RoadVitals

2004 Lexus RX330 Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
5
Newest Nov 9, 2011
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
2 investigations on file

Recall campaigns

5 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

11V539000

ENGINE AND ENGINE COOLING

Nov 9, 2011
420,326 units potentially affected
The defect: TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.
The risk: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.
The remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Toyota Motor Engineering & ManufacturingView on NHTSA.gov
11V112000

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Feb 24, 2011
769,379 units potentially affected
The defect: TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.
The risk: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.
The remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
TOYOTA MOTOR NORTH AMERICA, INC.Manufacturer number BOA/BLCView on NHTSA.gov
06V253000

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Jul 13, 2006
367,594 units potentially affected
The defect: ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.
The risk: THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
TOYOTA MOTOR NORTH AMERICA, INC.Manufacturer number 6LD 60FView on NHTSA.gov
06V023000

SEAT BELTS:REAR/OTHER

Jan 27, 2006
3,851 units potentially affected
The defect: CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THE ANCHOR BOLT FOR THE REAR, LEFT-HAND SIDE SEAT BELT BUCKLE DIRECTLY BEHIND THE DRIVER'S SEAT DOES NOT HAVE SUFFICIENT STRENGTH.
The risk: THE REAR SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED IN THE EVENT OF A CRASH.
The remedy: DEALERS WILL REPLACE FREE OF CHARGE THE REAR, LEFT-HAND SIDE SEAT BELT BUCKLE ANCHOR BOLT WITH AN IMPROVED ONE. THE RECALL BEGAN ON FEBRUARY 3, 2006. OWNERS MAY CONTACT LEXUS AT 800-255-3987.
TOYOTA MOTOR NORTH AMERICA, INC.Manufacturer number 6LAView on NHTSA.gov
04V558000

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

Nov 22, 2004
183,090 units potentially affected
The defect: CERTAIN PASSENGER VEHICLES MAY BE EQUIPPED WITH AN IMPROPERLY DESIGNED BRAKE LIGHT SWITCH. A SILICON OXIDE BUILD-UP OCCURS ON THE CONTACTS INSIDE THE BRAKE LIGHT SWITCH, WHICH CAN MAKE IT INOPERABLE.
The risk: IF THE SWITCH IS INOPERABLE, THE BRAKE LIGHTS WILL NOT ILLUMINATE AND CAN INCREASE THE RISK OF A CRASH.
The remedy: DEALERS WILL REPLACE THE BRAKE LIGHT SWITCH. THE RECALL BEGAN DURING DECEMBER 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
TOYOTA MOTOR NORTH AMERICA, INC.Manufacturer number SSC 40L/SSC 4LHView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

RQ10003ClosedRecall Query

Unintended and Uncontrolled Acceleration

Opened Feb 16, 2010
Closed Mar 1, 2011

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

ELECTRICAL SYSTEM:SOFTWARELed to recall 11V112000
PE05009ClosedPreliminary Evaluation

VACUUM BRAKE BOOSTER FAILURE

Opened Feb 10, 2005
Closed Jun 15, 2005

ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .