2013 Kia Sorento Engine Problems

The contact owns a 2013 Kia Sorento. The contact stated that there was a knocking sound coming from the vehicle with the engine warning light illuminated. The contact used a diagnostic machine to retrieve DTC: P0136, P0172 system, to the rich bank, and P1326 control module which indicated that the knock sensor needed to be replaced. The vehicle was towed to the local dealer, and the contact was informed that the oil change records were needed. The vehicle was diagnosed, and it was determined that there was too much fuel, and that the knock sensor had failed. The vehicle was not repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was approximately 312,320.

NHTSA ID

11753810

Incident

Apr 12, 2026

Mileage

312,320 mi

AC stopped, engine began to struggle, engine light came on and engine over heated. Pulled off highway to be towed. Dealer found metal in oil and suggested possible manufacturer defect issue.

NHTSA ID

11752405

Incident

Jul 22, 2026

The head gasket blew. This car has been meticulously maintained. All maintenance records with kia dealer. I hear there is secondary engine problems related to the 2013 kia sorento. I have all maintenance records as well as the dealer.

NHTSA ID

11746873

Incident

Jun 2, 2026

My vehicle experienced a dangerous incident involving smoke entering the passenger cabin followed by complete engine seizure. Prior to this failure, the vehicle had already undergone recall-related repairs through an authorized Kia dealership for known engine and fire-related safety concerns. The recall was marked as completed by the dealership. However, after the repair, the vehicle continued experiencing problems significant enough to require multiple return visits to the dealership. Despite the recall work being completed, the vehicle ultimately suffered the same type of dangerous condition the recall was intended to prevent. Smoke entering the cabin created a serious safety hazard for myself and anyone inside the vehicle. This was not a routine mechanical issue or ordinary wear and tear. This involved conditions directly connected to known Kia engine defect investigations involving engine failure and fire risks.

NHTSA ID

11743679

Incident

Nov 25, 2025

On Jan 1,2019 under KIA PI-1803 Recall I had a Knock Sensor Detection System(KSDS) installed on my 2013 KIA Sorento. My car broke down and was towed into the Kia Dealership and it indicated a P1326 fault active . It was reset and released to me on 05/12/2026 after conducting a BCT test saying it indicated PASS drove it off the lot went 5 miles, and it broke down, towed back in and they replaced the KSDS. They performed a BCT replaced the KSDS and then said it PASSED. I have requested an actual copy of the test not just a P. They have refused both at the Dealership Level and KIA Customer Service . The Results of both tests are conducted by Techline and that information is available. I believe the vehicle is unsafe to drive as this has happened twice in a 2 day period . I do not trust that it passed the rod bearing tests without the actual test results.

NHTSA ID

11742106

Incident

May 12, 2026

The contact owned a 2013 Kia Sorento. The contact stated that he had received a recall notice for NHTSA Campaign Number: 23V652000(Service Brakes, Hydraulic). The contact then stated that soon after the recall was serviced, the vehicle would hesitate to start after multiple attempts without warning. The vehicle had been taken back to the dealer on multiple occasions due to failure; the dealer was unable to diagnose the failure, but stated that the failure was not related to the recall. The contact then stated that while driving at approximately 45 MPH, a white-grayish smoke began to emit from the vehicle without warning. The smoke became heavier and quickly turned black as the contact pulled over and exited the vehicle. The vehicle quickly became engulfed in flames as the authorities were called to the scene. Both the police and the fire department arrived at the scene, and the fire department extinguished the fire. A police report was not filed, and no injuries were reported. The vehicle was towed to an independent mechanic, where it remained in their possession. The vehicle was destroyed as a result of the fire. Neither the manufacturer nor the dealer had yet been notified of the failure. The failure mileage was approximately 190,000.

NHTSA ID

11732711

Incident

Apr 20, 2026

Mileage

190,000 mi

On December 21, 2025, my vehicle experienced abnormal knocking/ticking sounds coming from the engine while driving on the interstate (60 mph), and it was difficult going up hills. The check engine light was intermittingly blinking, and there was a strong burning smell. The vehicle was taken to AutoZone and the code displayed P0304 indicating a cylinder 4 misfire. The spark plugs were replaced. However, the knocking sounds, blinking check engine light, and smell of burning happened again, and I took it PepBoys on December 26, 2025. After testing, they indicated that the fuel injector was cracked and fuel was found in the engine oil. I had AAA tow the vehicle to Cochran Kia [XXX] ). The dealership indicated that they would not be able to look at the vehicle until December 29, 2025. The dealership verified that the check engine light was still on and the motor was misfiring badly. They then checked cylinder #4 with a borescope and found that the valve had a crack in it and that the engine would need to be replaced. There was also damage/scoring to the piston and cylinder wall. The dealership corresponded with Kia (Case #25769914), Kia however indicated that there was no powertrain warranty and that this would not be covered under PI1803 and indicated that only applies to bearing failure, and that dealership should provide me with cost estimate to replace the engine. My vehicle has been properly maintained, and I provided the dealership with the additional requested maintenance records on February 14, 2026. I reached out to Kia Customer Care and they indicated to get the engine replaced under the warranty from the settlement, I had to work with the dealership. I contacted the dealership again on 3/12/26 and they said they can't do a warranty replacement because the warranty only covered if it was the rod bearing. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11723839

Incident

Dec 21, 2025

Car stalled several times including as I was turning through an intersection. I took my car to KIA Ganley if Boardman 7870 Market Street Bdmn Two, Youngstown, Ohio 44512. I met w/Gerry who I explained the concerns with car stalling reminding him it had been almost 2 years since the jnick sensor issue was detected. So why am I expected to keep driving a dangerous vehicle without the repair needed??!!!! Also asked about light assembly replacement delay (per recall) since I'm replacing the turn signal & brake bulbs 5-6 times a year while awaiting a replacement. assembly.

NHTSA ID

11710092

Incident

Jan 3, 2026

The contact owns a 2013 Kia Sorento. The contact received notifications of NHTSA Campaign Numbers: 17V224000 (ENGINE AND ENGINE COOLING) and 23V652000 (SERVICE BRAKES, HYDRAULIC). The contact stated that while his daughter was driving 45 MPH, there was an abnormal knocking sound coming from the engine. In addition, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact's daughter stated that the engine had seized, and the vehicle had stalled. The contact's daughter was unable to coast to the side of the road. No warning lights were illuminated. The vehicle was towed to the residence. The following day, the vehicle was towed to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The contact was informed that since the first recall repair had not been completed, the manufacturer denied the recall repairs. The vehicle remained at the dealer unrepaired. The contact received a bill from the dealer. The manufacturer was not notified of the failure. The contact's daughter stated that before the engine failed, every time the vehicle was started, there was an abnormal knocking sound coming from the engine. However, after several minutes, the abnormal sound disappeared. The failure mileage was approximately 125,000.

NHTSA ID

11702984

Incident

Oct 30, 2025

Mileage

125,000 mi

While driving, my vehicle developed engine knocking, lost power, overheated, and produced smoke from the engine compartment. Shortly after, the engine seized and the vehicle will not start. An authorized dealership diagnosed the failure and recommended a complete engine (long-block) replacement, indicating catastrophic internal engine damage. This failure appears consistent with known Theta II engine bearing defects. The manufacturer is refusing coverage by stating the owner did not bring in the car for the recalls. The recall was preventive monitoring software (KSDS) and did not repair or prevent the underlying mechanical defect that caused the failure. This is a safety concern, as the failure caused loss of power and overheating, creating risk of fire or accident.

NHTSA ID

11702856

Incident

Nov 30, 2025

I am reporting a safety defect on my 2013 Kia Sorento (VIN: [XXX] ). Before the failure, the vehicle began experiencing sluggish starting, sputtering during acceleration, stalling when stopped at traffic lights or stop signs, a noticeable fuel odor, and eventually a check engine light. These symptoms increased over several days, and once the check engine light illuminated, we had the vehicle towed to a Kia dealership for diagnosis. At the dealership, the problem was confirmed and reproduced by their technicians. They diagnosed: •Fuel leakage from the high-pressure fuel pressure regulator •Fuel contamination in the engine oil These components and diagnostic findings are available for inspection upon request. This issue poses a significant safety risk. Fuel leakage and fuel-in-oil contamination increase the potential for an engine fire, and the hesitation, sputtering, and stalling at intersections present a risk of unexpected loss of power in traffic, which could result in a collision. The vehicle previously had its engine replaced under a Kia recall in 2020, and the current symptoms are consistent with known Kia engine and fuel system defects addressed in past recalls and technical service bulletins. The vehicle has been inspected only by the dealership so far; it has not yet been inspected by the manufacturer, police, or insurance representatives. Kia Consumer Affairs has been contacted and is reviewing the case. I am requesting that NHTSA review this issue as a potential defect trend involving the high-pressure fuel system on this model, especially in vehicles with prior recall-related engine replacements. Documentation from the dealership, including the diagnostic report and repair estimate, is available upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11702339

Incident

Nov 24, 2025

I was on my way back from California to Mississippi when motor derated and started knocking in Williams , Az. My Kia only has 137,000 miles and Kia denying my claim for the extended warranty claim. I change my oil myself and keep my vehicle in great shape. To deny claim they also have to prove lack of servicing caused the defect. That is part of the Magnuson-Moss warranty act. I rented a vehicle to get back home and hired a trucking company to bring Kia back. They never did and after my job let me take two days to get my car back home I rented a truck and trailer to bring it home. So yes I’m very ill about Kia’s work practices.I took Kia to the dealership in Tupelo,Ms. and Kia had them remove valve cover and deny my claim. The vehicle messed up in July, but I wasn’t able to get it till September 1,2025 and then get it to dealership. It has been there till today cause I went and got it. I’m still waiting to get my denial letter.A woman by the name Vanessa is the one who called me to tell me it was denied. Mileage is a little over the 137,000. But battery is completely dead so I can’t get the exact mileage.

NHTSA ID

11696982

Incident

Jul 11, 2025

The contact owns a 2013 Kia Sorento. The contact stated that while stopped at a stop light, while depressing the accelerator pedal, the vehicle lost motive power in the intersection. No warning light was illuminated. An independent mechanic was contacted. The vehicle was towed by the warranty company to AAMCO, where it was diagnosed, and determined that the engine needed to be replaced. The contact was informed of an engine recall, and the vehicle was then towed to a local Kia dealer. The vehicle was not repaired. The manufacturer was notified of the failure, and informed the contact that the original owner would have received the recall and that the repair would not be covered. The contact was informed that the former owner should have notified her of the recall. The approximate failure mileage was 114,000.

NHTSA ID

11692540

Incident

Aug 15, 2025

Mileage

114,000 mi

My motor is knocking and losing compression

NHTSA ID

11681464

Incident

Aug 17, 2025

In 2017, our 2013 Kia Sorento was brought in for recall work associated with SC147. The work was completed, and the Kia service department stated that even though we have a branded/salvage title, we would receive the extended warranty associated with SC147. Recently, while driving down a busy highway, the engine started knocking, at which point the check engine light came on, and the vehicle would no longer accelerate. The car had to be pulled off to the side of the road, and towed to a repair shop. Upon inspection, the repair shop indicated the issue was related to SC147, and would need to be taken to Kia for further inspection and repair. Kia has indicated, now, that SC147 was closed due to the inspection and KSDS update done in 2017, and that we are not covered by the extended warranty associated with SC147 due to the branded title, which contradicts what was previously stated by Kia's service department. Kia has stated that they will NOT replace the engine. Even though this is a safety issue associated with SC147, Kia is unwilling to take accountability and seems to be sidestepping replacement due to having a branded/salvage title.

NHTSA ID

11675068

Incident

Jul 13, 2025

While driving down the road the car just went dead. No warning. It was the oil pump that had gone out and froze the engine causing complete loss of control of the vehicle.

NHTSA ID

11667259

Incident

Apr 19, 2025

Code p0014 indicates that the Bank 1 exhaust camshaft position timing was advanced beyond limits for a pre determined period of time.

NHTSA ID

11664027

Incident

Apr 7, 2025

This vehicle has a oil consumption problem that causes engine damage and Kia will not take responsibility for especially after the car being maintained. On top of it even with substantial evidence that this was a manufacturing defect that Kia is refusing to take accountability for and completely dismisses any claims or complaints and not even bothered to speak with you unless the car has warranty which is absurd because this was a again a manufacturing defect of the vehicle not from not sustaining the vehicle from the driver that owns it. It also did not give off any warning signs or any indication that there was a problem until the problem completely left me without a car. Without a warning or indication this was a hazard and luckily I did not have my children in the car when the oil brought broke and pierced an immense hole causing my engine damage. Kia sorentos are known for this defect it has had a lawsuit for this with other Kia sorento's they need to put this model also as I dug deeper I am not the only one that has this problem I'm currently trying to pursue a lawsuit with Kia corporation for this however as you know this is not an easy process This was definitely a safety issue that could have became extremely severe and risked my life and my children

NHTSA ID

11662704

Incident

Jan 1, 2025

my vehicle falls under the 2013 Kia Sorrento engine replacement and fuel pump. Recall these have not been done to my vehicle. I even double checked with the previous owner and Kia did not service the engine or replace it although it has a recall under mine, and all the symptoms stated in the recall with the engine and fuel pump are happening with my vehicle now how do I get this service covered under the recall also a very strong fuel odor

NHTSA ID

11660758

Incident

May 13, 2025

The car just completely stalled while driving on a busy street with myself and my children in the car. I first was alerted that it may just be the starter by a local mechanic. I fixed that and it still would not start. I then went and got a new battery and that did not work either. At that point I had the car towed to the Kia dealership. The mechanic told me that the car engine was a part of a recall for Kia. He told me that he would put the claim in and that Kia would fix it. He told me to send in my registration and drivers license. A couple of weeks later he informed me that they would not fix my engine because the registration was expired. The expired registration has nothing to do with their faulty recalled engine. I had this issue escalated and still was told they would not fix it.

NHTSA ID

11660205

Incident

Oct 1, 2024

premature bearing wear within the engine

NHTSA ID

11653792

Incident

Apr 4, 2025

Kia failed to take accountability for rods related to oil pan and engine damage defect on this vehicle. Did not offer other safety options and did not give any warning signs. I have ALL my receipts and maintenance on vehicle that I DID Maintain my vehicle responsible and this was a Kia vehicle safety issue on manufacturing. I did not receive any warning or lights on my dashboard and I have all my oil change receipts. Please see all attached documents for my complaint. All Kia customer service was concerned with was warranty when this is a manufacturing product defect of this car not being put together properly and my vehicle has been serviced over years at a Kia dealership and no one has ever told me my vehicle was not maintained. Kia corporation won't even investigate or even move forward in any direction even with all my receipts reports and evidence to submit my claims are true.

NHTSA ID

11652979

Incident

Jan 1, 2025

The contact owns a 2013 Kia Sorento. The contact stated while driving 70 MPH on an interstate, the vehicle abruptly decelerated. The contact pulled over to the side of the road. There was no warning light illuminated. The vehicle was towed to an unknown local dealer, where it was diagnosed that the engine had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred. The contact stated that upon picking up the vehicle from the dealer, the vehicle made an abnormally loud clunking, metal-on-metal sound; however, the dealer confirmed that there was no failure found. The vehicle was taken to a tire shop, where it was determined that the motor mounts had failed. The vehicle was not repaired. The manufacturer was contacted, and a case was filed. The manufacturer confirmed the warranty coverage. The approximate failure mileage was 151,000.

NHTSA ID

11652229

Incident

Jan 25, 2025

Mileage

151,000 mi

The contact owns a 2013 Kia Sorento. The contact received notification of NHTSA Campaign Number: 23V652000 (SERVICE BRAKES, HYDRAULIC); however, the part to do the recall repair was not yet available. The contact stated that while driving 55 MPH, there was an abnormal sound coming from the engine, and the vehicle lost motive power and stalled. The contact stated that several unknown warning lights were illuminated. The vehicle was able to restart. The vehicle was taken to the dealer; however, no cause for the failure was found. An unknown repair was performed. The contact stated that the failure persisted. The vehicle was taken to the dealer; however, no cause for the failure was found. An unknown repair was performed. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that the failure persisted. The failure mileage was approximately 105,000. Parts distribution disconnect.

NHTSA ID

11649041

Incident

May 21, 2023

Mileage

105,000 mi

While driving the car will stall, making maneuvering the car to safety difficult. There was no warning that this was happening. I did take the car to a mechanic, he said because the engine light was not on, he could not track the problem. I had this happen at least 6 times in the past few months

NHTSA ID

11648544

Incident

Mar 7, 2025