2022 Lincoln Corsair PHEV Owner Complaints

I was driving down the highway at around 70 mph, with one passenger. There had been no indications that anything was wrong with the vehicle. Then I noticed the car slowing down though I had not let up on the gas, which I now understand is called 'limp mode'. The screen said 'service vehicle soon'. It kept slowing down while I carefully pulled to the side of the road. Thankfully I had been in the right lane. This was not a very safe place to be, relatively close to an overpass. I turned off the car and let it rest for a few minutes. Then I started it and tried the gas. It did speed up to about 35 mph, so I kept going to try and get past the area of high traffic and little shoulder. Once I got past the overpass, I pulled over again. I stopped, let it rest and then started up again. Still it only went up to about 35 mph, but I was able to get to an exit and pull into a parking lot. I then called a tow truck and eventually they took the car to the closest Lincoln dealership. After reviewing the car, the dealership's service center said they did not see anything wrong with the vehicle and could not reproduce the issue. They did say that records showed a similar incident had happened in May 2025, under a different owner. They suggested I take the vehicle home and come back if it happened again. Then on July 12th, I was driving down I75 again, this time in the left lane and with my son in the car, and the same thing happened. The car started slowing down and the screen said 'service vehicle soon'. I was able to pull off at the next exit and let the car rest. We happened to be only 1.6 miles from the Lincoln dealership, so I carefully drove the car there and left it since they were closed. They later said that the service bulletin suggested that if they could drive the car 4 times without an issue, they could clear the issue. I looked further into it and found that there is an open recall on the vehicle, with no remedy, Open Safety Recall 25SC4. I do NOT feel safe.

NHTSA ID

11751963

Incident

May 14, 2026

Our 2022 Corsair Hybrid has been at Haldeman Ford in Kutztown, PA since October 29th. We will not drive it to our house because it is unsafe at any speed. The engine in this car has suddenly failed at least seven or eight times while being driven. At least three of these failures occurred when being driven by different Haldeman Ford technicians. They saw nothing that would explain the engine’s sudden catastrophic failure. The technicians cannot find out what is wrong with the vehicle and agree that the vehicle is dangerous to drive. Prior recall for engine failure stated that the car was not to be driven but also not to be plugged in because there was risk of fire. That recall is proof that the car was a lemon from the day it left the factory. It has been gently driven and has less than 16,000 miles. If the Corsair were to be said to be “repaired” at this point it would then require us to then act as crash test dummies with no guarantee that the engine would not stop suddenly - resulting in catastrophic injury or death. I could not ethically sell this car going forward. NOTE: On November 20, 2025 the NHTSA issued Manufacturer Recall Number 25SC4 - NHTSA Recall Number 25V789. This recall is for a manufacturing defect in the high voltage battery cells to cause an internal short circuit. This recall cites lost of motive power with increased risks in both crash and fire issues. This car has had several recalls in the past as well also dealing with fire and safety problems from the factory.

NHTSA ID

11700991

Incident

Oct 17, 2025

On the morning of [XXX], I lost power while driving. The dashboard remained lit, however, I had no ability to restart the car. The car was towed to the nearest dealership. Lincoln has opened case # [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11661063

Incident

May 9, 2025

The contact owns a 2022 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 24V954000 (Electrical System); however, the part to do the recall repair was unavailable. The local dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11660452

Incident

May 12, 2025

The contact owns a 2022 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 24V954000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11659270

Incident

Dec 5, 2024

The contact owns a 2022 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 24V954000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11657471

Incident

Jan 31, 2025

The contact owns a 2022 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 24V954000(Electrical System); however, the part to do the repair was not yet available. No further information was available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11654072

Incident

Apr 11, 2025

The contact owns a 2022 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 24V954000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11650525

Incident

Mar 25, 2025

The contact owns a 2022 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 24V954000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that while driving at approximately 73 MPH, the vehicle independently decelerated to approximately 60 MPH. No warning light was illuminated. The contact stated that the vehicle had approximately 15 miles of hybrid battery; however, the vehicle independently switched to the fuel. The vehicle was taken to a local dealer where it was diagnosed that the transmission oil pump had independently switched to Safe Mode and needed to be replaced. The vehicle was repaired under warranty. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 11,000. VIN tool confirms parts not available.

NHTSA ID

11637978

Incident

Nov 15, 2024

Mileage

11,000 mi

I was driving to work via the [XXX] in California when at approximately 6:40am I felt a jerking motion in my 2022 Lincoln Corsair Grand Touring (PHEv) and then immediately began receiving various warning lights and chimes indicating an issue. The vehicle was losing power and I was safely able to exit the freeway and pull to the side of the road. There were numerous warning indicators activated, including Service Engine Soon, Hill Start Assist failure, Pre-Collision Assist failure, EV Battery not available, and others. I exited the vehicle to ensure that there was not any visible physical damage, and did not find anything. I checked the Owners Manual for the warnings and it indicated that if the vehicle was able to be driven, it could but with caution. I proceeded to drive to work, approximately 4.7 miles away. The vehicle could not be driven over 35 MPH without violently shaking, along with a mechanical grinding noise. Drive Control was also not active and the vehicle felt like it had no suspension. Estimated repair time was approximately 1 week per the Lincoln Concierge (LC), and no root problem had been identified at the time. On Monday, 10/28 I followed up via text to the LC for an update and was informed that they checked with the Transmission technician and they had started to “tear down the transmission to find the fault.” On 10/30, I asked for another update and to inform the LC that I had a preplanned vacation to Big Bear, CA on 11/7/24 and hoped to have it back before then. On 10/31, the LC informed me that the Tech had “ordered a new transmission today and should be here by Tuesday [11/5/24].” On 11/5, I followed up via text to the LC and was informed that the new arrival date for the transmission would be 11/6 or 11/7. Because I did not have my Corsair and wanted to be cautious of the miles on the loaner, we took an alternate vehicle for the road trip. See PDF attached for additional details. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11637810

Incident

Oct 22, 2024

The contact owns a 2022 Lincoln Corsair. The contact stated while refueling the vehicle, there was fuel dripping out of the filler neck onto the ground. The contact stated that the failure had occurred two times. The vehicle was taken to the dealer where it was diagnosed with a failed fuel tank filler pipe. The contact was informed that the fuel tank filler pipe needed to be replaced. The vehicle was repaired. The manufacturer was not made aware of the failure. The contact was informed that the repair was not covered under Technical Service Bulletin: 22-2176. The failure mileage was approximately 3,800.

NHTSA ID

11615585

Incident

Sep 13, 2024

Mileage

3,800 mi

The contact owns a 2022 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 23V380000 (Engine) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11566528

Incident

Jan 19, 2024

The contact owns a 2022 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 23V380000 (Engine) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11558315

Incident

Dec 4, 2023

The contact owns a 2022 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 23V380000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted and determined parts were not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that parts were not available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11554905

Incident

Nov 13, 2023

Electrical connector and wiring harness melted due to close proximity to the right rear exhaust pipe. Experiencing intermittent parking brake fault messages that results in a check engine light, when climbing a grade longer then 1 mile long. Suspect extra heat produced from engine load had damaged some of the internal wires of the connector. This first occurred with 2000 miles on the odometer, 2 months old. Lincoln started producing these GT model Corsairs with a heat shield missing (that was part of 2021 and some 2022 models) that probably would have protected this wiring harness. Not sure what circuits are running through this connector, but their are a lot of wires in it. The connector is melted enough that it probably cannot be unplugged anymore. There is melted plastic residue on the exhaust pipe from the connector. Dealer has confirmed the melted connecter and zip tied the connector further away from the exhaust pipe as a temporary fix till they can investigate further.

NHTSA ID

11553328

Incident

Dec 23, 2022

Manufacturer Recall Number22S47 NHTSA Recall Number22V484 Dealer keeps providing excuses as to why this recall has not been completed after taking vehicle to them 3 times. Not correcting in a timely manner.

NHTSA ID

11551644

Incident

Oct 24, 2023

The contact owns a 2022 Lincoln Corsair. The contact received notification of NHTSA Campaign Numbers: 23V342000 (Back Over Prevention) and 23V38000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted and determined that the parts were not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that the parts were not available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11550668

Incident

Oct 18, 2023

The contact owns a 2022 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) and 23V380000 (Engine) however, the parts to do the recall repairs were not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11533980

Incident

Jul 22, 2023

Engine stops randomly and without warning while vehicle is in motion. Vehicle is available to inspect. This has happened on city streets and the highway. Trailing vehicles run the risk of a rear end collision at high speeds. The Lincoln Service Department has been unable to replicate this system failure. Reported to the Ford/Lincoln service department multiple times. They have inspected the vehicle multiple times. NO warning at any time.

NHTSA ID

11532864

Incident

Jul 4, 2023

The contact owns a 2022 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 23V380000 (Engine) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11532733

Incident

Jul 17, 2023

After driving for ten hours, I parked. The next morning, the SUV started normally. One minute later, the check engine light came on, citing "air may be in present in the cooling system". Then, the 'engine coolant over-temperature' warning came on less than two hours later. I took itto the dealer the next morning. They charged me to diagnose the situation. The coolant hose for the electric motor broke underneath the car. It caused the electric motor to overheat, which could lead to a fire. Had this happened in a remote area, occupants can become stranded.

NHTSA ID

11516291

Incident

Apr 6, 2023

Electrical System. Yes. While driving in traffic both on surface streets and the freeway the power in my vehicle stopped. The vehicle went from Drive to Park on its own. The battery light came on. The Start/Stop light went from solid green to blinking green. Vehicles around me had to stop suddenly to avoid a collision and the wait until I could restart the vehicle. This has happened a few times. No. No.

NHTSA ID

11512303

Incident

Mar 9, 2023