2004 Kia Sorento Problems

I BOUGHT MY 04 SORENTO FROM MY AUNT WHO WAS THE ONLY OWNER. IT HAD A POWER STEERING ISSUE AT THAT TIME WHICH TOOK SEVERAL ATTENPTS TO FIX. ABOUT A MONTH LATER WE WE VISITING FAMILY AND HAD TO TURN AROUND. UPON STOPPING WE NOTICED SMOKE FROM THE ENGINE COMPARTMENT SO I GRABBED MY 4 Y/O DAUGHTER OUT OF THE CAR AND BY BOYFRIEND OPENED THE HOOD TO FIND A SMALL FIRE ON OPPOSITE SIDE FRO WHERE BATTERY IS. ONCE FIRE WAS PUT OUT WE DROVE .5 MILES ON A CITY RD TO FAMILY. THE POWER STEERING WAS GONE AT THAT TIME AS WELL. 10/13/19 - THE DIRECTIONAL WORKED ALL DAY AND COME NIGHT TIME WHEN I CAME OUT FROM THE STORE AND STARTED VEHICLE THEY DID NOT WORK. THE NEXT DAY THEY WORKED FINEHOWEVER, ON 10/14/19 - I STARTED THE CAR IN AM AND THERE WAS A SQUEAKY BELT. I HIT THE GAS PEDAL QUICKLY AND NOISE WENT AWAY. THEN WHILE DRIVING, THE BATTERY AND BRAKE INDICATOR LIGHTS CAME ON THE DASH AND STAYED ON SO I PULLED OVER AND SHUT CAR OFF. IWAS DRIVING MY DAUGHTER TO THE PARK A MILE AWAY FROM HOME WHEN THE BATTERY AND BRAKE INDICATOR LIGHTS CAME ON AGAIN. I TURNED CAR OFF FOR A FEW MINUTES AND WHEN I RESTARTED IT THE LIGHTS WERE OFF. I WENT TO TURN AROUND TO GO HOME AND THE STEERING COMPLETELY FAILED SO IT WAS EXTREMELY DIFFICULT AND DANGEROUS. I HAVE NOT DRIVEN IT OR STARTED IT SINCE. MY MECHANIC CAMT TO MY HOME 2 DAYS IN A ROW AND WAS CONVINCED IT WAS CRANKSHAFT BOLT THAT SNAPPED. HE GOT IT INTO HIS SHOP THE FOLLOWING WEEK ON FRIDAY 10/26/19 AND CALLED A SHORT WHILE LATER INFORMING ME THAT IT WAS IN FACT THE CRANKSHAFT BOLT THAT SNAPPED DEEP IN THE SHAFT AND THE CRANKSHAFT WOULD NEED TO BE REPLACED FOR A COST OF AROUND $3000. I CALLED A FEW OTHER PLACES AND THEY SAID THE ENGINE WOULD NEED REPLACING WHICH WOULD COAT AROUND THE SAME. MY DAUGHTER AND I NOW HAVE NO VEHICLE AND ARE WALKING HER TO SCHOOL WHICH WILL BE DIFFICULT COME WINTER MONTHS.

OCT, 2016 - I AM THE ORIGNAL OWNER OF THE VEHICLE AND HAD MAINTAINED REGULAR MAINTAINENCE ON THE VEHICLE. I HAD JUST PUT $700 OF NEW TIRES ON VEHICLE AND HAD A ROUTINE OIL CHANGE AND FLUID CHECK BEFORE WE LEFT FOR OUR VACATION. I NEVER HAD ANY ISSUES WITH THE VEHICLE AND I STILL OWN. THE VEHICLE DOES NOT RUN BUT I WANTED TO KNOW WHAT STARTED THE FIRE. MY DAUGHTER AND I WERE HEADED OUT OF TOWN FOR A WEEK, ABOUT 200 MILES INTO THE COMMUTE THE FRONT OF THE VEHICLE BEGAN TO SMOKE FROM UNDER THE HOOD, WE WERE TRAVELING AT 55-60 MPH. AS I WAS EXITING THE 421 HIGHWAY FLAMES BEGAN COMING OUT FROM AROUND HOOD AND THE PAINT ON THE HOOD BEGAN TO BUBBLE UP DUE TO HEAT. I IMMEDIATELY CALLED THE FIRE DEPT, AS I WAS DRIVING, PULLED ONTO THE SHOULDER AND IMMEDIATELY REMOVED MY DAUGHTER AND OUR BELONGINGS FROM THE VEHICLE AND DISTANCED OURSELVES FROM THE VEHICLE. WHEN THE FIRE DEPT ARRIVED THEY PUT THE FLAMES OUT AND THE VEHICLE WAS TRANSPORTED TO A LOCAL SHOP, I HAD THE VEHICLE TOWED BACK TO OUR HOME CITY UPON DEPARTURE FROM OUR VACATION. UPON FURTHER OBSERVATION I WAS ABLE TO SEE THE FIRE STARTED IN THE AREA CLOSEST TO WHERE THE ENGINE MEETS THE DASH ON THE DRIVERS SIDE AND CONTINUED TO SPREAD FROM THAT POINT TO THE FRONT OF THE VEHICLE AND UNDER ON THE DRIVERS SIDE.

2004 KIA SORRENTO 97,000 MILES. THE LEFT AND RIGHT SIDE REAR CONTROL ARM BRACKETS RUSTED OFF.

2004 KIA SORENTO EX WITH EXTENSIVE RUST DAMAGE TO REAR CROSS-MEMBERS #2 AND #3. DISCOVERED DURING TIRE ROTATION IN NOV 2018, BUT IS OBVIOUS THE DAMAGE HAS EXISTED FOR A SUBSTANTIAL AMOUNT OF TIME. CROSS-MEMBER #2 IS JUST IN FRONT AND ABOVE THE REAR AXLE AND HAS THE MOUNTING BRACKETS FOR THE AXLE STRUTS, WHICH KEEP THE AXLE IN PLACE, IT ALSO HAS A MOUNTING BRACKET FOR THE FUEL TANK, AS WELL AS A PASS THROUGH BRACKET FOR THE REAR BRAKE LINES, AND A MUFFLER HANGER. THE CAR IS NOT SAFE TO BE DRIVEN DUE TO THE IMMINENT DANGER OF A FULL FAILURE. CROSS-MEMBER #2 IS ABOUT 70% RUSTED THROUGH ON THE FUEL TANK SIDE AND PERFORATED IN SEVERAL OTHER PLACES AS WELL. CROSSMEMBER #3 WHICH IS BEHIND THE REAR AXLE CONTAINS NO MOUNTS, BUT A TORSION BAR DOES CONNECT WHERE THE CROSS-MEMBER PASSES THROUGH THE LEFT FRAME RAIL. STRUT MOUNT CONNECTORS ON AXLE ARE ALSO SEVERELY RUSTED. BACKING PLATE FOR REAR DISC BRAKES ON BOTH SIDES IS RUSTED SO SEVERELY THEY CRUMBLE LIKE AN EGGSHELL. CONTACTED KIA AND THEY SAID THEY WILL NOT COVER REPAIR OF THE DEFECT, CASE #12944853 OPENED. IT ONLY TAKES A QUICK SEARCH ONLINE TO FIND THERE ARE MANY CASES OF THIS WITH PARTICULARLY 2004 MODELS.

Crank pully bolt snapped. Causing crank pully to fall, and critical belts to fail.

CRANKSHAFT BOLT BROKE WITH APPROX 75,000 MILES. KIA ISSUED SERVICE BULLETIN AND REPLACED THE BOLT. BUT THE MOTOR WAS DESTROYED WHEN IT BROKE AND CONTINUOUSLY OVERHEATED AND WAS UNDRIVABLE. IT REQUIRED A NEW MOTOR. NOT HAVING $ TO REPLACE MOTOR & KIAS ZERO ACCOUNTABILITY. VEHICLE SAT AT A REPAIR SHOP FOR 2 YEARS & THEY FILED FOR AN ABANDONED TITLE. AT THE TIME VALUED AT APPROX $7500. WASTED!!!! THANKS KIA!

THIS KIA WAS HOUSED AND STORED IN A GARAGE FOR MOST OF ITS LIFE AND DRIVEN ONLY IN THE SUMMER. IN THE WINTERS OF MICHIGAN IS WAS HOUSED IN A CLEAN DRY GARAGE. THIS KIA WAS A 2 OWNER CAR. I AM THE SECOND OWNER. I HAD DRIVEN IT ONE WINTER AND THIS SUMMER TOOK IT TO GET AN ALIGNMENT BECAUSE IT PULLED TO THE RIGHT. ALIGNMENT CENTER COULD NOT DO THE ALIGNMENT BECAUSE THE WHOLE RIGHT DRIVERSIDE OF THE FRAME WAS RUSTED OUT BEYOND THEIR SAFTY STANDARDS. THE KIA WAS PULLING TO THE RIGHT BECAUSE THE WHOLE FRAME ON THE RIGHT SIDE WAS 80% RUSTED OUT AND THE LEFT SIDE WAS ALSO BUT NOT TO THE EXTENT OF THE RIGHT SIDE. THERE ARE FOOT LONG GAPING HOLES IN THE FRAME DUE TO THE RUSTING. IT IS IRREPARABLE. THERE IS NO SAFE SPOT TO WELD TO TO FIX IT EITHER. AFTER A RAIN I NOTICED THE POOLS OF WATER GO DIRECTLY UNDER THE KIA INSTEAD OF ON THE SIDES POOLING AND DRIPPING OFF THE FRAME ON EACH RIGHT AND LEFT SIDE. A FLAW OF DESIGN BUT A DEADLY IF TRAVELLING AND THE CAR SNAPS IN HALF. THE KIA LOOKS PERFECT AND RUNS PERFECT. THE UNDERSIDE IT'S FRAME IS TOTALLY RUSTED BEYOND REPAIR. KEPT IN A GARAGE AND OUT OF ELEMENTS FOR VIRTUALLY ALL OF ITS LIFE, THIS SHOULD NOT HAVE HAPPENED. DEFECTIVE STEEL ? DEFECTIVE BODY DESIGN? DEFECTIVE KIA. NOT SAFE NOT DRIVABLE.

WHILE MY DAUGHTER WAS DRIVING ON THE HIGHWAY, THE BRAKES FAILED. THE MECHANIC SHOWED ME THE BRAKE LINES TOWARD THE REAR SUSPENSION RUSTED THROUGH. ALSO THE SUPPORT FOR THE REAREND RUSTED THROUGH MAKING THE VEHICLE DANGEROUS TO DRIVE. THE BRAKE LINES FROM FRONT TO BACK WERE CHANGED AND I AM LOOKING TO HAVE THE SUPPORT BRACKETS CHANGED.

I BOUGHT MY 04 SORENTO FROM MY AUNT WHO WAS THE ONLY OWNER. IT HAD A POWER STEERING ISSUE AT THAT TIME WHICH TOOK SEVERAL ATTENPTS TO FIX. ABOUT A MONTH LATER WE WE VISITING FAMILY AND HAD TO TURN AROUND. UPON STOPPING WE NOTICED SMOKE FROM THE ENGINE COMPARTMENT SO I GRABBED MY 4 Y/O DAUGHTER OUT OF THE CAR AND BY BOYFRIEND OPENED THE HOOD TO FIND A SMALL FIRE ON OPPOSITE SIDE FRO WHERE BATTERY IS. ONCE FIRE WAS PUT OUT WE DROVE .5 MILES ON A CITY RD TO FAMILY. THE POWER STEERING WAS GONE AT THAT TIME AS WELL. 10/13/19 - THE DIRECTIONAL WORKED ALL DAY AND COME NIGHT TIME WHEN I CAME OUT FROM THE STORE AND STARTED VEHICLE THEY DID NOT WORK. THE NEXT DAY THEY WORKED FINEHOWEVER, ON 10/14/19 - I STARTED THE CAR IN AM AND THERE WAS A SQUEAKY BELT. I HIT THE GAS PEDAL QUICKLY AND NOISE WENT AWAY. THEN WHILE DRIVING, THE BATTERY AND BRAKE INDICATOR LIGHTS CAME ON THE DASH AND STAYED ON SO I PULLED OVER AND SHUT CAR OFF. IWAS DRIVING MY DAUGHTER TO THE PARK A MILE AWAY FROM HOME WHEN THE BATTERY AND BRAKE INDICATOR LIGHTS CAME ON AGAIN. I TURNED CAR OFF FOR A FEW MINUTES AND WHEN I RESTARTED IT THE LIGHTS WERE OFF. I WENT TO TURN AROUND TO GO HOME AND THE STEERING COMPLETELY FAILED SO IT WAS EXTREMELY DIFFICULT AND DANGEROUS. I HAVE NOT DRIVEN IT OR STARTED IT SINCE. MY MECHANIC CAMT TO MY HOME 2 DAYS IN A ROW AND WAS CONVINCED IT WAS CRANKSHAFT BOLT THAT SNAPPED. HE GOT IT INTO HIS SHOP THE FOLLOWING WEEK ON FRIDAY 10/26/19 AND CALLED A SHORT WHILE LATER INFORMING ME THAT IT WAS IN FACT THE CRANKSHAFT BOLT THAT SNAPPED DEEP IN THE SHAFT AND THE CRANKSHAFT WOULD NEED TO BE REPLACED FOR A COST OF AROUND $3000. I CALLED A FEW OTHER PLACES AND THEY SAID THE ENGINE WOULD NEED REPLACING WHICH WOULD COAT AROUND THE SAME. MY DAUGHTER AND I NOW HAVE NO VEHICLE AND ARE WALKING HER TO SCHOOL WHICH WILL BE DIFFICULT COME WINTER MONTHS.

OCT, 2016 - I AM THE ORIGNAL OWNER OF THE VEHICLE AND HAD MAINTAINED REGULAR MAINTAINENCE ON THE VEHICLE. I HAD JUST PUT $700 OF NEW TIRES ON VEHICLE AND HAD A ROUTINE OIL CHANGE AND FLUID CHECK BEFORE WE LEFT FOR OUR VACATION. I NEVER HAD ANY ISSUES WITH THE VEHICLE AND I STILL OWN. THE VEHICLE DOES NOT RUN BUT I WANTED TO KNOW WHAT STARTED THE FIRE. MY DAUGHTER AND I WERE HEADED OUT OF TOWN FOR A WEEK, ABOUT 200 MILES INTO THE COMMUTE THE FRONT OF THE VEHICLE BEGAN TO SMOKE FROM UNDER THE HOOD, WE WERE TRAVELING AT 55-60 MPH. AS I WAS EXITING THE 421 HIGHWAY FLAMES BEGAN COMING OUT FROM AROUND HOOD AND THE PAINT ON THE HOOD BEGAN TO BUBBLE UP DUE TO HEAT. I IMMEDIATELY CALLED THE FIRE DEPT, AS I WAS DRIVING, PULLED ONTO THE SHOULDER AND IMMEDIATELY REMOVED MY DAUGHTER AND OUR BELONGINGS FROM THE VEHICLE AND DISTANCED OURSELVES FROM THE VEHICLE. WHEN THE FIRE DEPT ARRIVED THEY PUT THE FLAMES OUT AND THE VEHICLE WAS TRANSPORTED TO A LOCAL SHOP, I HAD THE VEHICLE TOWED BACK TO OUR HOME CITY UPON DEPARTURE FROM OUR VACATION. UPON FURTHER OBSERVATION I WAS ABLE TO SEE THE FIRE STARTED IN THE AREA CLOSEST TO WHERE THE ENGINE MEETS THE DASH ON THE DRIVERS SIDE AND CONTINUED TO SPREAD FROM THAT POINT TO THE FRONT OF THE VEHICLE AND UNDER ON THE DRIVERS SIDE.

I BOUGHT MY 04 SORENTO FROM MY AUNT WHO WAS THE ONLY OWNER. IT HAD A POWER STEERING ISSUE AT THAT TIME WHICH TOOK SEVERAL ATTENPTS TO FIX. ABOUT A MONTH LATER WE WE VISITING FAMILY AND HAD TO TURN AROUND. UPON STOPPING WE NOTICED SMOKE FROM THE ENGINE COMPARTMENT SO I GRABBED MY 4 Y/O DAUGHTER OUT OF THE CAR AND BY BOYFRIEND OPENED THE HOOD TO FIND A SMALL FIRE ON OPPOSITE SIDE FRO WHERE BATTERY IS. ONCE FIRE WAS PUT OUT WE DROVE .5 MILES ON A CITY RD TO FAMILY. THE POWER STEERING WAS GONE AT THAT TIME AS WELL. 10/13/19 - THE DIRECTIONAL WORKED ALL DAY AND COME NIGHT TIME WHEN I CAME OUT FROM THE STORE AND STARTED VEHICLE THEY DID NOT WORK. THE NEXT DAY THEY WORKED FINEHOWEVER, ON 10/14/19 - I STARTED THE CAR IN AM AND THERE WAS A SQUEAKY BELT. I HIT THE GAS PEDAL QUICKLY AND NOISE WENT AWAY. THEN WHILE DRIVING, THE BATTERY AND BRAKE INDICATOR LIGHTS CAME ON THE DASH AND STAYED ON SO I PULLED OVER AND SHUT CAR OFF. IWAS DRIVING MY DAUGHTER TO THE PARK A MILE AWAY FROM HOME WHEN THE BATTERY AND BRAKE INDICATOR LIGHTS CAME ON AGAIN. I TURNED CAR OFF FOR A FEW MINUTES AND WHEN I RESTARTED IT THE LIGHTS WERE OFF. I WENT TO TURN AROUND TO GO HOME AND THE STEERING COMPLETELY FAILED SO IT WAS EXTREMELY DIFFICULT AND DANGEROUS. I HAVE NOT DRIVEN IT OR STARTED IT SINCE. MY MECHANIC CAMT TO MY HOME 2 DAYS IN A ROW AND WAS CONVINCED IT WAS CRANKSHAFT BOLT THAT SNAPPED. HE GOT IT INTO HIS SHOP THE FOLLOWING WEEK ON FRIDAY 10/26/19 AND CALLED A SHORT WHILE LATER INFORMING ME THAT IT WAS IN FACT THE CRANKSHAFT BOLT THAT SNAPPED DEEP IN THE SHAFT AND THE CRANKSHAFT WOULD NEED TO BE REPLACED FOR A COST OF AROUND $3000. I CALLED A FEW OTHER PLACES AND THEY SAID THE ENGINE WOULD NEED REPLACING WHICH WOULD COAT AROUND THE SAME. MY DAUGHTER AND I NOW HAVE NO VEHICLE AND ARE WALKING HER TO SCHOOL WHICH WILL BE DIFFICULT COME WINTER MONTHS.

WHILE DRIVING MY VEHICLE AT 65MPG ON THE HIGHWAY WITH MY BABY IN THE CAR, THE STEERING JERKED TO THE LEFT. I ALMOST CRASHED INTO A DESIEL TRUCK !! I THEN CORRECT IT AND PULLED OVER. I DROPPED MY SON OFF AT MY MOM'S HOME AND WENT TO THE GARAGE TO HAVE IT LOOKED AT. ON THE WAY, IT LOST ALL POWER STEERING AND I COULD NOT TURN CORRECTLY. SOMEONE HIT THE BACK OF MY CAR AND SHOVED IT INTO ANOTHER VEHICLE IN THE FRONT. SO NOW MY BACK AND FRON IN LOOKS LIKE CRAP AND I HAVE NO POWER STEERING.. BUT MY SON AND I ARE STILL ALIVE.. WHEN RESEARCHING THIS ISSUE, I FOUND OUT IT WAS NOT MY FAULT OR MY CAR.. THIS IS A FAULTY MANUFACTURE SAFTY ISSUE THAT HAS NOT EVEN BEEN RESEARCHED YET !! THERE HAVE BEEN SO MANY CUSTOMER COMPLAINTS ABOUT THE DANGER OF THIS VEHICLE AND THIS ISSUE I CAN NOT BELIEVE IT'S STILL ON THE ROAD. HTTPS://WWW.CARCOMPLAINTS.COM/KIA/SORENTO/2004/STEERING/STEERING.SHTML AND TO FIND OUT THE STATE WAS AWARE OF IT AND JUST NEVER EVEN LOOKED INTO PROTECTING US. THIS IS A DANGER AND NEEDS TO BE RECALLED ASAP BEFORE SOMEONE LOOSES THEIR LIFE AND THE LIFE OF THEIR CHILD LIKE I ALMOST DID !!!!

WHILE TRYING TO REFULE THE GASOLINE WILL SUDDENLY "SPRAY" FROM THE TANK. VEHICLE STATIONARY.

TL* THE CONTACT OWNS A 2004 KIA SORENTO. WITHIN LESS THAN 30 DAYS OF OWNING THE VEHICLE, THE CONTACT STATED THAT THE FUEL GAUGE ON THE INSTRUMENT CLUSTER CONTINUED TO INDICATE FULL WHETHER THE CONTACT REFUELED THE VEHICLE OR NOT. ALSO, WHEN THE AIR CONDITIONER WAS TURNED OFF, SMOKE EMITTED INTO THE INTERIOR OF THE VEHICLE AND UNDER THE HOOD. THE CONTACT EXITED THE VEHICLE AND LIFTED THE HOOD TO FAN AWAY THE SMOKE. THE CONTACT DROVE THE VEHICLE TO HER JOB. ANOTHER CONSUMER CALLED THE FIRE DEPARTMENT BECAUSE THE VEHICLE ERUPTED INTO FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. NEITHER A FIRE NOR A POLICE REPORT WAS FILED. THE APPROXIMATE FAILURE MILEAGE WAS 107,000. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE.

"TAKATA RECALL" I BOUGHT THIS CAR JUST RECENTLY AND THE DRIVERS SIDE AIR BAG STAYS ON ALL THE TIME THERE HAVE BEEN RECALLS BUT NOT ON MY CAR IS IT SAFE TO DRIVE THIS LIKE THIS OR IS IT DANGEROUS AND THE FACTORY SHOULD SEND OUT A RECALL ON THIS RIGHT !

TAKATA RECALL AIR BAG LIGHT IS ON THE DASH CAN I GET THIS REPLACED FOR NO CHARGE LIGHT STAYS ON ALL THE TIME.

THE INTERIOR LIGHTS DO NOT STAY ON THE WHEEL I HAVE TO PLAY WITH IT TO GET THEM TO COME ON AND THEY GO OFF ALL THE TIME WHICH IS VERY DANGEROUS DRIVING AT NIGHT. AND MY LOW BEAMS DO NOT WORK AT ALL I HAVE TO DRIVE WITH HIGH BEAMS ON.

TL* THE CONTACT OWNS A 2004 KIA SORENTO. THE CONTACT STATED THAT WHILE GOING THROUGH INSPECTION, THE AIR BAG WARNING LIGHT ILLUMINATED CONTINUOUSLY. IN ADDITION, THE REAR BRAKE LIGHT FAILED TO OPERATE. THE VEHICLE WAS NOT DIAGNOSED. THE CONTACT STATED THAT THE BRAKE LIGHTS WERE REPAIRED; HOWEVER, THE AIR BAG WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

WHILE MY DAUGHTER WAS DRIVING ON THE HIGHWAY, THE BRAKES FAILED. THE MECHANIC SHOWED ME THE BRAKE LINES TOWARD THE REAR SUSPENSION RUSTED THROUGH. ALSO THE SUPPORT FOR THE REAREND RUSTED THROUGH MAKING THE VEHICLE DANGEROUS TO DRIVE. THE BRAKE LINES FROM FRONT TO BACK WERE CHANGED AND I AM LOOKING TO HAVE THE SUPPORT BRACKETS CHANGED.

TL* THE CONTACT OWNS A 2004 KIA SORENTO. WHILE DRIVING APPROXIMATELY 30 MPH, THE POWER STEERING AND BRAKES SUDDENLY MALFUNCTIONED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CAMSHAFT PULLEY WAS FAULTY AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND THE LOCAL DEALER (QUIRK KIA IN BRANKLY, MA) WERE NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 99,000. *LN

I WAS DRIVING WHEN I HEARD A CLUNKING NOISE, AND MY TRUCK SHIFTED. SO I PULLED OVER TO SEE THE MY REAR LOWER ARM FELL FROM SUBFRAME CORRSION DUE TO HEAVY SALT USE HERE IN WI. I HAD TO GET CAR TOWED HOME.

IT DRIVES FINE THEN ALL OF A SUDDEN FOOT SAME POSITION ON GAS PETAL IT ACCELERATES.

I BOUGHT A 2004 KIA SORENTO IN 2006 FINISHED PAYING FOR IT IN 2010,OVER THE YEARS I HAVE HAD TO CHANGE THE LIGHTS SO MANY TIMES I CANT COUNT,I HAVE HAD TOPAINT IT TWICE,THEN THE DRIVING SHAFT BROKE,THE COMPRESSOR WAS CHANGED TWICE, THE CD PLAYER WORKS ON AND OFF THE AIR BAGS LIGHT CAME ON AND STAYED FOR MONTHS ON END THE ENGINE LIGHT DOES THE SAME AND MOST RECENTLY THERE IS SMOKE COMING FROM THE ENGINE, I AM HAVING TO STOP PARK AND LET IT COOL OFF BEFORE CONTINUING ON MY JOURNEY, AT THE MOMENT I GOT SCARED AND I NOW I HAVE MY VEHICLE PARKED AT HOME BECAUSE I AM SCARED TO DRIVE IT, IT IS A SHAME AND I AM VERY UPSET. IS THERE ANYONE OUT THERE WHO IS TRYING TO DO SOMETHING ABOUT THESE PROBLEMS US CONSUMERS ARE HAVING? I OWN MY VEHICLE AND HAS A CLEAN TITLE AND WOULD LIKE TO TRADE IN OR SELL BUT WITH ALL THESE PROBLEMS HOW CAN I PASS IT ON TO SOMEONE ELSE? I AM ASKING SOMEONE FROM KIA TO DO THE RESPONSIBLE THING AND GIVE US SOME ANSWERS BEFORE SOMEONE LOSES THEIR LIFE,THAT IS IF IT HASN'T HAPPENED ALREADY. DON'T LET THIS BE TOYOTA. *TR

2004 KIA SORENTO MANUAL TRANSMISSION TRANSMISSION LOCKS UP RANDOMLY. I AM UNABLE TO CHANGE GEARS. THE SHIFT STICK MOVES TO THE VARIOUS POSITIONS BUT THE CAR REMAINS IN GEAR. THIS OCCURS WHILE DRIVING OR STOPPED AND TRYING TO UPSHIFT OR DOWNSHIFT . I HAVE HAD THE VEHICLE TO THE KIA DEALER ON THREE OCCASIONS, BUT THEY ARE NOT ABLE TO DUPLICATE THE PROBLEM AND HENCE, CAN DO NOTHING ABOUT IT. LAST OCCURRENCE, ON 3/27/2008, HAD VEHICLE TOWED TO THE DEALER, HOWEVER THEY SAID THAT IT WAS NOT LOCKED UP WHEN THEY DROVE IT. NO HELP FROM KIA CUSTOMER SERVICE EITHER. *TR

TL* THE CONTACT OWNS A 2004 KIA SORENTO EX. THE VEHICLE HAS KUMHO RADIAL 798 TIRES, LINE SIZE P245/70/R16, MANUFACTURED MARCH 2006. THE CONTACT STATED THAT THE TIRES WERE EXHIBITING ABNORMAL FRACTURES. THE TIRE DISTRIBUTOR WAS CONTACTED AND ADVISED THAT THE FAILURE WAS CAUSED BY THE HOT CLIMATE. THE TIRES WERE NEITHER REPAIRED NOR REPLACED. THE FAILURE MILEAGE OF THE TIRES WAS 16,000. THE VEHICLE FAILURE MILEAGE WAS 52,501 AND THE CURRENT MILEAGE WAS 52,793. UPDATED 05/03/2011*LJ UPDATED 1/5/12 *CN

FRONT PASSENGER TIRE TREAD CAME OFF WHILE DRIVING DOWNHILL ON A MOUNTAIN ROAD AND CAUSE PASSENGER AIRBAG TO DEPLOY, WE WERE LUCKY CAR DID NOT ROLL OVER AND WE ALL WERE KILLED. BRIDGESTONE IS THE TIRE MANUFACTURER (DUELER 684, P245/70R16) AND WHEN I DO A WEB SEARCH ALL KINDS OF INFORMATION COMES UP WITH RECALLS BUT COULD NOT FIND MY TIRE TYPE BUT FOUND ALL KINDS OF BLOGS WITH PEOPLE COMPLAINING ABOUT MY TYPE OF TIRE AND THE TREAD COMING OFF. *TR

MAJOR RUST PROBLEM WITH FRAME AND SUSPENSION KIA SORENTO PURCHASED MARCH 30 2004 2 MONTHS PAST THE WARRANTY 85392 MILES HAVING JUST DRIVEN ON THE HIGHWAY 65MPH VEHICLE WAS ENTERING SCHOOL PARKINGLOT, AT THE ENTRANCE VEHICLE WENT OVER SPEED BUMP AT THIS POINT THERE WAS A LOUD BANG AND THE VEHICLE STARTED SHAKING AND SQUEALING. UPON INSPECTION THE PASSENGER SIDE REAR STABILIZER-TRACTION BAR BROKE COMPLETELY OFF THE FRAME RAIL JUST FORWARD OF THE WHEEL. THIS CAUSES THE REAR AXEL TO MOVE FREELY FORWARD AND BACK. FURTHER INSPECTION BY KIA DEALERSHIP SHOED MORE COMPONENTS ABOVE THE REAR AXEL BROKEN FREE. I FILED A GOOD WILL COMPLAINT WITH KIA WHO RESPONDED WITH A BIG NO REGARDING ANY HELP. FORTUNATELY THIS BREAKDOWN HAPPENED IN A PARKING LOT AND NO INJURIES HAPPENED BUT IF THIS HAD HAPPENED ON THE HIGHWAY IT WOULD HAVE BEEN A MAJOR ACCIDENT WITH POSSIBLE INJURIES OR DEATH IF THE VEHICLE ROLLED OVER . THIS WAS VERY GOOD LOW MAINTENANCE LOW MILEAGE VEHICLE AND WE WERE HOPING FOR A FEW MORE YEARS OF USAGE, NOW WE ARE DISAPPOINTED WITH KIA THAT NO NOTICES OF MAJOR RUST ISSUES WERE MADE AVAILABLE. NOW WHAT WE HAVE IS A CAR THAT WORTHLESS AND DOESN'T LIVE UP TO THE WARRANTY LIMITS. *TR

VEHICLE IS ONLY 7 YEARS OLD. METAL BRACKET WELDED TO THE REAR AXLE THAT HOLDS THE UPPER CONTROL ARMS HAS COMPLETELY FAILED! THE NORMAL TORQUE FROM THE REAR AXLE HAS BROKEN BOTH BRACKETS HOLDING THE UPPER CONTROL ARM TO THE CARS FRAME. ALL THAT IS HOLDING THE REAR AXLE IN PLACE IS THE LOWER CONTROL ARMS AND THE SWAY BARS. THERE ARE NO WEEP HOLES TO ALLOW WATER TO DRAIN OUT OF THE BRACKET WELDMENT, CAUSING WATER TO FILL THE CUP-LIKE CONDITION CREATED. THIS CONDITION HAS (AN WILL) CAUSE PREMATURE FAILURE OF ALL KIA SORENTO REAR AXLE/UPPER CONTROL ARM CONNECTIONS. WHILE DRIVING THE REAR AXLE COULD BECOME DETACHED FROM THE VEHICLE DUE TO EXCESSIVE STRESS PLACED ON THE REMAINING PARTS. A TYPICAL TRAFFIC MANEUVER COULD CAUSE A CATASTROPHIC FAILURE, AND RENDER THE VEHICLE UNCONTROLABLE, WITH THE LIKELYNESS OF MASSIVE PAIN, INJURY AND DEATH AS A RESULT!!! THIS IS AN EXTREMELY DANGEROUS CONDITION!!! THESE CARS NEED TO BE RECALLED NOW BEFORE SOMEONE IS KILLED!!! PS IF YOU SEE A KIA SORENTO ON THE FREEWAY...STAY AWAY FROM IT FOR YOUR OWN SAFETY!

PICKED UP VEHICLE AFTER HAVING REAR SUPPORT BEARINGS REPAIRED DRIVING BACK HOME AT 65MPH ON I-35/TEXAS 410 EAST STARTED TO EXPERIENCE STRONG SMELL OF EXHAUST FUMES IN PASSENGER COMPARTMENT. DURING DRIVE HOME STARTED TO RAIN, ACTIVATED WIPERS, DRIVERS SIDE WIPER BLADE FELL OFF DURING RAINSTORM HAD TO OPEN DRIVER SIDE WINDOW TO NAVIGATE! UPON ARRIVAL AT HOME NOTICED, SMOKE COMING FROM ENGINE COMPARTMENT (PASSENGERS SIDE) AND SMOKE UNDERNEATH VEHICLE FROM CATALYTIC CONVERTER. LOOKED UNDERNEATH VEHICLE AND CATALYTIC CONVERTER, WAS SMOKING, INSIDE ENGINE COMPARTMENT A HOSE AT THE REAR OF THE ENGINE COMPARTMENT (SORRY NOT A MECHANIC) HAD A HOLE IN IT AND WAS SMOKING ALSO? VEHICLE HAS NOT BEEN DRIVEN SINCE 12/7/12, VEHICLE WAS PURCHASED 10/4/12, HAS LIMITED WARRANTY. *TR

I BOUGHT MY 2004 SORENTO NEW. IN MAY 2008 AND AT 64,000 MILES THIS YEAR THE WATER PUMP STARTED LEAKING. I TOOK IT INTO THE LOCAL KIA DEALERSHIP AND THEY SAID IT WAS UNDER A RECALL AND REPLACED IT. THEY ALSO RECOMMENDED A TIMING BELT CHANGE AT THAT TIME AND I DID THAT TOO. AFTER I LEFT THE DEALERSHIP AND DROVE INTO MY GARAGE, WATER WAS POURING OUT FROM UNDERNEATH THE PASSENGERS SIDE TIRE, WHERE THE RESERVE TANK WAS. I TURNED AROUND TOOK IT RIGHT BACK AND SHOWED THEM. THEY SAID IT WASN'T ANYTHING THEY DID TO BUST IT, IT MUST OF BEEN THAT WAY ALREADY. I INFORMED THEM THAT I KNOW IT WASN'T THAT WAY BECAUSE I HAD BEEN POURING TONS OF WATER IN IT UNTIL I COULD GET MY CAR IN FOR THAT APPOINTMENT SINCE THE WATER PUMP WAS LEAKING AND THE LEAKING BEFORE WAS COMING FROM THE CENTER OF THE CAR, NOT BY THE TIRE. I ALSO INFORMED THEM, THAT I KNEW THEY BUSTED BECAUSE THEY HAD TO PUT PRESSURE ON THE WATER PUMP LINE TO TEST IT AND THEREFORE IT WAS THERE FOUGHT. THEY STILL SAID EVEN THOUGH THEY DIDN'T DO IT THEY WOULD GO AHEAD AND REPLACE IT FOR FREE. WHY DO THEY NOT WANT TO OWN UP TO IT TO BEGIN WITH? IF I HAD NOT MADE A SCENE IN FRONT OF THEIR OTHER CUSTOMERS THEY WHERE GOING TO MAKE ME PAY FOR IT. I HAVE ALSO HAD THE WIPER PARK AREA BURN OUT. SMOKE STARTED COMING FROM MY WINDSHIELD ON HE INSIDE AND NOW THE HEATED WIPER PARK AREA IS NOT WORKING. IT WILL NEED A WHOLE NEW WINDSHIELD. *TR

TL* THE CONTACT OWNS A 2004 KIA SORENTO. WITHIN LESS THAN 30 DAYS OF OWNING THE VEHICLE, THE CONTACT STATED THAT THE FUEL GAUGE ON THE INSTRUMENT CLUSTER CONTINUED TO INDICATE FULL WHETHER THE CONTACT REFUELED THE VEHICLE OR NOT. ALSO, WHEN THE AIR CONDITIONER WAS TURNED OFF, SMOKE EMITTED INTO THE INTERIOR OF THE VEHICLE AND UNDER THE HOOD. THE CONTACT EXITED THE VEHICLE AND LIFTED THE HOOD TO FAN AWAY THE SMOKE. THE CONTACT DROVE THE VEHICLE TO HER JOB. ANOTHER CONSUMER CALLED THE FIRE DEPARTMENT BECAUSE THE VEHICLE ERUPTED INTO FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. NEITHER A FIRE NOR A POLICE REPORT WAS FILED. THE APPROXIMATE FAILURE MILEAGE WAS 107,000. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE.

TL* THE CONTACT OWNS A 2004 KIA SORENTO. WHILE DRIVING AT APPROXIMATELY 35 MPH, THE VEHICLE LOST POWER AND THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE FAN AND AIR CONDITIONER. THE BATTERY INDICATOR WAS ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED. THIS WAS A RECURRING FAILURE. THE CONTACT STATED THAT THE NEIGHBOR ASSISTED HER WITH THE FAILURE BY CHECK UNDER THE ENGINE. IT WAS DISCOVERED THAT THE AIR CONDITIONER BELT FRACTURED, WAS ON TOP OF THE ENGINE BLOCK, AND THE PULLEY WAS LOOSE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE VEHICLE WAS DIAGNOSED AND REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000.

A FEW WEEKS AFTER PURCHASING MY 2004 KIA SORENTO, I NOTICED THE DRIVERS SEAT ROCKING BACK AND FORTH WHEN ACCELERATING AND BRAKING. DEALER REPLACED SEAT RAIL. THAT FAILED TO RESOLVE PROBLEM. SINCE THEN THE DEALER HAS AGAIN REPLACE THE SEAT RAIL AND THE WHOLE SEAT WITHOUT RESOLVING THE PROBLEM. KIA REP SAYS THAT IT IS NORMAL FOR ELECTRIC SEATS IN KIAS TO ROCK LIKE MINE DOES. I BELIEVE THE SEAT WILL EVENTUALLY FAIL DURING AN ACCIDENT RENDERING IT AND THE SEAT BELT USELESS.*AK

"TAKATA RECALL" I BOUGHT THIS CAR JUST RECENTLY AND THE DRIVERS SIDE AIR BAG STAYS ON ALL THE TIME THERE HAVE BEEN RECALLS BUT NOT ON MY CAR IS IT SAFE TO DRIVE THIS LIKE THIS OR IS IT DANGEROUS AND THE FACTORY SHOULD SEND OUT A RECALL ON THIS RIGHT !