2005 Lincoln Aviator

This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.

I WAS DRIVING ON A HIGHWAY 55 MPH WHEN PASSENGER REAR TOE LINK FAILED AND I LOST CONTROL OF VEHICLE. I WAS ABLE TO PULL OVER WITHOUT CRASHING. VEHICLE WAS REPAIRED AT GARAGE NEARBY.

NHTSA ID

11373131

Incident

Oct 20, 2020

Mileage

142,600 mi

A 6 INCH CRACK DEVELOPED AT REAR CENTER TAILGATE BODY PANEL MADE OUT OF PLASTIC BELOW THE REAR WINDOW. THERE HAD BEEN REPORTS THAT THE REAR WINDOW COULD FALL OUT AND INTERNAL TAILGATE COMPONENTS COULD BE DAMAGED DUE TO WATER ENTRY FROM THE CRACK. THIS APPEARS TO BE A COMMON PROBLEM FROM MY RESEARCH.

NHTSA ID

11338701

Incident

Jan 9, 2020

DRIVER SIDE AIR BAG DEPLOYED WITH NO IMPACT OF ANY KIND. CAR WAS STARTED AND AIR BAG DEPLOYED.

NHTSA ID

11311365

Incident

Jan 22, 2020

Mileage

180,000 mi

REAR PLASTIC LITIGATE APPLIQUE BROKE OFF HITTING A PASSENGER CAR'S WINDSHIELD. THE WINDSHIELD CRACKED. THIS THE THIRD PIECE FAILURE. THE LINCOLN WAS TRAVELING WEST ON THE DULLES GREENWAY.

NHTSA ID

11291524

Incident

Dec 23, 2019

Mileage

66,300 mi

WHILE PARKED AT THE GAS STATION GETTING READY TO PUMP GAS THE REAR WINDOW EXPLODED, GLASS SHATTERED EVERYWHERE, LEFT HINGE CRACKED AND FRAME AROUND LIFTGATE BEND AND CURLED UP. MY REAR LIFTGATE HAS THE SAME CRACKED AS PREVIOUSLY REPORTED. I REPLACED THE ENTIRE LIFTGATE IN 2011 & ON THE NEW LIFTGATE THE SAME CRACK CAME BACK

NHTSA ID

10916449

Incident

Oct 15, 2016

Mileage

133,400 mi

I HAVE THE SAME CRACKING PROBLEM WITH THE BACK GATE WHICH RESULTED IN THE BREAKING OF HINGES. ALSO A KNOWN DEFECT IN USING DEFECTIVE PARTS IN THE ENGINE SUCH AS TIMING CHAIN CASSETTES AND TENSIONER. FORD KNEW ABOUT THE PROBLEM AND ISSUED AN TECHNICAL BULLETIN ON IT BUT NEVER FIXED THE PROBLEM. THE MECHANIC TOLD ME HE REPAIRED THIS VERY FREQUENTLY FOR THIS ENGINE

NHTSA ID

10906769

Incident

May 6, 2015

OWNER OF 2005 LINCOLN AVIATOR. I WAS NOT ABLE TO GET THE GEAR SHIFT OUT OF PARK. I HAD THE AVIATOR TOWED TO A FAMILY MEMBER'S AUTOMOTIVE GARAGE AND WAS TOLD THAT I WILL NEED TO HAVE THE ENTIRE GEAR SHIFT REPLACED. UPON DOING SOME RESEARCH, IT SEEMS THAT THIS IS A VERY COMMON PROBLEM IN THIS YEAR, MAKE, AND MODEL. I HAVE READ ENDLESS TESTIMONIES FROM OTHER VEHICLE OWNERS WITH THE EXACT DISPUTE. THE PART AND LABOR WILL COST ME APPROXIMATELY $1100.00 AT MY FAMILY'S GARAGE, ONE CAN ONLY GUESS THE DOLLAR AMOUNT WILL DOUBLE AT THE LOCAL DEALERSHIP. MY CAR IS DRIVEABLE, HOWEVER, WHEN IN PARK, I WILL HAVE TO PUT MY EMERGENCY BRAKE ON. I WAS ALSO INFORMED THAT THE GEAR SHIFT, IF BUMPED, MAY MOVE OUT OF PARK EVEN WITHOUT THE KEY IN THE IGNITION. I AM APPALLED THAT FORD/LINCOLN MOTOR COMPANY HAS NOT TAKEN RESPONSIBILITY OF THE DEFECTED MECHANISM. IT IS UNACCEPTABLE AND RAISES MANY QUESTIONS ON HOW IMPORTANT VEHICLE SAFETY IS TO FORD/LINCOLN MOTOR COMPANY, NOT TO MENTION A TOTAL INCONVENIENCE FINANCIALLY! THIS IS MY FOURTH VEHICLE FROM FORD/LINCOLN MOTOR COMPANY AND I HIGHLY DOUBT I WILL PURCHASE ANOTHER BASED ON THE COMPANY'S LACK IN ADDRESSING THE MATTER. I AM A MOTHER OF ONE CHILD AND NOW DO NOT FEEL SECURE DRIVING A VEHICLE THAT I ONCE FELT VERY PROTECTED IN.

NHTSA ID

10735385

Incident

Jul 21, 2015

Mileage

86,000 mi

WHEN PURCHASED USED 2 YRS OLD [XXX], I NOTICED A CRACK IN THE MIDDLE OF THE LIFTGATE. I HAVE OWNED THIS VEHICLE FOR ALMOST 7YRS AND HAVE TAKEN VERY GOOD CARE OF IT, BUT I NOW HAVE 3 CRACKS IN THE LIFTGATE. IT SEEMS TO BE VERY THIN ACROSS THE BOTTOM OF THE BACK WINDOW AND EVERY TIME YOU OPEN AND CLOSE THE WINDOW, IT PUTS STRESS ACROSS THE BOTTOM OF IT. THIS SHOULD BE A RECALL BECAUSE THERE ARE A LOT OF OTHER OWNERS WITH THE SAME PROBLEM AND OBVIOUSLY THIS IS A DEFECT!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR UPDATED 4/19/2016 *JS

NHTSA ID

10690330

Incident

Aug 24, 2007

Mileage

36,000 mi

The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.

FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE

LOW TIRE INDICATOR ON - TPMS SYSTEM SENSOR WAKE UP. *TT

ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE (DTC) PEWEE, P0302, P0303, P0304, P0305, P0306, P0307, P0308, AND P0316. *TT

MALFUNCTION INDICATOR LAMP ON WITH PCM DIAGNOSTIC TROUBLE CODE P0463 AND/OR IC DIAGNOSTIC TROUBLE CODE B1201 - FUEL GAUGE DROPS TO EMPTY OR SLOW TO UPDATE AFTER REFUELING. *TT

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT