2025 Kia Sorento Hybrid Owner Complaints

My rear windshield exploded out when back door was closed

NHTSA ID

11755773

Incident

Aug 8, 2026

The contact owns a 2025 Kia Sorento. The contact stated that while driving approximately 75 MPH, the vehicle lost automotive power and failed to exceed 30 MPH. The contact pulled over to the side of the road to avoid other vehicles. No warning lights were illuminated. The vehicle was towed to a dealer to be diagnosed; however, the cause of the failure was not yet determined. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 16,386.

NHTSA ID

11751110

Incident

Jul 15, 2026

Mileage

16,386 mi

The contact owns a 2025 Kia Sorento Hybrid. The contact stated that while driving at approximately 55 MPH, the vehicle suddenly decelerated and failed to exceed 35 MPH before stalling and losing power. Emergency services were contacted and assisted with pushing the vehicle to the side of the road. The vehicle was towed to a dealer, who held the vehicle for two days but had not diagnosed the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 11,000.

NHTSA ID

11749335

Incident

Jul 7, 2026

Mileage

11,000 mi

Wireless cell phone charging pad causes phone to overheat. I have tried other vehicles (Ford Explorer) and this had no detrimental effect on cell phone. As well as heating the cell phone (Apple iPhone 16) it also doesn’t charge the phone. I have also tried other cell phones (Apple iPhone 16 and 14) and same issues were presented. The safety issue is the inability to charge the cell phone reliably as well as the very hot condition caused to the cell phone. I purchased this vehicle new in July 2025 and I realized the issue almost immediately. I did let my Kia service department know of this and was told at the time that this is very common and that a recall (repair) would likely be available soon. To be best of my knowledge this hasn’t happened. The only reason I am bringing it up now is that my son in law (the Ford Explorer) mentioned that he utilizes his with no problem. Thank you

NHTSA ID

11748874

Incident

Jul 2, 2025

I purchased a 2025 Kia Sorento Hybrid from Dulles Kia. Since I've owned it, I've had the same problem three times — my car randomly goes into limp mode while I'm driving. It doesn't matter what speed I'm going. The car just starts slowing down on its own, won't let me accelerate, and the RPMs start surging up and down. It's terrifying. The first time it happened, it was towed to Fayetteville Kia. They couldn't even recreate the problem. They redownloaded some software and sent me on my way. The second time it happened, it was taken to Herson's Kia in Rockville. This time they were able to recreate it. They told me it was the fuel pump and replaced it under warranty. Now it's happened again — this time while I was on vacation in Ocean City, Maryland. I was stranded with my two dogs, one of which is my service animal. I had to arrange a tow and find a last-minute hotel out of pocket. The car is currently at Pohanka Kia in Salisbury. They first told me it was a fuel injector, then changed their diagnosis to a valve seal issue — and apparently it's a known issue with this type of vehicle. It has now been sitting at the dealership for over a week. This is the third time the same problem has occurred. It has ruined multiple vacations and left me stranded, stressed, and without my car for extended periods. I just want a car that works.

NHTSA ID

11748306

Incident

Apr 19, 2026

Warning lights on while driving. The emergency triangle, collison warning, break warning, both turn signals, and departure warning lights were illuminated. We were concerned of causing damage to the vehicle and pulled over. Dealer knows of issues in CA and AZ with other Sorentos. Dealer said it is due to camera overheating; the camera housing is metal and therefore causes this issue. No known fix and we are apprehesive to drive it. KIA customer care had no information and only said to go to dealer when lights are on so a code can be pulled. I believe the housings need to be replaced if that is the case and if there is a true issue with the vehicle I cannot distignuish between "camera" or mechanical when lights come on.

NHTSA ID

11746569

Incident

Jun 23, 2026

For an unknown reason when driving on the highway in heavy traffic the engine started to shake violently causing us to immediately pull over and when we opened the hood the engine was shaking violently. This was a dangerous situation because during this time the engine was not very responsive to input. No warning lights came on at all.

NHTSA ID

11746457

Incident

May 29, 2026

My 2025 Kia Sorento Hybrid, with approximately 20,000 miles, has experienced a sudden loss of power and entered a limp-mode condition twice within two days. During both incidents, the vehicle would not accelerate normally and was unable to maintain expected traffic speed, creating a significant safety hazard. No warning lights, warning messages, or check-engine light appeared before or during either event. After the incidents, no OBD-II diagnostic trouble codes were present. Stopping and starting the vehicle restored normal operation temporarily, but the problem reoccurred. The sudden and unexplained loss of propulsion without any warning or stored fault codes increases the risk of a crash, particularly when merging, passing, or driving in traffic.

NHTSA ID

11744877

Incident

Jun 17, 2026

Around XXX the car was suddenly unable to accelerate properly. When pushing the accelerator, the engine would rev only after a long lag, would rev significantly higher than normal without shifting, and the acceleration response was dramatically less than usual. It felt as if the engine simply had no power, or at times almost as if something were resisting the engine. It made it nearly impossible to accelerate past roughly 40mph and the response in acceleration from the pedal was very unpredictable. A mechanic was able to replicate the issue and it was initially attributed to the high pressure fuel pump. Roughly a week after the pump was replaced in early August 2024, the issue occurred again and was again replicated by the dealer and attributed to the fuel sensor, which was replaced. The issue then re-occurred on June 14, 2026. The car is currently in the shop awaiting diagnosis and repair. At no point during any of these instances did any warning appear on the dashboard or anywhere else in the car. The parts are not available for inspection, it is unclear to me who from Kia or any other organization has examined them beyond the dealership (Kia of Riverdale in Riverdale, NJ). The safety of the car’s occupants and potentially other motorists was put at risk by acceleration performing radically differently than would be anticipated from a properly functioning car. The issue was noted several times, including while pulling out of a parking lot onto a busy road and while attempting to keep up with traffic on a busy divided highway.

NHTSA ID

11744327

Incident

Jul 20, 2024

Car will suddenly go into limp mode while driving. Took to dealership and couldn' t find anything wrong. One week later did the same thing. Took back to dealership and haven't heard anything from them yet. It will just go limp and cars coming behind you could crash into you.

NHTSA ID

11740215

Incident

May 1, 2026

In February, on my car that I had had for six months with less than 3500 miles on it, I was driving and got a “driver assist warning“ on my car and I no longer have the ability to apply gas to the car. Thankfully, I was able to pull over safely. I restarted the car and everything was fine. I called the dealership and they said it is probably a bad sensor and I made an appointment to bring in my card that Friday. They said that this was due to probably a dirty sensor due to it being snowing out. The next day I took my car to a car wash to clean it to make sure that there was nothing messing with the sensor. As soon as I exited the car wash, I got the same quote, driver, warning, assist quote, warning on my dashboard and lost the ability to gas my car. I immediately took my car to the dealer where it stayed for 18 days. They said that they replaced the sensor which was causing the issue. I had my car back for a total of 10 days when the same thing happened to me. This time I was driving on a 55 mph road. Luckily, again I was able to pull over safely. I took my car straight to the dealer where they had it for 28 days. They got the corporate Kia mechanics involved. They tried a bunch of things to fix my car, and eventually said that the sensor malfunctioning was due to the oil being too high. This is on a car now with less than 38,000 miles which has never had service on it. My car has been in the shop for a total of 46 days of the last two months. The sensor just going out abruptly can cause a major accident. Since I have had this problem, I have heard of at least two other cars doing the exact same thing.

NHTSA ID

11736096

Incident

Feb 10, 2026

1/24/26 -- While driving ~25-30mph (~2 miles from start of trip) car produced “Engine Management System error” and within a minute or so “Check Hybrid System. Stop Safely” warning and went into electric only mode, limp mode. Turning off the car and turning back on temporarily enabled the gas engine to run. Dealer reviewed fault codes and stated vehicle was now running correctly. ~800 miles and less than 30days later the same problem occurred again. 2/17 – While driving ~30mph (~1mile from start of trip) the car produced a “Engine Management System error”. At this point I was approaching a traffic light and stopped at the red light. Decided to return home and attempted to turn right on red at the light. When I hit the gas to turn, the gas engine did not engage, the car limped forward a few feet in electric mode, and the car started beeping with the “Check Hybrid System. Stop Safely” warning. If I had less less space when turning right, or the car would have a moved a few feet farther, I would have been hit in the intersection by an oncoming car. Thankfully I had left a lot of space and my car did not pull that far into the intersection. I turned the car off, when I turned the car on again, the gas engine engaged, and I was able to slowly drive the 1 mile home. Car was then towed to the dealer 2/18 for repair. As of 3/17 dealer still has the vehicle (so do not have a second repair invoice) and waiting on an Customer Care escalation from KIA as dealer recalibrated the Hybrid module but can't recreate the issue after driving 400miles. This issue leaves the car in a limp mode with a significant chance of causing a accident, I was almost hit, when there is loss of ability to accelerate at any meaningful rate or drive any sustained distance.

NHTSA ID

11725121

Incident

Feb 17, 2026

While travelling in the center lane of the highway, the vehicle experienced a sudden loss of power and could not maintain speed. Vehicle could not go faster than approximately 20 miles per hour. Managed to exit highway off ramp by driving approximately 20 miles per hour as there was not a shoulder to exit the lane of traffic in that particular area. The hybrid battery voltage went very low. After exiting highway turned off vehicle and turned back on again, was able to drive normally to the dealership service center. Dealership found code history of fuel rail pressure sensor, cleared code and test drove and stated not able to duplicate concern at this time. 2025 Kia Sorento Hybrid mileage is 14250 miles

NHTSA ID

11722826

Incident

Mar 4, 2026

The vehicle experiences a sudden and complete loss of power while driving. Specifically, the vehicle loses the ability to accelerate. During these incidents, the battery indicator shows critically low battery levels despite there being sufficient gasoline in the vehicle. The exact component causing the malfunction has not been identified by the dealership, as they report no diagnostic codes are present. The vehicle is available for inspection upon request. This issue has occurred multiple times while driving on highways at speeds where surrounding traffic is traveling approximately 55 mph or higher. This has also happened while pulling out into traffic, causing near misses of an accident. When the malfunction occurs, the vehicle rapidly loses acceleration capability and slows down to approximately 20 mph. This creates a dangerous speed differential between my vehicle and surrounding traffic. It becomes extremely difficult to safely maneuver into the breakdown lane due to the inability to accelerate. This situation creates a significant risk of rear-end collision or multi-vehicle accident. The dealership has been unable to reproduce the issue during service visits. However, the vehicle has been brought in multiple times for this same concern. The dealership has stated that no diagnostic trouble codes are stored, and therefore they cannot identify or repair the root cause. I have multiple videos documenting the issue occurring while driving. The vehicle has been inspected multiple times by the authorized Kia dealership service department. This issue has been occurring since July of 2025. Video Link: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11721493

Incident

Feb 28, 2026

Currently at a Kia dealership for the 3rd time since the end of December. While driving the electric refuses to switch to gas after the battery drains, it is a hybrid. Maxes out at 18 mph and then an alarm goes off for Hybrid System error. First two time check engine light also came on. Have had vehicle towed to Kia dealerships all three times. Never the same thing repaired or replaced but problem stops for a few days to two weeks and then happens again. They vehicle has been examined and the issue has been replicated or examined by the Canton Kia dealership in Canton, MI two times. Currently at Taylor Kia Toledo, OH. This is a safety issue due to the lack of speed and acceleration. So far I have been in relatively low speed areas but what if it happened on the expressway or in heavy traffic. I normally have my kids in the car and now feel that my vehicle is unsafe and I have only had it 11 months.

NHTSA ID

11718991

Incident

Dec 26, 2025

1. I'm not sure what component or system malfunctioned. The dealership has said something different every time it's had to be taken in. The first time they said it could have been the dip stick. The second time they said they didn't know but did an update to the car's system. Last week, was the third time we've had to take it in and they said they are doing an oil change and replacing the air intake hose assy, GDI fuel pump, High pressure fuel pump, valve cover assy, oil filter and oil but didn't say if this would fix the issue. 2. We have loss confidence in this car's safety and reliability and the dealership's ability to repair it. It's been in the shop multiple times and continues to fail. The issue with the vehicle is that when we got a warning the power to the car shuts off. It doesn't allow you to do anything with the gas pedal no matter what speed you are going. We have experienced this multiple times on city streets and the highway. The potential for an accident is very high when the car does this. 3. We have taken it to the dealership and they don't know what's wrong with it. I created a case with Kia and have not heard back from a case manager at all. 4. The vehicle has only been inspected by the dealership and no one else. They have contacted Kia corporate for solutions via messaging but this is the third time the car has just loss power while we are driving. 5. There were some warning signs like check hybrid batter system on the dashboard. The kia Access app allow shows diagnostic alerts like ADAS_DRV. I have attached some photos and some of the documentation we have. There have been multiple dates but I put the first date that the car broke down. Other dates include (1/28/26 and 2/6/26).

NHTSA ID

11717334

Incident

Jan 16, 2026

The contact owns a 2025 Kia Sorento Hybrid. The contact stated that while driving approximately 65 MPH, the vehicle went into LIMP Mode, and the vehicle decelerated to 35 MPH. The vehicle was driven to the residence and was later towed to the local dealer. While at the dealer, the cause of the failure was not determined, and the failure had self-corrected. The vehicle was retrieved; however, approximately 1,500 miles late,r the failure reoccurred. The manufacturer was made aware of the failure. The failure mileage was 2,300.

NHTSA ID

11716775

Incident

Jul 9, 2025

Mileage

2,300 mi

I was driving onto a busy intersection from a parking lot. When I went to pull into traffic, the truck wouldnt go, it lost power and we coasted into oncoming traffic , I coasted right , and the dash flashed limited mode max speed 20 mph in yellow lights. The peddle was on the floor at that point. We had kids in the car and it was going 17 mpr in 55 mph cars on us swerving around us. I coasted at 17 mpr downgrade 2 miles before I could get a place to pull over. I turned it off and sat for a while. Turned it back on and it had power again. We made it to the house, I towed it to KIA next day, they claim no codes went off and nothing wrong with it. Cars that lose power entering freeways without warning tells me there is something seriously wrong. No problem prior. I leased it new. It has 5000 miles. Its been at kia since mid-december 2025. I contacted corporate and they said it doesn't trigger their warranty and they are done with it. I was told to bring it back when it happens again. I wont risk my life or others with this unrepaired truck. I worry for my family and others. We could of been killed.

NHTSA ID

11716361

Incident

Dec 15, 2025

Incident #1: Car suddenly and without warning had complete loss of power, with gas engine shutting off and only using battery power. Car was traveling at 45mph in morning traffic. Pedal was pushed to the floor, but car would only go a maximum of 20mph. Warning dash lights then appeared saying "Hybrid Malfunction/Pull Over Immediately/Turn off car". I was able to pull off road and turn off car and then turn back on. Car ran normally the 2 miles back home. Incident #2: 2 days later, while driving my kids to school the car again, suddenly and without warning had complete loss of power, with gas engine shutting off and only using battery power. Again, warning dash lights: "Check Hybrid System. Stop Safely!". I did so and car ran normally back to my house (distance approx: 2.5 miles). I immediately called KIA of Beaverton and they said to have it towed right away. Once at dealer, they were unable to diagnose any issues and said that no codes showed up, but also said that the car "deleted codes". Car was in shop for 2 days and determined "car operates as designed." I picked up the car. Incident #3: 7 days later, with kids in the car, again car had complete power loss with no warning. Warning lights again told of "Check Hybrid System. Stop Safely!" Pulled over (in heavy Friday rush hour traffic) and turned off car. Turned on again, but this time car drove for less than a quarter mile before complete power loss happened again with all warning lights. This time we took video of the car not having power, all the warning lights etc. as evidence. We turned off the car and upon turning it on, it instantly had no power. We pulled car over and had to park it that night at a local business for towing. Car was towed again to Beaverton KIA. Again, dealer said they were not able to replicate problem after driving 250 miles on it. Insisted we pick up car, despite numerous comm's saying how unsafe we felt taking it. Dealer claimed KIA told them to remove .5 Qt of oil.

NHTSA ID

11715726

Incident

Jan 13, 2026

Was driving home from work, and suddenly all the indicator lights came on on the dash, (check engine, warring lights, indicator that the battery was critically low, etc etc.) the car notified me to safely pull off the road. I pulled off the road in limp mode, the engine would not engage when pedal was pressed, and then lost power. I was stuck in the middle of the lane on a side road in park. I turned the car off, then turned it back on and let it idle for a bit thinking it may be the battery (which is new). After several minutes drove it home and have not had any other issues. I researched this issue on the internet and there were reported similar problems exactly like this. Note. I put it on a reader at home and it did not show any codes.

NHTSA ID

11713723

Incident

Jan 26, 2026

While driving, have had the engine of my 25 Sorento Hybrid stop working. An emergency notice comes on the screen (see photo) stating to pull over safely. The hybrid system error message has come on 4-5 times in the last month. The vehicle will not drive more than 15-20 miles per hour and has virtually no acceleration making it very dangerous to drive in or around high speed/traffic areas. Took it to a local Kia dealership where I was told nothing was wrong and their only guess was that it was related to the battery and cold weather. The same messaged/incident has happened 2x since bringing it into the dealership. With the most recent being 1/22/26. Problem first arose on 1/9/26. There are dozens of reports of this in online threads over the past few months with Kia hybrid engines

NHTSA ID

11712750

Incident

Jan 9, 2026

My wife first drove the vehicle and started noticing intense fumes entering the cabin which required rolling down the windows. There were no alerts from the car at this time or engine lights. We checked to see if the exhaust got plugged and it was not. I later drove the car that same day and it would not accelerate when I tried to right turn onto a main road. The check engine light then popped on and loud alerting from the vehicle cause me to have to pull over and shut the vehicle off. We had it towed by the dealer and the last thing we heard was that gas and oil had leaked together and it would take 5 days to get the part to fix it.

NHTSA ID

11709405

Incident

Jan 6, 2026

Will be driving when it switches to EV mode it will have no power and go into limp mode. Can't go over 30 mph. This is now the second time this has happened. Dealership tried to say it was because of temperature. Come on.

NHTSA ID

11708773

Incident

Jan 5, 2026

Beginning at approximately 750 miles on a brand-new 2025 Kia Sorento Hybrid EX, the vehicle experienced a flashing Check Engine Light accompanied by severe shaking while driving, rough idling, loss of power, and loud engine/exhaust noise. The vehicle became difficult and unsafe to operate due to the vibration and reduced drivability. These symptoms appeared suddenly on November 22, less than three weeks after purchase. The vehicle was taken to the dealership on November 24. Their technician retrieved diagnostic codes P0300 (Random Misfire) and P0304 (Cylinder #4 Misfire) and identified a failed ignition coil on Cylinder #4. The coil was replaced, and the dealership reported the issue resolved. However, less than 24 hours later, with the vehicle still under 800 miles, the exact same symptoms reoccurred: heavy shaking while driving, vibration while idling, loss of power, and unstable engine operation. This indicates the underlying issue may be more serious than a single coil failure. The problem has been reproduced and confirmed by the dealership, and the vehicle is currently back in their possession for further inspection. A loaner vehicle was issued because the vehicle was not safe to drive. The sudden shaking, engine misfire, and loss of power created a significant safety risk, especially if this failure were to occur at highway speeds or while turning across traffic. Given the extremely low mileage and recurrence immediately after repair, this may indicate a broader defect affecting engine performance or ignition components in this model. The vehicle remains available for inspection by NHTSA, the manufacturer, or investigators.

NHTSA ID

11702272

Incident

Nov 22, 2025

Safety Concern – 2025 Kia Sorento Prestige Hybrid (VIN [XXX] ) Around October 13, 2025, my leased 2025 Kia Sorento Prestige Hybrid experienced a sudden and severe loss of power while I was driving on the highway. The vehicle was towed to the dealership, where the High Power Control Unit (HPCU), part number 36601-3DPG3, was replaced. No clear explanation of the root cause was provided. Less than a month later, on November 6, the same failure occurred again—this time in heavy highway traffic—creating a serious safety risk and increasing the chance of a collision. The vehicle is primarily driven by my wife, who regularly uses highways to transport our son. The recurring and unpredictable nature of this issue has made us feel unsafe and anxious. We are deeply concerned that another failure could lead to a serious accident or fatality. We respectfully request that the National Highway Traffic Safety Administration (NHTSA) investigate this matter as a potential safety defect. Without a clear understanding of the cause, we are documenting these incidents to encourage action. It is critical that Kia resolves this issue to protect families and maintain trust in its brand. Thank you INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11698214

Incident

Oct 13, 2025