECTION BY KIA AUTHOIZED MECHANIC REVEALED, THAT THE CAR HAD FACTORY DEFECT IN THE BRAKE SYSTEM. UNTIL NOW THERE HAS BEEN DONE A NUMEROUS AMOUNT OF REPAIRS AND ADJUSTMENTS FOR THE BRAKE SYSTEM, BUT WITHOUT ANY SUCCESFUL RESULTS.CAR HAVE LOTS OF DEFERENT PROBLEMS AND FACTORY DEFECTS. IT IS A LEMON. *AK
AFTER AN OIL CHANGE THE MECHANIC LEFT THE OIL PLUG LOOSE AND THE PLUG FELL ON THE OPEN HIGHWAY, NOW THE VEHICLE HAS LEFT A CONSUMER STRANDED.*ET
IN COLD/DAMP WEATHER BRAKES WILL LOCK UP AND MAKE LOUD NOISE, CAUSING VEHICLE TO SKID. *AK
OIL FILTERS MADE BY ANY OTHER COMPANY THAN KIA DOES NOT WORK. I HAD TO GET AN OIL CHANGE TWICE BECAUSE THE ONE DONE BY THE CAR LOT WAS NOT A KIA OIL FILTER AND THE ONE I HAD DONE WAS NOT A KIA FILTER. I TOOK THE CAR TO A KIA REPAIR SHOP THE NEXT DAY AND THEY CLEANED THE AREA AND CHANGED THE FILTER. THE BRAKES SINCE I BOUGHT THE CAR HAVE BEEN SCREACHING AND AT THAT TIME, A BRAKE REPAIRMAN ADVISED ME MY BRAKES WORE AT 95%. THE BRAKES STILL SCREACH AND GRIND. IN THE SUMMER, THE AIR CONDITIONER GIVES OFF A FOUL ODOR TO THE POINT OF HAVING TO TURN IT OFF. THE REAR MIDDLE SEATBELT DOES NOT LATCH. THE STEPS LISTED IN THE KIA MANUAL DOES NOT COINCIDE WITH THE STEPS YOU MUST TAKE TO DEFROST THE WINDOWS. THE ONLY WAY I CAN IS TO TURN THE HEAT UP ALL THE WAY, OR TO TURN ON THE HEAT AND AIR CONDITIONER, WHICH I CAN'T USE. THE CAR WHEN IT'S IN DRIVE FEELS LIKE IT'S IN A LOWER GEAR AT TIMES AND FEELS LIKE IT'S NOT QUITE IN DRIVE. THE SEAMS IN THE DRIVER'S DOOR ALLOWS WATER DRIP INTO THE CAR. THE WINDSHIELD WASHER HOLE ON THE RIGHT SIDE DOESN'T SPREW OUT ANY WINDSHIELD CLEANER. I HAD TO TAKE THE CAR BACK TO THE CAR LOT BEAUSE OF THE GAS DOOR NOT OPENING WITH THE INDOOR GAS LATCH. THE OUTSIDE OF THE FRONT HUBCAPS GETS VERY OIL AND NO ONE CAN TELL ME WHY. THE WINDOW'S RESIST WHEN YOU TRY TO ROLL THEM UP. *AK
WHEN VEHICLE IS COLD THE BRAKE PEDAL WOULD NOT DEPRESS TO THE FLOORBOARD, CAUSING THE CONSUMER TO PUMP THE BRAKES TO GET OUT OF PARK. DEALER HAS BEEN NOTIFIED OF PROBLEM, BUT CANNOT FIND ITS CAUSE. KIA HAS FAILED TO REPAIR THE VEHICLE. *AK *ML
BRAKE, DRUM, AND ROTOR PROBLEMS. AIR CONDITIONER DOESN'T WORK. DOESN'T ACCELERATE WELL.
THE PARKING BRAKE CABLE PULLED OUT OF THE CENTER ANCHOR IN THE TRANSFER BRACKET DUE TO POSSIBLE DESIGN FLAW OF THE METAL BEING TOO SOFT (WEAK) FOR FORCE NECESSARY. MJS
WHILE CONSUMER WAS DRIVING AT 45 MPH VEHICLE LOST BRAKING POWER. TOOK AUTO TO DEALER AND WAS TOLD THAT THEY CANNOT FIND ANYTHING WRONG WITH BRAKES. *AK
SEVERAL REPLACEMENTS OF BRAKE PADS AND ROTORS DUE TO WARPING/VIBRATION/SHUDDERING, ALSO GLAZED BRAKE LINING REPLACED DUE TO SQUEAKING NOISE WHEN APPLYING BRAKES.
BRAKES ARE DEFECTIVE, PADS AND ROTORS, MAKE A LOUD SQUEALING NOISE. REPAIRWORK DONE AT OWNER'S EXPENSE, AND PROBLEM STILL EXISTS DUE TO TYPE OF BRAKES. DEALER AWARE AND CANNOT REMEDY PROBLEM. PROVIDE FURTHER INFORMATION. *AK
TRANSMISSION BROKE DOWN. OVERDRIVE KEEPS SLIPPING. WILL NOT SHIFT. VEHICLE WOULD NOT START UP. THE KILL SWITCH WIRING KEEPS EFFECTING STARTING. BRAKE DISC & PADS NEED TO BE REPLACED. *AK
BRAKE PEDAL GOES TO THE FLOOR, SEEMS TO BE AIR IN BRAKES. DEALER CANNOT DUPLICATE PROBLEM. *AK
BRAKE ROTORS SEVERELY WORN, PADS FAILED CAUSING NOISE.
BOTH FRONT BRAKES FAILED.
BRAKE CALIPERS, ROTORS AND PADS HAVE BEEN REPLACED FOUR TIMES IN TWO YEARS.
BRAKES FAILED.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .