2010 Lexus IS 350

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

TL* THE CONTACT OWNED A 2010 LEXUS IS 350. WHILE THE CONTACT'S HUSBAND WAS DRIVING AT AN UNKNOWN SPEED, ANOTHER VEHICLE REAR ENDED HIS VEHICLE. THE CONTACT'S VEHICLE SPUN AND STRUCK A BARRIER ON THE PASSENGER SIDE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT'S HUSBAND SUFFERED FRACTURED RIBS THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A TOW YARD AND THE INSURANCE COMPANY DECLARED THE VEHICLE TO BE A TOTAL LOSS. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER TO DETERMINE THE AIR BAG FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS APPROXIMATELY 88,000.

NHTSA ID

11121703

Incident

Aug 26, 2015

Mileage

88,000 mi

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 LEXUS IS 350. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V340000 (AIR BAGS). THE CONTACT STATED THAT THE PARTS NEEDED FOR THE RECALL REMEDY WERE STILL NOT AVAILABLE AND THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

10948929

Incident

Jun 14, 2016

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 LEXUS IS 350. THE CONTACT RECEIVED NOTIFICATION OF AN AIR BAG RECALL AND STATED THAT THE PART WAS NOT AVAILABLE WITHIN A REASONABLE TIME FRAME TO SCHEDULE THE RECALL REPAIR. THE DEALER DID NOT GIVE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE VEHICLE WOULD RECEIVE THE RECALL REPAIR. THE NHTSA CAMPAIGN NUMBER WAS UNKNOWN. THE CONTACT WAS NOT EXPERIENCING A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

10945712

Incident

May 2, 2016

TAKATA RECALL I RECEIVED A LETTER IN MAY 2016 THAT THERE WAS A RECALL ON THE PASSENGER AIRBAG AND NEEDED TO COME IN FOR SERVICE, I TOOK MY VEHICLE IN AND WAS TOLD THEY HAD NOT RECEIVED THE PARTS AND WOULD NOTIFY ME WHEN THEY WERE AVAILABLE. AS OF 12/09/2016 THEY STILL NAVE NOT RECEIVED WHAT THEY NEED TO FIX MY VEHICLE. I AM VERY DISSATISFIED WITH LEXUS. I WOULD LIKE SOMEONE TO GET THIS PROBLEM RESOLVED AS SOON AS POSSIBLE. IF I DO NOT GET SATISFACTION I MAY HAVE TO CONTACT AN ATTORNEY.

NHTSA ID

10934071

Incident

May 1, 2016

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 LEXUS IS 350. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V340000 (AIR BAGS). THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA ID

10929012

Incident

Dec 1, 2016

THESE THREE ITEMS ARE LISTED AS RE CALL HOWEVER NO ONE HAS CONTACTED THE OWNER OF THIS VEHICLE WHERE CAN WE GET THESE FIXED WE LIVE IN BETHANY BEACH DELAWARE 19930 PHONE # [XXX] OR EMAIL. [XXX] THANK YOU INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10882474

Incident

Jun 6, 2016

TL* THE CONTACT OWNS A 2010 LEXUS IS350. THE CONTACT STATED THAT UPON STARTING THE IGNITION, AN ABNORMAL KNOCKING NOISE WAS HEARD FROM OUTSIDE THE VEHICLE. THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT TAKEN FOR DIAGNOSIS OR REPAIRS. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER 13V395000 (ENGINE). THE CONTACT WAS NOT ABLE TO HAVE THE VEHICLE SERVICED UNDER THE RECALL UNTIL JANUARY 2013 BECAUSE OF A MASSIVE WAITING LIST. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 42,000.

NHTSA ID

10553057

Incident

Nov 5, 2013

Mileage

42,000 mi

I WAS DRIVING ON THE FREEWAY AT 65 MILES PER HOUR WHEN THE SIDE VIEW MIRROR ON THE PASSENGER SIDE CAME LOOSE AND WAS DANGLING BACK AND FORTH. ABOUT A WEEK LATER THE SAME THING HAPPENED TO THE SIDE VIEW MIRROR ON THE DRIVERS SIDE. THE MIRRORS WERE NEVER HIT OR IN AN ACCIDENT. I HAVE A LEXUS IS350 2010. *TR

NHTSA ID

10499316

Incident

Feb 6, 2013

Mileage

35,000 mi

TI: 19LE05 Expired December 1, 2022

DP: Limited Service Campaign KLG expired December 01, 2022

DP: Customer Support Program 19LE05 expired December 1, 2022.

TI: 19LE05 Expired December 1, 2022

CSP: On July 30, 2018, a settlement of claims for Economic Loss related to Takata airbag inflators was approved for full implementation. The settlement includes Lexus?s agreement to provide a Customer Support Program (?CSP?) for 2002-2019 model year (MY) vehicles originally equipped with certain Takata airbag inflators or repaired under a recall with Takata airbag inflators to provide coverage for repairs of the airbag inflator contained in the airbag module. This CSP letter is to help clarify how to administer this coverage in accordance with the settlement. This is NOT a recall or a campaign, but is provided to reassure owners that Lexus stands behind the reliability of our vehicles

CSP: Takata CSP Coverage Job Aid - published 7.28.2022