2004 Kia Sorento Owner Complaints

Crank pully bolt snapped. Causing crank pully to fall, and critical belts to fail.

NHTSA ID

11444487

Incident

Dec 20, 2021

THIS KIA WAS HOUSED AND STORED IN A GARAGE FOR MOST OF ITS LIFE AND DRIVEN ONLY IN THE SUMMER. IN THE WINTERS OF MICHIGAN IS WAS HOUSED IN A CLEAN DRY GARAGE. THIS KIA WAS A 2 OWNER CAR. I AM THE SECOND OWNER. I HAD DRIVEN IT ONE WINTER AND THIS SUMMER TOOK IT TO GET AN ALIGNMENT BECAUSE IT PULLED TO THE RIGHT. ALIGNMENT CENTER COULD NOT DO THE ALIGNMENT BECAUSE THE WHOLE RIGHT DRIVERSIDE OF THE FRAME WAS RUSTED OUT BEYOND THEIR SAFTY STANDARDS. THE KIA WAS PULLING TO THE RIGHT BECAUSE THE WHOLE FRAME ON THE RIGHT SIDE WAS 80% RUSTED OUT AND THE LEFT SIDE WAS ALSO BUT NOT TO THE EXTENT OF THE RIGHT SIDE. THERE ARE FOOT LONG GAPING HOLES IN THE FRAME DUE TO THE RUSTING. IT IS IRREPARABLE. THERE IS NO SAFE SPOT TO WELD TO TO FIX IT EITHER. AFTER A RAIN I NOTICED THE POOLS OF WATER GO DIRECTLY UNDER THE KIA INSTEAD OF ON THE SIDES POOLING AND DRIPPING OFF THE FRAME ON EACH RIGHT AND LEFT SIDE. A FLAW OF DESIGN BUT A DEADLY IF TRAVELLING AND THE CAR SNAPS IN HALF. THE KIA LOOKS PERFECT AND RUNS PERFECT. THE UNDERSIDE IT'S FRAME IS TOTALLY RUSTED BEYOND REPAIR. KEPT IN A GARAGE AND OUT OF ELEMENTS FOR VIRTUALLY ALL OF ITS LIFE, THIS SHOULD NOT HAVE HAPPENED. DEFECTIVE STEEL ? DEFECTIVE BODY DESIGN? DEFECTIVE KIA. NOT SAFE NOT DRIVABLE.

NHTSA ID

11351192

Incident

Jun 28, 2020

WHILE MY DAUGHTER WAS DRIVING ON THE HIGHWAY, THE BRAKES FAILED. THE MECHANIC SHOWED ME THE BRAKE LINES TOWARD THE REAR SUSPENSION RUSTED THROUGH. ALSO THE SUPPORT FOR THE REAREND RUSTED THROUGH MAKING THE VEHICLE DANGEROUS TO DRIVE. THE BRAKE LINES FROM FRONT TO BACK WERE CHANGED AND I AM LOOKING TO HAVE THE SUPPORT BRACKETS CHANGED.

NHTSA ID

11300856

Incident

Dec 30, 2019

Mileage

150,000 mi

2004 KIA SORRENTO 97,000 MILES. THE LEFT AND RIGHT SIDE REAR CONTROL ARM BRACKETS RUSTED OFF.

NHTSA ID

11298476

Incident

Dec 19, 2019

Mileage

97,000 mi

I BOUGHT MY 04 SORENTO FROM MY AUNT WHO WAS THE ONLY OWNER. IT HAD A POWER STEERING ISSUE AT THAT TIME WHICH TOOK SEVERAL ATTENPTS TO FIX. ABOUT A MONTH LATER WE WE VISITING FAMILY AND HAD TO TURN AROUND. UPON STOPPING WE NOTICED SMOKE FROM THE ENGINE COMPARTMENT SO I GRABBED MY 4 Y/O DAUGHTER OUT OF THE CAR AND BY BOYFRIEND OPENED THE HOOD TO FIND A SMALL FIRE ON OPPOSITE SIDE FRO WHERE BATTERY IS. ONCE FIRE WAS PUT OUT WE DROVE .5 MILES ON A CITY RD TO FAMILY. THE POWER STEERING WAS GONE AT THAT TIME AS WELL. 10/13/19 - THE DIRECTIONAL WORKED ALL DAY AND COME NIGHT TIME WHEN I CAME OUT FROM THE STORE AND STARTED VEHICLE THEY DID NOT WORK. THE NEXT DAY THEY WORKED FINEHOWEVER, ON 10/14/19 - I STARTED THE CAR IN AM AND THERE WAS A SQUEAKY BELT. I HIT THE GAS PEDAL QUICKLY AND NOISE WENT AWAY. THEN WHILE DRIVING, THE BATTERY AND BRAKE INDICATOR LIGHTS CAME ON THE DASH AND STAYED ON SO I PULLED OVER AND SHUT CAR OFF. IWAS DRIVING MY DAUGHTER TO THE PARK A MILE AWAY FROM HOME WHEN THE BATTERY AND BRAKE INDICATOR LIGHTS CAME ON AGAIN. I TURNED CAR OFF FOR A FEW MINUTES AND WHEN I RESTARTED IT THE LIGHTS WERE OFF. I WENT TO TURN AROUND TO GO HOME AND THE STEERING COMPLETELY FAILED SO IT WAS EXTREMELY DIFFICULT AND DANGEROUS. I HAVE NOT DRIVEN IT OR STARTED IT SINCE. MY MECHANIC CAMT TO MY HOME 2 DAYS IN A ROW AND WAS CONVINCED IT WAS CRANKSHAFT BOLT THAT SNAPPED. HE GOT IT INTO HIS SHOP THE FOLLOWING WEEK ON FRIDAY 10/26/19 AND CALLED A SHORT WHILE LATER INFORMING ME THAT IT WAS IN FACT THE CRANKSHAFT BOLT THAT SNAPPED DEEP IN THE SHAFT AND THE CRANKSHAFT WOULD NEED TO BE REPLACED FOR A COST OF AROUND $3000. I CALLED A FEW OTHER PLACES AND THEY SAID THE ENGINE WOULD NEED REPLACING WHICH WOULD COAT AROUND THE SAME. MY DAUGHTER AND I NOW HAVE NO VEHICLE AND ARE WALKING HER TO SCHOOL WHICH WILL BE DIFFICULT COME WINTER MONTHS.

NHTSA ID

11271165

Incident

Oct 13, 2019

Mileage

180,000 mi

OCT, 2016 - I AM THE ORIGNAL OWNER OF THE VEHICLE AND HAD MAINTAINED REGULAR MAINTAINENCE ON THE VEHICLE. I HAD JUST PUT $700 OF NEW TIRES ON VEHICLE AND HAD A ROUTINE OIL CHANGE AND FLUID CHECK BEFORE WE LEFT FOR OUR VACATION. I NEVER HAD ANY ISSUES WITH THE VEHICLE AND I STILL OWN. THE VEHICLE DOES NOT RUN BUT I WANTED TO KNOW WHAT STARTED THE FIRE. MY DAUGHTER AND I WERE HEADED OUT OF TOWN FOR A WEEK, ABOUT 200 MILES INTO THE COMMUTE THE FRONT OF THE VEHICLE BEGAN TO SMOKE FROM UNDER THE HOOD, WE WERE TRAVELING AT 55-60 MPH. AS I WAS EXITING THE 421 HIGHWAY FLAMES BEGAN COMING OUT FROM AROUND HOOD AND THE PAINT ON THE HOOD BEGAN TO BUBBLE UP DUE TO HEAT. I IMMEDIATELY CALLED THE FIRE DEPT, AS I WAS DRIVING, PULLED ONTO THE SHOULDER AND IMMEDIATELY REMOVED MY DAUGHTER AND OUR BELONGINGS FROM THE VEHICLE AND DISTANCED OURSELVES FROM THE VEHICLE. WHEN THE FIRE DEPT ARRIVED THEY PUT THE FLAMES OUT AND THE VEHICLE WAS TRANSPORTED TO A LOCAL SHOP, I HAD THE VEHICLE TOWED BACK TO OUR HOME CITY UPON DEPARTURE FROM OUR VACATION. UPON FURTHER OBSERVATION I WAS ABLE TO SEE THE FIRE STARTED IN THE AREA CLOSEST TO WHERE THE ENGINE MEETS THE DASH ON THE DRIVERS SIDE AND CONTINUED TO SPREAD FROM THAT POINT TO THE FRONT OF THE VEHICLE AND UNDER ON THE DRIVERS SIDE.

NHTSA ID

11269088

Incident

Oct 4, 2016

Mileage

140,000 mi

I WAS DRIVING WHEN I HEARD A CLUNKING NOISE, AND MY TRUCK SHIFTED. SO I PULLED OVER TO SEE THE MY REAR LOWER ARM FELL FROM SUBFRAME CORRSION DUE TO HEAVY SALT USE HERE IN WI. I HAD TO GET CAR TOWED HOME.

NHTSA ID

11266654

Incident

Oct 2, 2019

Mileage

133,346 mi

"TAKATA RECALL" I BOUGHT THIS CAR JUST RECENTLY AND THE DRIVERS SIDE AIR BAG STAYS ON ALL THE TIME THERE HAVE BEEN RECALLS BUT NOT ON MY CAR IS IT SAFE TO DRIVE THIS LIKE THIS OR IS IT DANGEROUS AND THE FACTORY SHOULD SEND OUT A RECALL ON THIS RIGHT !

NHTSA ID

11252535

Incident

Aug 9, 2019

TAKATA RECALL AIR BAG LIGHT IS ON THE DASH CAN I GET THIS REPLACED FOR NO CHARGE LIGHT STAYS ON ALL THE TIME.

NHTSA ID

11252136

Incident

Aug 9, 2019

WHILE DRIVING MY VEHICLE AT 65MPG ON THE HIGHWAY WITH MY BABY IN THE CAR, THE STEERING JERKED TO THE LEFT. I ALMOST CRASHED INTO A DESIEL TRUCK !! I THEN CORRECT IT AND PULLED OVER. I DROPPED MY SON OFF AT MY MOM'S HOME AND WENT TO THE GARAGE TO HAVE IT LOOKED AT. ON THE WAY, IT LOST ALL POWER STEERING AND I COULD NOT TURN CORRECTLY. SOMEONE HIT THE BACK OF MY CAR AND SHOVED IT INTO ANOTHER VEHICLE IN THE FRONT. SO NOW MY BACK AND FRON IN LOOKS LIKE CRAP AND I HAVE NO POWER STEERING.. BUT MY SON AND I ARE STILL ALIVE.. WHEN RESEARCHING THIS ISSUE, I FOUND OUT IT WAS NOT MY FAULT OR MY CAR.. THIS IS A FAULTY MANUFACTURE SAFTY ISSUE THAT HAS NOT EVEN BEEN RESEARCHED YET !! THERE HAVE BEEN SO MANY CUSTOMER COMPLAINTS ABOUT THE DANGER OF THIS VEHICLE AND THIS ISSUE I CAN NOT BELIEVE IT'S STILL ON THE ROAD. HTTPS://WWW.CARCOMPLAINTS.COM/KIA/SORENTO/2004/STEERING/STEERING.SHTML AND TO FIND OUT THE STATE WAS AWARE OF IT AND JUST NEVER EVEN LOOKED INTO PROTECTING US. THIS IS A DANGER AND NEEDS TO BE RECALLED ASAP BEFORE SOMEONE LOOSES THEIR LIFE AND THE LIFE OF THEIR CHILD LIKE I ALMOST DID !!!!

NHTSA ID

11206123

Incident

Apr 1, 2019

Mileage

120,000 mi

MY SORENTO WAS IN PARK RUNNING IN MY DRIVEWAY STARTED SMOKING AND CAUGHT FIRE AND BURNED UP IN A MATTER OF MINUTES. I'M AWARE OF RECALLS WITH KIA VEHICLES CATCHING FIRE. I WOULD LIKE THIS TO BE ADDRESSED AND INVESTIGATED AS I FEEL IT WAS DUE TO A MALFUNCTION. 911 WAS CALLED AND THE FIRE DEPARTMENT CAME TO DISTINGUISH THE CAR IT IS A TOTAL LOSS.

NHTSA ID

11185552

Incident

Feb 15, 2019

Mileage

253,701 mi

THEY HAD A RECALL AND A LAWSUIT ON THE KIA FOR THE PULLEY BOLT KEEPS BREAKING AND I NEVER GOT A NOTICE AND MINE KEEPS BREAKING AND KIA WON'T DO ANYTHING ABOUT IT.

NHTSA ID

11183151

Incident

May 12, 2008

I HAVE FIXED MY PULLEY BOLT 3 TIME AND IT KEEP BRAKING AND I DON'T KNOW WHAT ELSE TO DO TO FIX THE PROBLEM

NHTSA ID

11170812

Incident

Nov 15, 2018

2004 KIA SORENTO EX WITH EXTENSIVE RUST DAMAGE TO REAR CROSS-MEMBERS #2 AND #3. DISCOVERED DURING TIRE ROTATION IN NOV 2018, BUT IS OBVIOUS THE DAMAGE HAS EXISTED FOR A SUBSTANTIAL AMOUNT OF TIME. CROSS-MEMBER #2 IS JUST IN FRONT AND ABOVE THE REAR AXLE AND HAS THE MOUNTING BRACKETS FOR THE AXLE STRUTS, WHICH KEEP THE AXLE IN PLACE, IT ALSO HAS A MOUNTING BRACKET FOR THE FUEL TANK, AS WELL AS A PASS THROUGH BRACKET FOR THE REAR BRAKE LINES, AND A MUFFLER HANGER. THE CAR IS NOT SAFE TO BE DRIVEN DUE TO THE IMMINENT DANGER OF A FULL FAILURE. CROSS-MEMBER #2 IS ABOUT 70% RUSTED THROUGH ON THE FUEL TANK SIDE AND PERFORATED IN SEVERAL OTHER PLACES AS WELL. CROSSMEMBER #3 WHICH IS BEHIND THE REAR AXLE CONTAINS NO MOUNTS, BUT A TORSION BAR DOES CONNECT WHERE THE CROSS-MEMBER PASSES THROUGH THE LEFT FRAME RAIL. STRUT MOUNT CONNECTORS ON AXLE ARE ALSO SEVERELY RUSTED. BACKING PLATE FOR REAR DISC BRAKES ON BOTH SIDES IS RUSTED SO SEVERELY THEY CRUMBLE LIKE AN EGGSHELL. CONTACTED KIA AND THEY SAID THEY WILL NOT COVER REPAIR OF THE DEFECT, CASE #12944853 OPENED. IT ONLY TAKES A QUICK SEARCH ONLINE TO FIND THERE ARE MANY CASES OF THIS WITH PARTICULARLY 2004 MODELS.

NHTSA ID

11153412

Incident

Nov 16, 2018

TOOK MY CAR IN FOR NYS INSPECTION AND WAS ALERTED TO AN ISSUE WITH MY REAR SUSPENSION. THE REAR CROSS MEMBER IS COMPLETED ROTTED OUT AND THE UPPER TRAILING ARM HAVE BECOME SEPARATED FROM THE CROSS MEMBER DUE TO RUST AND CORROSION. THIS IS A 2004 KIA SORENTO EX THAT I PURCHASED NEW AND NOW HAS 103,000 MILES. THIS CORROSION IS AN EXTREMELY HAZARDOUS SITUATION AND THE VEHICLE CANNOT BE REPAIRED. NEEDLESS TO SAY IT CANNOT BE DRIVEN.

NHTSA ID

11132949

Incident

Oct 2, 2018

Mileage

103,000 mi

VEHICLE CAUGHT FIRE WHILE STATIONARY. FIRE STARTED IN FRONT COMPARTMENT NEAR FUSES. TOTAL LOSS

NHTSA ID

11129141

Incident

Aug 16, 2016

Mileage

124,000 mi

IT DRIVES FINE THEN ALL OF A SUDDEN FOOT SAME POSITION ON GAS PETAL IT ACCELERATES.

NHTSA ID

11122307

Incident

Mar 24, 2018

UNINTENDED ACCELERATION. RPM WOULD RANGE FROM 1000 TO AS HIGH AS 2000 RPM WITHOUT WARNING. IAC VALVE WAS REPLACED AND DID NOT RESOLVE THE PROBLEM. FINAL DIAGNOSIS WAS CRUISE CONTROL RANDOMLY OPERATING. DISCONNECTED CRUISE CABLE AT THE THROTTLE BODY. PROBLEM CEASED. GREEN LIGHT ON CRUISE SWITCH NEVER INDICATED IT WAS OPERATING. VEHICLE WAS OPERATING AS WELL AS STOPPED AT LIGHTS WHEN THIS OCCURRED.

NHTSA ID

11119718

Incident

Aug 1, 2018

Mileage

71,000 mi

THE INTERIOR LIGHTS DO NOT STAY ON THE WHEEL I HAVE TO PLAY WITH IT TO GET THEM TO COME ON AND THEY GO OFF ALL THE TIME WHICH IS VERY DANGEROUS DRIVING AT NIGHT. AND MY LOW BEAMS DO NOT WORK AT ALL I HAVE TO DRIVE WITH HIGH BEAMS ON.

NHTSA ID

11114047

Incident

Apr 18, 1917

Mileage

8,200 mi

WAS DRIVING WIFE TO WORK , STOPPED AT LIGHT WHEN LIGHT TURNED GREEN I PUSHED THE GAS PEDAL AND I HEARD A BANG SO LOUD I THOUGHT SOMEONE HIT US FROM BEHIND. I DROVE CAR HOME AND LOOKED UNDER IT AND I COULDN'T BELIEVE IT ! THE RUST ON THE REAR END BRACKETS AND THE TWO BARS CONNECTED TO THEM WERE TOTALLY RUSTED THROUGH AND HANGING OFF. I WENT TO THE KIA DEALER WHERE I ORIGINALLY BOUGHT THE CAR AND ASKED THEM ABOUT IT THEY SAID THEY NEVER HEARD OF THAT PROBLEM. I TOLD THEM THERE ARE HUNDREDS OF COMPLAINTS ON THE INTERNET ABOUT IT ,THEY TOLD ME DON'T BELIEVE EVERYTHING YOU SEE ON THE INTERNET. THEN THEY SAID THAT IT'S NOT A KIA PROBLEM IT'S A ROAD SALT PROBLEM. I TOLD THEM NOTHING ELSE UNDER THE CAR WAS RUSTED THAT BAD , AND I BELIEVE IT'S A DESIGN PROBLEM. THEY SAID THERE IS NOTHING THEY CAN DO, SO NOW I HAVE A CAR WITH ONLY 83,000 MILES ON IT THAT IS TOO DANGEROUS TO DRIVE. THIS PROBLEM HAD TO HAVE STARTED WAY WAY BEFORE 83,000 MILES TO HAVE GOTTEN THIS BAD.

NHTSA ID

11103610

Incident

Mar 31, 2018

Mileage

83,000 mi

WHILE DRIVING APPROXIMATELY 35 MPH, THE REAR OF THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO NOTICED THAT THE CROSSMEMBER BARS WERE SEVERELY CORRODED THROUGH AND WERE NOT ABLE TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. MAJOR SAFETY HAZARD. THE ENTIRE BRACKET HOLDING THE DIFFERENTIAL RUSTED THROUGH. THE FRAME REAR CROSS MEMBER ALSO RUSTED THROUGH CAUSING THE CONTROL ARMS IS DETACHED FROM THE REAR END ALSO CREATING A SAFETY HAZARD.

NHTSA ID

11073051

Incident

Feb 14, 2018

Mileage

100,000 mi

THE ELECTRICAL SYSTEM GOES HAYWIRE. WE WILL BE DRIVING ALONG AND THE INTERIOR LIGHTS COME ON, THE FRONT DOORS OPEN LIGHTS COME ON AND STARTS BUZZING AND SO DOES THE THE LOCKING MECHANISM ON THE DOORS. WE CHECK TO MAKE SURE THE DOORS ARE CLOSED PROPERLY BUT THEY ALWAYS ARE. THIS IS WHEN THE CAR IS IN MOTION USUALLY BUT SOMETIMES WHILE STATIONARY AS WELL. SOMETIMES THE DOORS UNLOCK TOO. WE HAVE NO IDEA WHAT CAUSED THIS BUT FEEL IT IS A SAFETY HAZARD AS WELL AS A NUISANCE WHILE DRIVING. IT NEVER SEEMS TO MATTER IF YOU ARE DRIVING STRAIGHT OR TURNING.. WE HAVEN'T TAKEN IT ANYWHERE FOR REPAIRS YET, BECAUSE IT SEEMS TO BE ELECTRICAL AND KNOW THAT IT CAN BE EXPENSIVE.

NHTSA ID

11072753

Incident

Oct 2, 2017

MY DAUGHTER TOOK MY CAR A 2004 KIA SORENTO IN FOR A NYSI AND THE SHOP DEAD LINED THE CAR AND MADE ME FLATBED IT HOME DUE TO THE FACT THAT THE REAR END WAS FALLING OUT DUE TO EXCESSIVE ROT ON THE BRACKETS AND THEY DEEMED THE CAR UNSAFE TO DRIVE. THE WOMEN THAT RUNS THE SHOP TOLD MY DAUGHTER AND SON THAT THIS ISN'T THE FIRST TIME THAT SHE HAS SEEN THIS ON A KIA. IN FACT ITS A PREVALENT ISSUE! UPON COMING HOME I DID SOME RESEARCH ON THE INTERNET AND FOUND THAT THIS IS A MAJOR ISSUE THAT THE FEDERAL GOVERNMENT SHOULD BE LOOKING INTO ORDERING KIA TO DO A RECALL,MY DAUGHTER COULD HAVE BEEN KILLED DRIVING THIS VEHICLE.I ALSO SAW ON THE INTERNET THAT IN THE UK KIA HAD TAKEN CARE OF THIS ISSUE WITH CONSUMERS. I WOULD LIKE CONSIDERATION IN HAVING KIA REPAIR THIS CAR FREE OR PURCHACE THE VEHICLE BACK AT BLUE BOOK PRICING. THIS IS AN EXTREMELY DANGEROUS ISSUE THAT COULD HAVE KILLED MY DAUGHTER OR ANYONE ELSE ON THE ROAD WHERE MY DAUGHTER WAS DRIVING THE KIA SORENTO.

NHTSA ID

11067017

Incident

Jan 31, 2018

Mileage

166,230 mi

TL* THE CONTACT OWNS A 2004 KIA SORENTO. WHILE DRIVING APPROXIMATELY 30 MPH, THE POWER STEERING AND BRAKES SUDDENLY MALFUNCTIONED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CAMSHAFT PULLEY WAS FAULTY AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND THE LOCAL DEALER (QUIRK KIA IN BRANKLY, MA) WERE NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 99,000. *LN

NHTSA ID

11034078

Incident

Oct 6, 2017

Mileage

99,000 mi

THE REAR AXLE IS FALLING APART AND IT'S RUSTED WHERE I CAN'T EVEN WELD A BRACKET FOR THE REAR SUSPENSION IT'S SO RUSTED THAT I WAS TOLD BY A MECHANIC THAT THE REAR AXLE CAN ACTUALLY FALL OFF THE VEHICLE I WOULD HAVE TO REPLACE THE ENTIRE REAR AXLE SO I CAN PUT A BRACKET OR IT WILL COME WITH A BRACKET IT WILL COST ME $4000 AND I THINK A KIA SHOULD BE RESPONSIBLE BECAUSE THE WHOLE ENTIRE CAR UNDERNEATH IT RUSTED BUCKET FULL OF RUST

NHTSA ID

11023841

Incident

Sep 10, 2017